Cadmium effects on transcriptional expression of rhlB/rhlC genes and congener distribution of monorhamnolipid and dirhamnolipid in Pseudomonas aeruginosa IGB83

Limited Role of Rhamnolipids on Cadmium Resistance for an Endogenous-Secretion Bacterium

Rhamnolipids, a type of biosurfactant, represent a potential strategy for both enhancing organismic resistance and in situ remediation of heavy metals contaminations. In-depth study of the mechanism of rhamnolipids synthesis in response to heavy metals stress, is indispensable for a wide use of biosurfactant-secreting microbes in bioremediation. In this study, we employed the wild-type and the rhlAB deficient strain (ΔrhlAB) of Pseudomonas aeruginosa, a prototypal rhamnolipids-producing soil microorganism, to investigate its responses to cadmium resistance based on its physicochemical, and physiological properties. Compared with the wild-type strain, the ΔrhlAB were more sensitive to Cd-stress at low Cd concentration (<50 mg/L), whereas there was little difference in sensitivity at higher Cd concentrations, as shown by spot titers and cell viability assays. Secreted rhamnolipids reduced intracellular Cd²⁺ accumulation to alleviate Cd²⁺ stress, whereas endogenous rhamnolipids played a limited role in alleviating Cd²⁺ stress. Synthesized rhamnolipids exhibited a higher critical micelle concentration (CMC) (674.1 mg/L) and lower emulsification index (4.7%) under high Cd-stress, while these parameters showed no obvious changes. High Cd-stress resulted in high hydrophilic wild-type bacterial surface and lower bioremediation ability. This study could advance a deeper understanding of the mechanism of cadmium resistance and provide a theoretical foundation for the application of biosurfactant and biosurfactant-secreted bacterium in contaminant bioremediation.

Bacterial Resistance against Heavy Metals in Pseudomonas aeruginosa RW9 Involving Hexavalent Chromium Removal

Pseudomonas aeruginosa RW9 is a promising candidate for the bioremediation of chromium hexavalent (Cr(VI)) pollution, as it resists a high concentration of up to 60 mg/L of Cr(VI). Leaving cells exposed to Cr(VI) has large bioreduction potential, implying its capacity to extract the ions from the contaminated medium. In this study, the tolerance for and distribution of Cr(VI) were investigated to identify the cells’ adaptation and removal strategies. Micro-characterization analysis was conducted to assess the effect of Cr(VI) on the cells. The cells’ elongation was observed at higher Cr(VI) concentrations, signifying their adaptation to DNA damage caused by Cr(VI) toxicity. Cr(VI) distribution analysis showed that the strain developed a complex mechanism to adapt to Cr(VI), based on surface-bound (0.46 mg/L), intracellularly accumulated (1.24 mg/L) and extracellular sequestration (6.74 mg/L), which accounted for 85% of the removal efficiency. The extracellular sequestration might be attributable to the production of metabolites, in accordance with the fourier-transform infrared spectroscopy (FTIR) spectra and orcinol analysis that confirmed the presence of a glycolipid biosurfactant, rhamnolipid. Remarkably, the rhamnolipid was slightly induced in the presence of Cr(VI). From the data obtained, it was confirmed that this local strain is well equipped to survive high doses of Cr(VI) and has great potential for application in Cr(VI) bioremediation.

Effect of bioaugmentation on digestate metal concentrations in anaerobic digestion of sewage sludge

