[Reconstruction after extended partial laryngeal and hypopharyngeal resections. A new method with rib cartilage, chondrosynthesis and free radial transplants]

Laryngotracheal reconstruction using prefabricated and preconditioned composite radial forearm free flaps

OBJECTIVE

Total or subtotal laryngectomy performed as surgical treatment of locally advanced laryngeal tumors requires a permanent laryngostomy or tracheostomy, and are both associated with severe and lifelong disability. The hitherto published reconstructive methods for the rehabilitation of patients after subtotal anterior laryngotracheal resection of extended laryngotracheal malignancies have not been thoroughly convincing.

METHODS

We present a successful method of extended laryngotracheal reconstruction that combines modern surgical and biomedical techniques.

RESULTS

A stable three-dimensional anterior neolarynx was prefabricated, including the use of vacuum-assisted prelamination and preconditioning of a composite radial forearm free flap, which was then transferred to the neck and vascularized by microvascular anastomosis to the cervical vessels. This reconstructive procedure permitted the restoration of a stable laryngotracheal conduit in two cases, with the subsequent successful closure of the tracheo-laryngostomy.

CONCLUSION

In the reported cases the pre- or post-operative irradiation did not compromise the success of reconstruction. Not only did our technique facilitate the rehabilitation of patients suffering from drawbacks of the laryngo-tracheofissure, but it also assisted in avoiding total laryngectomy in cases of advanced anterior laryngeal cancer by extending the indications for subtotal anterior laryngeal resections followed by reconstructive surgery.

Extrusion forces of resorbable tacks and titanium screws in laryngeal chondrosynthesis

Laryngotracheal trauma, partial laryngectomy and phonosurgery may necessitate reconstruction of the cartilaginous skeleton to ensure the quality of respiration and voice. The present report focuses on initial experience gained with a new resorbable material for plates and tacks that allows chondrosynthesis of the laryngeal skeleton. A comparison of the extrusion forces necessary to pull out the resorbable tacks versus conventional titanium screws and the degree of deformation until failure represent the experimental parameters of reconstruction quality under investigation. The PolyMax system (Synthes, Oberdorf, Switzerland) was used in a human cadaver dissection. Sixteen tacks with a diameter of 1.5 mm and sixteen titanium screws with a diameter of 1 mm were placed into the two wings of the thyroid cartilage. Extrusion forces and the degree of deformation occurring until mechanical failure of the device-body interface were measured for the two types of fixation systems. Results in N and mm were compared using a two-sided Wilcoxon test. Neither variable differed significantly between the two groups. However, within the two groups, the necessary strength to pull the tacks or the screws out of the cartilage varied markedly depending on both the inhomogeneous quality of cartilage and the degree of calcification. The PolyMax system with the tacks is recommended as an effective tool for reconstructing the cartilaginous skeleton of the larynx and the trachea with the inherent advantage of resorption as well as avoidance of a second surgery for material removal.