Poor performance of Enduron polyethylene liner in total hip arthroplasty: a minimum ten-year follow up and ultra-morphological analysis of wear particles

Long-Term Results of Hip Arthroplasty Using Extensive Porous-Coated Stem-A Minimum Follow-Up of 15 Years

Introduction:

We report the clinical and radiographic results of hip arthroplasty using extensive porous-coated stems over 15 years in Korea.

Methods:

This retrospective study included 210 patients (268 hips) who underwent total hip arthroplasties (232 hips) and bipolar hemiarthroplasties (36 hips) between June 1996 and December 2002 for avascular necrosis of the femoral head, hip fracture, or osteoarthritis, after excluding those who died or were lost to follow-up. One senior author (K.H.M.) evaluated Harris Hip Score (HHS); limping gait; and leg length discrepancy, and 3 independent reviewers assessed the radiographic findings, including the level of stress shielding, Dorr classification, subsidence and loosening of femoral stem, heterotopic ossification (Brooker classification), osteolysis of acetabulum, wear rate of the polyethylene liner, component loosening, and revision rate.

Results:

The mean follow-up duration was 16.9 years and average age at operation was 50.9 years. The HHS improved at the last follow-up. Stress shielding was grade 1 in 185 hips, grade 2 in 35 hips, grade 3 in 37 hips, and grade 4 in 11 hips. Femoral stem subsidence was <3 mm in 4 hips and >3 mm in 6 hips. Femoral stems with stable bony ingrowth were observed in 258 hips, fibrous stable femoral stems in 4 hips, and unstable femoral stems in 6 hips. Heterotopic ossification was class 1 in12 and class 2 in 4 hips. Revision surgery was performed for periprosthetic osteolysis of cup (45 hips), recurrent dislocation (1), unstable femoral stem (1), and infection (1). The Kaplan-Meier survivorship at the 15-year follow-up was 86.2%. The survivorship of femoral stem at 15 years was 99.3%, and if including impending revision due to unstable femoral stem was 97.1%.

Disscussion:

This study has all the limitations inherent with a retrospective design. However, a large number of patients in this cohort operated on by a single surgeon and a long-term follow-up are some of the potential advantages of the current study.

Conclusions:

At the 15-year follow-up, extensive porous-coated stem showed relatively good survivorship even in geriatric patients (Dorr type C).

Delay of total hip arthroplasty to advanced stage worsens post-operative hip motion in patients with femoral head osteonecrosis

PURPOSE

Osteonecrosis of the femoral head (ONFH) is commonly detected in young patients and most surgeons tend to delay total hip arthroplasty (THA) until the end stage of the disease. We hypothesised that post-operative range of motion (ROM) of the hip as well as baseline ROM at the time of surgery decreases with the disease progression. The purpose of this study was to determine whether patients, who were operated at an advanced stage, have pre- and post-operative hip ROM similar to ROM of patients, who were operated at earlier stages.

METHODS

Eight hundred and fifty patients (850 hips) treated with THA for ONFH were classified according to pre-operative stages of Association Research Circulation Osseous (ARCO). Fifty-six patients were operated at stage 2, 458 at stage 3, and 336 at stage 4. Pre-operative and one year post-operative ROM was compared among the stages.

RESULTS

Pre-operative sum of hip ROM decreased with the progression of ARCO stage (P < 0.001) and correlated with the post-operative sum of hip ROM (correlation coefficient 0.661). Although hip ROM improved after THA in all stages, post-operative ROM in patients with lower pre-operative ROM did not improve to the same level as in those with a higher pre-operative ROM (P < 0.001).

CONCLUSIONS

The progression of ONFH negatively affected post-operative hip ROM as well as baseline hip ROM at the time of THA. Surgeons should consider a delay of THA negatively affects the hip ROM after the arthroplasty, when they determine the treatment modality for ONFH patients.

Retrieval analysis of ceramic-coated metal-on-polyethylene total hip replacements

PURPOSE

Ceramic coatings have been used in metal-on-polyethylene (MOP) hips to reduce the risk of wear and also infection; the clinical efficacy of this remains unclear. This retrieval study sought to better understand the performance of coated bearing surfaces.

METHODS

Forty-three coated MOP components were analysed post-retrieval for evidence of coating loss and gross polyethylene wear. Coating loss was graded using a visual semi-quantitative protocol. Evidence of gross polyethylene wear was determined by radiographic analysis and visual inspection of the retrieved implants.

RESULTS

All components with gross polyethylene wear (n = 10) were revised due to a malfunctioning acetabular component; 35 % (n = 15) of implants exhibited visible coating loss and the incidence of polyethylene wear in samples with coating loss was 54 %, significantly (p = 0.02) elevated compared to samples with intact coatings (14 %).

CONCLUSIONS

In this study we found evidence of coating loss on metal femoral heads which was associated with increased wear of the corresponding polyethylene acetabular cups.