This study examined the influence of bioaugmentation on metal concentrations (aluminum, cadmium, chromium, cobalt, copper, iron, lead, manganese, molybdenum, nickel and zinc) in anaerobically digested sewage sludge. To improve the digestion efficiency, bioaugmentation with a mixture of wild-living Archaea and Bacteria (MAB) from Yellowstone National Park, USA, was used. The total concentration of all metals was higher in the digestate than in the feedstock. During anaerobic digestion, the percent increase in the concentration of most of metals was slightly higher in the bioaugmented runs than in the un-augmented runs, but these differences were not statistically significant. However, the percent increase in cadmium and cobalt concentration was significantly higher in the bioaugmented runs than in the un-augmented runs. At MAB doses of 9 and 13% v/v, cadmium concentration in the digestate was 211 and 308% higher than in the feedstock, respectively, and cobalt concentration was 138 and 165%, respectively. Bioaugmentation increased over 4 times the percentage of Pseudomonas sp. in the biomass that are able to efficiently accumulate metals by both extracellular adsorption and intracellular uptake. Biogas production was not affected by the increased metal concentrations. In conclusion, bioaugmentation increased the concentration of metals in dry sludge, which means that it could potentially have negative effects on the environment.

Effect of Re-acidification on Buffalo Grass Rhizosphere and Bulk Microbial Communities During Phytostabilization of Metalliferous Mine Tailings

Phytostabilized highly acidic, pyritic mine tailings are susceptible to re-acidification over time despite initial addition of neutralizing amendments. Studies examining plant-associated microbial dynamics during re-acidification of phytostabilized regions are sparse. To address this, we characterized the rhizosphere and bulk bacterial communities of buffalo grass used in the phytostabilization of metalliferous, pyritic mine tailings undergoing re-acidification at the Iron King Mine and Humboldt Smelter Superfund Site in Dewey-Humboldt, AZ. Plant-associated substrates representing a broad pH range (2.35-7.76) were sampled to (1) compare the microbial diversity and community composition of rhizosphere and bulk compartments across a pH gradient, and (2) characterize how re-acidification affects the abundance and activity of the most abundant plant growth-promoting bacteria (PGPB; including N2-fixing) versus acid-generating bacteria (AGB; including Fe-cycling/S-oxidizing). Results indicated that a shift in microbial diversity and community composition occurred at around pH 4. At higher pH (>4) the species richness and community composition of the rhizosphere and bulk compartments were similar, and PGPB, such as Pseudomonas, Arthrobacter, Devosia, Phyllobacterium, Sinorhizobium, and Hyphomicrobium, were present and active in both compartments with minimal presence of AGB. In comparison, at lower pH (<4) the rhizosphere had a significantly higher number of species than the bulk (p < 0.05) and the compartments had significantly different community composition (unweighted UniFrac; PERMANOVA, p < 0.05). Whereas some PGPB persisted in the rhizosphere at lower pH, including Arthrobacter and Devosia, they were absent from the bulk. Meanwhile, AGB dominated in both compartments; the most abundant were the Fe-oxidizer Leptospirillum and Fe-reducers Acidibacter and Acidiphilium, and the most active was the Fe-reducer Aciditerrimonas. This predominance of AGB at lower pH, and even their minimal presence at higher pH, contributes to acidifying conditions and poses a significant threat to sustainable plant establishment. These findings have implications for phytostabilization field site management and suggest re-application of compost or an alternate buffering material may be required in regions susceptible to re-acidification to maintain a beneficial bacterial community conducive to long-term plant establishment.

Oxygen effects on rhamnolipids production by Pseudomonas aeruginosa

Background

Rhamnolipids are the most extensively studied biosurfactants and has been successfully used in various areas from bioremediation to industrial fields. Rhamnolipids structural composition decide their physicochemical properties. Different physicochemical properties influence their application potential. Rhamnolipids can be produced at both aerobic conditions and anaerobic conditions by Pseudomonas aeruginosa. This study aims to evaluate the oxygen effects on the rhamnolipids yield, structural composition, physicochemical properties and the rhl-genes expression in P. aeruginosa SG. Results will guide researchers to regulate microbial cells to synthesize rhamnolipids with different activity according to diverse application requirements.

