Spray-dried Ancellotta red wine: natural colorant with potential for food applications

Phenolic composition and sensory dynamic profile of chocolate samples enriched with red wine and blueberry powders

Cabernet Sauvignon (CS) and a combination of Cabernet Sauvignon with blueberry extract (CS + B), were spray dried (using maltodextrin DE10, 13.5% w/w as a carrier) to obtain two types of phenolic-rich powders. The addition of blueberry to CS increased phenolic compounds content by 16%. Eight chocolate formulations were obtained by modifying concentrations of cocoa solids, cocoa butter, and sugar. Six of the samples were added with 10% w/w of phenolic-rich powder, while two of them remained as powder-free controls. The anthocyanin and flavan-3-ol profiles of chocolates were determined by HPLC-DAD-MS and HPLC-MS, respectively. In addition, the sensory dynamic profile of samples was assessed by Temporal Dominance of Sensations with a consumer panel. Results showed that the addition of phenolic-rich powders produced a significant increase in the anthocyanin composition obtaining the highest anthocyanin content in the white chocolate added with CS + B powder. On the other hand, adding 10% of CS powder to dark chocolate (55% cocoa pellets) did not result in a significant increase in phenolic compounds. The addition of phenolic-rich powders to chocolates influenced visual color, texture, and taste, leading to new products with distinctive characteristics and increasing the possibility of using phenolic-rich powders as innovative and healthy ingredients.

Effect of Encapsulation Processes by Freeze and Spray Drying on the Antioxidant Properties of Red Wine from cv. Listan Prieto and Syrah

BACKGROUND

Wine antioxidants are linked to cardiovascular disease prevention, thus are highly valued by the healthy food market. The dehydration process removes alcohol and water from wine and allows it to extend its shelf life, while encapsulation can help preserve physical-chemical and antioxidant properties. Moreover, information on the effect of wine drying and encapsulation on non-anthocyanin phenolic compounds is limited in the literature.

METHODS

Listan Prieto and Syrah (Vitis vinifera L.) wines were dehydrated and converted into powder by freezing and spray drying. Powdered wines were subjected to water activity, pH, soluble solids, color, and phenolic compounds analysis.

RESULTS

Freeze-drying process produced powdered wines with higher pH than the spray-drying process. Powdered wines made by these processes presented similar water activity and soluble solids. Powdered wines did not show statistical differences in trans-resveratrol, hydrocinnamic acids, phloretin, kaempferol, and quercetin content according to their dehydration process. In addition, powdered wines significantly concentrated hydrocinnamic acid and quercetin when compared to non-dealcoholized and dealcoholized wine samples.

CONCLUSIONS

The results suggest that the dehydration process does not negatively modify the characteristics of the wine, and it retains a significant concentration of phenolic compounds. Therefore, powdered wines have an interesting potential to be used as a natural source of antioxidants for food supplementation.

Anthocyanin content and storage stability of spray/freeze drying microencapsulated anthocyanins from berries: a review

A comprehensive literature search for articles published on spray and freeze-dried anthocyanins from a large variety of berries was performed. Out of a total of two-hundred and eight collected values, anthocyanin content in encapsulates had a 120-fold variation depending on the raw material and type of encapsulating agents. Highest observed anthocyanin concentration amounted to about 3500 mg/100 g powder. In most cases increasing the amount of encapsulant agents led to a noticeable reduction in the concentration of anthocyanins, this being attributable to a predominance of the dilution effect. Retention of encapsulated anthocyanins after storage at 25 °C (in darkness) for periods between 90 and 180 days were in the range of 80–67%, as long as the water activity (aw) was 0.33 or less. Some predicted values of half-time (t1/2) from literature must be taken with precaution since in many cases they were derived from experimental measurements taken at storage times smaller than predicted half times. Anthocyanin degradation during storage occurred even below the glass transition temperature (Tg) of the amorphous matrices.

Advanced fractionation process for wine-based products diversification

Wine fractionation is an old practice widely applied for many reasons, including the production of food-grade alcohol and spirits, alcohol-reduced wines and beverages, functional products, and aromas. The purpose is the need to satisfy different lifestyles and legal constraints. The raw material, usually called industrial wine, includes wine overproduction and wine not used as such: mainly table wine, the fermented juice of unsold table grapes, and quality wine. Three technologies are currently in use: Vacuum distillation, Reverse osmosis in dialyzing mode, and the Spinning cone column. The process developed in this work results from the integration of a multistage reverse osmosis section operating in dialyzing mode, with the Atmospheric distillation of the permeate stream; the two most applied technologies for fractionating liquid mixtures. This process allows the fractionation of the wine into four products (the vegetation water, the azeotropic Ethanol, a concentrated aqueous solution of the solid extract, and a concentrated alcoholic solution of volatile aroma compounds) while preserving sensorial, nutritional and functional properties of the individual compounds. Then, the proper recombination of these products gives rise to a wide variety of wine-based products to meet the specifications of each market segment. The process is environmentally friendly and, in comparison with the competitors, is less energy-intensive, other than resilient and flexible regarding the production potentiality.