Aliphatic SPI charge-transfer complex hybrid films for high temperature polymer electrolyte membrane fuel cells

Novel Side-Chain Type Sulfonated Poly(phenylquinoxaline) Proton Exchange Membranes for Direct Methanol Fuel Cells

Side-chain type sulfonated poly(phenylquinoxaline) (SPPQ)-based proton exchange membranes (PEMs) with different ionic exchange capacity (IEC) were successfully synthesized by copolymerization from 4,4'-bis (2-diphenyletherethylenedione) diphenyl ether, 4,4'-bis (2-phenylethylenedione) diphenyl ether and 3,3',4,4'-tetraaminobiphenyl, and post-sulfonation process. The sulfonic acid groups were precisely grafted onto the p-position of phenoxy groups in the side chain of PPQ after the convenient condition of the post-sulfonation process, which was confirmed by ¹H NMR spectra and FTIR. The sulfonic acid groups of side-chain type SPPQ degraded at around 325 °C, and their maximum stress was higher than 47 MPa, indicating great thermal and mechanical stability. The water uptake increased with the increasing IEC and temperature. The size change in their plane direction was shown to be lower than 6%, indicating the stability of membrane electrode assembly. The SPPQ PEMs displayed higher proton conductivity than that of main chain. In the single cell test, the maximum power density of side-chain type SPPQ-5 was 63.8 mW cm^-2 at 20 wt% methanol solution and O₂ at 60 °C, which is largely higher than 18.4 mW cm^-2 of NR212 under the same conditions. The SPPQ PEMs showed high performance (62.8 mW cm^-2) even when the methanol concentration was as high as 30 wt%.

Sulfonated poly (arylene ether sulfone)-graft-sulfonated poly (vinyl alcohol) proton exchange membranes: Improved proton selectivity

Aldehyde terminated sulfonated poly (arylene ether sulfone) (SPAES-CHO) is prepared by a series of nucleophilic substitution reaction based on SPAES in this paper. Novel SPAES-graft-SPVA (SPAES-g-SPVA) membranes are fabricated by acetal reaction between SPAES-CHO and different amounts of sulfonated poly (vinyl alcohol) (SPVA). The 1H-NMR and FTIR indicate the successful preparation of SPAES-CHO and SPAES-g-SPVA membranes. With the introduction of SPVA, the SPAES-g-SPVA membranes have much lower methanol permeability than pure SPAES membrane and Nafion117 membrane. The methanol permeability coefficients of the SPAES-g-SPVA membranes decrease from 3.41 × 10−7 cm2 s−1 to 1.67 × 10−7 cm2 s−1 with the increase of SPVA content. And the proton conductivity of all the membranes is higher than 15 mS cm−1 at 25°C. Moreover, SPAES-g-SPVA membranes exhibit high proton selectivity. Especially, SPAES-g-SPVA-30% membrane has the highest proton selectivity, which is nearly five times higher than Nafion117.