Results

Quantitative real-time PCR analysis revealed that rhlAB genes were down-regulated under anaerobic conditions. Therefore, strain P. aeruginosa SG anaerobically produced less rhamnolipids (0.68 g/L) than that (11.65 g/L) under aerobic conditions when grown in media containing glycerol and nitrate. HPLC–MS analysis showed that aerobically produced rhamnolipids mainly contained Rha-C₈-C₁₀, Rha–Rha-C₁₀-C_12:1 and Rha–Rha-C₈-C₁₀; anaerobically produced rhamnolipids mainly contained Rha-C₁₀-C₁₂ and Rha-C₁₀-C₁₀. Anaerobically produced rhamnolipids contained more mono-rhamnolipids (94.7%) than that (54.8%) in aerobically produced rhamnolipids. rhlC gene was also down-regulated under anaerobic conditions, catalyzing less mono-rhamnolipids to form di-rhamnolipids. Aerobically produced rhamnolipids decreased air–water surface tension (ST) from 72.2 to 27.9 mN/m with critical micelle concentration (CMC) of 60 mg/L; anaerobically produced rhamnolipids reduced ST to 33.1 mN/m with CMC of 80 mg/L. Anaerobically produced rhamnolipids emulsified crude oil with EI₂₄ = 80.3%, and aerobically produced rhamnolipids emulsified crude oil with EI₂₄ = 62.3%. Both two rhamnolipids products retained surface activity (ST < 35.0 mN/m) and emulsifying activity (EI₂₄ > 60.0%) under temperatures (4–121 °C), pH values (4–10) and NaCl concentrations less than 90 g/L.

Conclusions

Oxygen affected the rhl-genes expression in P. aeruginosa, thus altering the rhamnolipids yield, structural composition and physicochemical properties. Rhamnolipids produced at aerobic or anaerobic conditions was structurally distinct. Two rhamnolipids products had different application potential in diverse biotechnologies. Although both rhamnolipids products were thermo-stable and halo-tolerant, aerobically produced rhamnolipids possessed better surface activity, implying its well wetting activity and desorption property; anaerobically produced rhamnolipids exhibited better emulsifying activity, indicating its applicability for enhanced oil recovery and bioremediation of petroleum pollution.

Development and validation of an ultra-performance liquid chromatography tandem mass spectrometry (UPLC-MS/MS) method for the quantitative determination of rhamnolipid congeners

Rhamnolipids (RLs) are synthesised as a complex mixture of congeners comprising either one or two molecules of rhamnose glycosidically linked to a dimer of 3-hydroxy fatty acids varying in chain length and degree of saturation. Currently, HPLC-MS/MS is the most precise and accurate method for RL determination, while accurate quantification is limited. In this study, a rapid ultra pressure liquid chromatography tandem mass spectrometry (UPLC-MS/MS) method was developed and validated for the rapid and quantification of individual RL congeners. Increased RLs specificity was achieved using tandem mass spectrometry in multiple reaction monitoring (MRM) mode which was used to quantify RL isomer pairs such as Rha-Rha-C8-C10/Rha-Rha-C10-C8 which are difficult to resolve chromatographically. UPLC showed an 18-fold reduction in retention time for Rha-Rha-C10-C10 (1.07 min) and a 17-fold reduction for Rha-C10-C10 (1.36), the major rhamnolipids present, compared to HPLC, with a total run time less than 2.2 min. The results show that the linear range for the main RL congeners (Rha-C10-C10 and Rha-Rha-C10-C10) is 0.1 to 100 μg/mL. The LOD and LOQ for Rha-C10-C10 is 0.05 and 0.1 μg/mL and for Rha-Rha-C10-C10 is 0.1 and 0.5 μg/mL, respectively. The method was validated for linearity, intra- and inter-day precision and accuracy in accordance with FDA guidelines. The method was applied for the quantification of 14 individual RL congeners produced by Pseudomonas aeruginosa ST5 and comparison of RLs composition on four different carbon sources. Quantification of the individual congeners showed a conserved congener distribution irrespective of carbon source with a preferential selection for C10 β-hydroxyacids as the lipid component of RLs. The only statistically significant differences detected were between actual RL yields on the various carbon sources.

