Effects of smoking or baking procedures during sausage processing on the formation of heterocyclic amines measured using UPLC-MS/MS

Effects of Smoking Temperature, Smoking Time, and Type of Wood Sawdust on Polycyclic Aromatic Hydrocarbon Accumulation Levels in Directly Smoked Pork Sausages

Smoking is an excellent food preservation method but also a source of contamination of foodstuffs with carcinogenic polycyclic aromatic hydrocarbons (PAHs). Herein we investigated the influence of smoking temperature, smoking time, and type of wood sawdust used as smoke source on PAH levels attained through controlled smoking of pork sausages. Four PAHs (benz[a]anthracene, chrysene, benzo[b]fluoranthene, benzo[a]pyrene) were monitored, as required by European Commission Regulation 835/2011. PAH concentrations increased continuously both with higher temperatures (55-95 °C) and with longer smoking periods (2-9 h), although the level of benzo[a]pyrene exhibited a tendency to plateau after 6 h. Among seven types of hardwoods tested, plum, alder, and birch yielded PAH concentrations considerably higher than that of commonly used beech, and oak showed similar levels to beech while apple and, to a lesser extent, walnut caused lower levels of sausage contamination. These findings could guide the establishment of good practices in the smoked meat industry.

Inhibitory effects of Portulaca oleracea L. and selected flavonoid ingredients on heterocyclic amines in roast beef patties and Density Function Theory calculation of binding between heterocyclic amines intermediates and flavonoids

The inhibitory effects of Portulaca oleracea L. (PO) and its flavonoid ingredients on the formation of heterocyclic amines (HAs) in roast beef patties were investigated. Ten HAs were found in control patties, and the total content was 212.73 ± 7.13 ng/g. With the addition of PO (1%, 5%, and 10%, w/w), HAs decreased by 62.39%, 68.03%, and 73.75%, respectively. The main flavonoid ingredients (rutin, hesperidin, and flavanone) also present a similar inhibitory effect. The Density Function Theory (DFT) methods were adopted to investigate the inhibitory mechanism. These ingredients bonded with the intermediate to block the formation of norharman. Both experimental and calculated data of the ingredients were analyzed on their HAs inhibitory capacity. Our results provide a novel and valuable strategy to reduce HAs via a low additive level of medicinal and edible plants. And the correlation between experimental and calculated data could be applied to predict the inhibitory ability of inhibitors.

Predictive Correlation between Apparent Sensory Properties and the Formation of Heterocyclic Amines in Chicken Breast as a Function of Grilling Temperature and Time

In the present set of experiments, we studied the correlation between the heterocyclic amine (HCA) concentration and the color changes of the chicken breast with or without skin during grilling under open or closed conditions as a function of the applied temperature and time. The concentration of the HCAs formed during grilling was measured by a validated LC–MS/MS method, whereas the color changes were determined either instrumentally or by visual observation. In general, higher temperatures and longer heat treatment times resulted in a more substantial HCA formation, especially on the surface of the samples and in the skin, where the total levels reached 746 ng/g. Results of regression analysis demonstrate a strong correlation (r > 0.7) between the HCA content of the grilled chicken breast and the L* and a* values indicating the significance of brightness and the red parameter of the color scale, respectively. In the case of open grilling, the skinless breast samples showed correlation (r > 0.7) between the HCA content and the color analysis results in both the full sample and the crust, respectively. Breast samples with skin exhibited the same level of correlation when they were grilled closed. In the case of open grilling the breast with skin, and closed-grilling the skinless breast, the linear regression analysis yielded a weaker correlation (0.7 > r > 0.4 or less) between the HCA concentrations and the color. Our results demonstrate that there is a predictive correlation between the color changes perceptible for the consumers and the HCA formation during grilling of chicken breast as a function of time and temperature depending on the type of grilling and the presence of skin.