Urinary methylchloroform rather than urinary metabolites as an indicator of occupational exposure to methylchloroform

Estimation of biological occupational exposure limit values for selected organic solvents from logartihm of octarol water partition coefficient

OBJECTIVES

For several organic solvents (solvents in short), biological occupational exposure limits (BOELs) have been established for un-metabolized solvents in urine, based on the solvent exposure-urinary excretion relationship. This study was initiated to investigate the possibiliy of estimating a BOEL from the Pow (the partition coefficient between n-octyl alcohol and water), a physico-chemical parameter.

METHODS

Data were available in the literatures for exposure-excretion relationship with regard to 10 solvents for men and 7 solvents for women.

RESULTS

Statistical analysis revealed that the slopes (after correction for molecular weights and logarithmic conversion) of the exposure-excretion regression lines linearly correlated (p<0.01) with the log Pow values the respective solvents. No significant difference (p>0.05) was observed between men and women, and it was acceptable to combine the data for the two sexes. Thus the log Pow-log slope relation was represented by a single equation for both sexes. Based on the observations, procedures were established to estimate BOEL values from Pow. Successful estimations of BOELs for styrene, tetrahydrofuran and m-xylene (a representative of xylene isomers) were calculated as examples.

CONCLUSIONS

The present study proposed promising procedures for estimation of a BOEL from the Pow.

Validation of urine density correction in cases of hippuric acid and un-metabolized toluene in urine of workers exposed to toluene

To investigate if it is appropriate to apply urine density correction when a urine sample is dense or dilute. Data on hippuric acid (HA-U), toluene (Tol-U), creatinine (CR) and specific gravity (SG) in end-of-shift urine samples and exposure to air-borne toluene were cited from previous publications. In practice, 837 cases were available, and they were classified into dense, intermediate and dilute groups taking 0.3 and 3.0 g/l of CR and 1.010 and 1.030 of SG as cut-off points. Lines of regression of HA-U and Tol-U (as observed, CR-corrected or SG-corrected) with air-borne toluene were calculated for each density groups, and correlation coefficients (CCs) were compared. The dense groups gave CCs similar to those of the intermediate groups. Dilute versus intermediate group comparison also gave promising results. These conclusions were however based primarily on the findings with observed values, because the numbers of cases in the dilute or dense group were limited when CR- or SG-correction was applied. Literature survey showed that urine density correction does not always improve the correlation between solvents in air and exposure makers in urine. It was concluded that no correction for urine density may be necessary in evaluating HA-U and Tol-U in dense (and probably also dilute) urine samples as markers of occupational toluene exposure. Just in case when correction for urine density is desired for any reason, SG-correction may be recommended.

Gases and organic solvents in urine as biomarkers of occupational exposure: a review

A brief review of urine analysis in studies of occupational exposure to volatile organic compounds and gases is provided. Analysis of exhaled breath for volatile compounds does not have a long history in occupational medicine. A number of studies has been undertaken since the 1980s, and the methods are well enough accepted to be put forward as biological equivalents of threshold limit values (TLVs) for some volatile organic compounds (VOCs) such as acetone; methanol; methyl ethyl ketone (MEK); methyl isobutyl ketone (MIBK); tetrahydrofurane; dichloromethane. In the last 20 years many scientific articles have shown that the urinary concentrations of unchanged solvents are correlated with environmental exposure and could be used for biological monitoring. The use of urine analysis of unchanged solvents in occupational applications is not yet widespread. Nonetheless, in the short time since its application, a number of important discoveries has been made, and the future appears bright for this branch of analysis. In this paper, the basic concepts and methodology of urine analysis are briefly presented with a critical revision of the literature on this matter. The excretion mechanisms of organic solvents in urine are discussed, with regard to biological variability, and the future directions of research are described.

The urinary excretion of solvents and gases for the biological monitoring of occupational exposure: a review

'In the field' application of the measurement of urinary excretion of unmodified solvent for the biological monitoring of exposed workers has been investigated in many recent papers. The results obtained for several solvents are reviewed. The values of correlation coefficients (r) and regression lines obtained for benzene, toluene, xylene, styrene, n-hexane, cyclohexane, 2- and 3-methylpentane, methyl chloride, tetrachloroethylene, carbon tetrachloride, methyl chloroform, p-dichlorobenzene, nitrous oxide, halothane, isoflurane, enflurane, acetone, methyl ethyl ketone and methyl isobutyl ketone are presented. The correlations observed were generally good: r values range from 0.50-0.97, and the majority are between 0.84 and 0.90. The regression lines reported for the same solvent in different studies present some variability: this is possibly due to an inadequate control of factors influencing the relationship between external dose and absorption, such as differences in body burden, work load, individual characteristics, etc. These factors are discussed. As a whole, results reported in the literature show that measuring of urinary excretion of unmodified solvents provides a highly sensitive and specific exposure index, and can also be applied for the biological monitoring of occupational exposure to low levels of solvents or to solvent mixtures. Nevertheless, for an adequate assessment of biological limit values, further studies evaluating the reproducibility of regression lines are needed, given that the aspects influencing the correlation between external dose and urinary excretion are fully controlled. Another crucial aspect is the correlation with early effects: even though this has yet to be evaluated for several solvents, for others such as styrene and perchloroethylene a good correlation was obtained, further supporting the usefulness of the measurement of urinary excretion of solvent for the biological monitoring of occupational exposure.

Toluene itself as the best urinary marker of toluene exposure

Head-space gas chromatography (GC) and high-performance liquid chromatography (HPLC) (with fluorescence detectors) methods were developed for toluene (TOL-U) and o-cresol (CR-U) in urine, respectively. In order to identify the most sensitive urinary indicator of occupational exposure to toluene vapor (TOL-A) among TOL-U, CR-U, and hippuric acid in urine (HA-U), the two methods together with an HPLC (with untraviolet detectors) method for determination of HA-U were applied in the analysis of end-of-shift urine samples from 115 solvent-exposed workers (exposed to toluene at 4 ppm as geometric mean). Regression analysis showed that TOL-U correlated with TOL-A with a significantly higher correlation coefficient than did HA-U or CR-U. With regard to the TOL-A concentrations at which the exposed subjects could be separated from the nonexposed by the analyte, TOL-U achieved separation at < 10 ppm TOL-A, whereas both HA-U and CR-U did so only when TOL-A was 30 ppm or even higher. The ratio of the analyte concentrations at 50 ppm TOL-A to those at 0 ppm TOL-A was also highest for TOL-U. Overall, the results suggest that TOL-U is a better marker of exposure to toluene vapor than HA-U or CR-U.