Dirhamnose-lipid production by recombinant nonpathogenic bacterium Pseudomonas chlororaphis

We previously discovered that Pseudomonas chlororaphis NRRL B-30761 produces monorhamnolipids (R1Ls) with predominantly 3-hydroxydodecenoyl-3-hydroxydecanoate (C12:1-C10) or 3-hydroxydodecanoyl-3-hydroxydecanoate (C12-C10) as the lipid moiety under static growth conditions only. We have now cloned, sequenced, and analyzed in silico the gene locus of NRRL B-30761 containing the putative coding sequences of rhamnosyltransferase chain A (rhlA Pch , 894 bps), rhamnosyltransferase chain B (rhlB Pch , 1272 bps), and N-acyl-homoserine lactone-dependent transcriptional regulatory protein (rhlR Pch , 726 bps). The putative gene products RhlAPch (297 amino acid residues or a.a.), RhlBPch (423 a.a.), and RhlRPch (241 a.a.) only have between 60 and 65% a.a. identities to their respective closest matched homologs in P. aeruginosa. Polymerase chain reaction (PCR)-based assay did not detect the presence of rhamnosyltransferase C gene (rhlC) in P. chlororaphis, suggesting a genetic basis for the lack of dirhamnose-lipid (R2L) synthesis in this organism. We thus genetically constructed an R2L-synthesizing P. chlororaphis by expressing a rhamnosyltransferase C (rhlC) gene of P. aeruginosa using an expression vector (pBS29-P2-gfp) containing a Pseudomonas syringae promoter. The R2L/R1L ratio is 2.4 in the rhamnolipid (RL) sample isolated from the genetically engineered (GE) P. chlororaphis [pBS29-P2-rhlC], in contrast to undetectable R2L in the GE P. chlororaphis [pBS29-P2-gfp] control cells based on LC-MS analysis. The critical micelle concentrations of the R2L and R1L samples from GE P. chlororaphis [pBS29-P2-rhlC] and the control [pBS29-P2-gfp] cells were ca. 0.1 mM, and their minimum surface tensions were ca. 26 mN/m with no significant difference.

Abundance and Activity of 16S rRNA, AmoA and NifH Bacterial Genes During Assisted Phytostabilization of Mine Tailings

Mine tailings in semiarid regions are highly susceptible to erosion and are sources of dust pollution and potential avenues of human exposure to toxic metals. One constraint to revegetation of tailings by phytostabilization is the absence of microbial communities critical for biogeochemical cycling of plant nutrients. The objective of this study was to evaluate specific genes as in situ indicators of biological soil response during phytoremediation. The abundance and activity of 16S rRNA, nifH, and amoA were monitored during a nine month phytostabilization study using buffalo grass and quailbush grown in compost-amended, metalliferous tailings. The compost amendment provided a greater than 5-log increase in bacterial abundance, and survival of this compost-inoculum was more stable in planted treatments. Despite increased abundance, the activity of the introduced community was low, and significant increases were not detected until six and nine months in quailbush, and unplanted compost and buffalo grass treatments, respectively. In addition, increased abundances of nitrogen-fixation (nifH) and ammonia-oxidizing (amoA) genes were observed in rhizospheres of buffalo grass and quailbush, respectively. Thus, plant establishment facilitated the short term stabilization of introduced bacterial biomass and supported the growth of two key nitrogen-cycling populations in compost-amended tailings.

Influence of ferric iron on gene expression and rhamnolipid synthesis during batch cultivation of Pseudomonas aeruginosa PAO1

Bioprocesses based on sustainable resources and rhamnolipids in particular have become increasingly attractive in recent years. These surface-active glycolipids with various chemical and biological properties have diverse biotechnological applications and are naturally produced by Pseudomonas aeruginosa. Their production, however, is tightly governed by a complex growth-dependent regulatory network, one of the major obstacles in the way to upscale production. P. aeruginosa PAO1 was grown in shake flask cultures using varying concentrations of ferric iron. Gene expression was assessed using quantitative PCR. A strong increase in relative expression of the genes for rhamnolipid synthesis, rhlA and rhlC, as well as the genes of the pqs quorum sensing regulon was observed under iron-limiting conditions. Iron repletion on the other hand caused a down-regulation of those genes. Furthermore, gene expression of different iron regulation-related factors, i.e. pvdS, fur and bqsS, was increased in response to iron limitation. Ensuing from these results, a batch cultivation using production medium without any addition of iron was conducted. Both biomass formation and specific growth rates were not impaired compared to normal cultivation conditions. Expression of rhlA, rhlC and pvdS, as well as the gene for the 3-oxo-C12-HSL synthetase, lasI, increased until late stationary growth phase. After this time point, their expression steadily decreased. Expression of the C4-HSL synthetase gene, rhlI, on the other hand, was found to be highly increased during the entire process.

Biosurfactants in agriculture

Agricultural productivity to meet growing demands of human population is a matter of great concern for all countries. Use of green compounds to achieve the sustainable agriculture is the present necessity. This review highlights the enormous use of harsh surfactants in agricultural soil and agrochemical industries. Biosurfactants which are reported to be produced by bacteria, yeasts, and fungi can serve as green surfactants. Biosurfactants are considered to be less toxic and eco-friendly and thus several types of biosurfactants have the potential to be commercially produced for extensive applications in pharmaceutical, cosmetics, and food industries. The biosurfactants synthesized by environmental isolates also has promising role in the agricultural industry. Many rhizosphere and plant associated microbes produce biosurfactant; these biomolecules play vital role in motility, signaling, and biofilm formation, indicating that biosurfactant governs plant–microbe interaction. In agriculture, biosurfactants can be used for plant pathogen elimination and for increasing the bioavailability of nutrient for beneficial plant associated microbes. Biosurfactants can widely be applied for improving the agricultural soil quality by soil remediation. These biomolecules can replace the harsh surfactant presently being used in million dollar pesticide industries. Thus, exploring biosurfactants from environmental isolates for investigating their potential role in plant growth promotion and other related agricultural applications warrants details research. Conventional methods are followed for screening the microbial population for production of biosurfactant. However, molecular methods are fewer in reaching biosurfactants from diverse microbial population and there is need to explore novel biosurfactant from uncultured microbes in soil biosphere by using advanced methodologies like functional metagenomics.

Fatty acid cosubstrates provide β-oxidation precursors for rhamnolipid biosynthesis in Pseudomonas aeruginosa, as evidenced by isotope tracing and gene expression assays

Rhamnolipids have multiple potential applications as "green" surfactants for industry, remediation, and medicine. As a result, they have been intensively investigated to add to our understanding of their biosynthesis and improve yields. Several studies have noted that the addition of a fatty acid cosubstrate increases rhamnolipid yields, but a metabolic explanation has not been offered, partly because biosynthesis studies to date have used sugar or sugar derivatives as the carbon source. The objective of this study was to investigate the role of fatty acid cosubstrates in improving rhamnolipid biosynthesis. A combination of stable isotope tracing and gene expression assays was used to identify lipid precursors and potential lipid metabolic pathways used in rhamnolipid synthesis when fatty acid cosubstrates are present. To this end, we compared the rhamnolipids produced and their yields using either glucose alone or glucose and octadecanoic acid-d(35) as cosubstrates. Using a combination of sugar and fatty acids, the rhamnolipid yield was significantly higher (i.e., doubled) than when glucose was used alone. Two patterns of deuterium incorporation (either 1 or 15 deuterium atoms) in a single Rha-C(10) lipid chain were observed for octadecanoic acid-d(35) treatment, indicating that in the presence of a fatty acid cosubstrate, both de novo fatty acid synthesis and β-oxidation are used to provide lipid precursors for rhamnolipids. Gene expression assays showed a 200- to 600-fold increase in the expression of rhlA and rhlB rhamnolipid biosynthesis genes and a more modest increase of 3- to 4-fold of the fadA β-oxidation pathway gene when octadecanoic acid was present. Taken together, these results suggest that the simultaneous use of de novo fatty acid synthesis and β-oxidation pathways allows for higher production of lipid precursors, resulting in increased rhamnolipid yields.