1
|
Helamieh M, Reich M, Bory S, Rohne P, Riebesell U, Kerner M, Kümmerer K. Blue-green light is required for a maximized fatty acid unsaturation and pigment concentration in the microalga Acutodesmus obliquus. Lipids 2022; 57:221-232. [PMID: 35460080 DOI: 10.1002/lipd.12343] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 02/01/2022] [Revised: 04/05/2022] [Accepted: 04/05/2022] [Indexed: 11/06/2022]
Abstract
Blue-green light is known to maximize the degree of fatty acid (FA) unsaturation in microalgae. However, knowledge on the particular waveband responsible for this stimulation of FA desaturation and its impact on the pigment composition in microalgae remains limited. In this study, Acutodesmus obliquus was cultivated for 96 h at 15°C with different light spectra (380-700 nm, 470-700 nm, 520-700 nm, 600-700 nm, and dark controls). Growth was monitored daily, and qualitative characterization of the microalgal FA composition was achieved via gas chromatography coupled with electron impact ionization mass spectrometry (GC-EI/MS). Additionally, a quantitative analysis of microalgal pigments was performed using high-performance liquid chromatography with diode array detection (HPLC-DAD). Spectra that included wavelengths between 470 and 520 nm led to a significantly higher percentage of the polyunsaturated fatty acids (PUFA) 18:3 and 16:4, compared to all other light conditions. However, no significant differences between the red light cultivations and the heterotrophic dark controls were observed for the FA 18:3 and 16:4. These results indicate, that exclusively the blue-green light waveband between 470 and 520 nm is responsible for a maximized FA unsaturation in A. obliquus. Furthermore, the growth and production of pigments were impaired if blue-green light (380-520 nm) was absent in the light spectrum. This knowledge can contribute to achieving a suitable microalgal pigment and FA composition for industrial purposes and must be considered in spectrally selective microalgae cultivation systems.
Collapse
Affiliation(s)
- Mark Helamieh
- Institute of Sustainable Chemistry, Leuphana University of Lueneburg, Lueneburg, Germany.,Strategic Science Consult Ltd, Hamburg, Germany
| | - Marco Reich
- Institute of Sustainable Chemistry, Leuphana University of Lueneburg, Lueneburg, Germany
| | - Sophie Bory
- Institute of Sustainable Chemistry, Leuphana University of Lueneburg, Lueneburg, Germany
| | - Philipp Rohne
- Institute of Pharmacy and Biochemistry, Therapeutical Life Sciences, Johannes Gutenberg-University Mainz, Mainz, Germany
| | - Ulf Riebesell
- GEOMAR Helmholtz Centre for Ocean Research Kiel, Kiel, Germany
| | | | - Klaus Kümmerer
- Institute of Sustainable Chemistry, Leuphana University of Lueneburg, Lueneburg, Germany
| |
Collapse
|
2
|
Lab-scale photobioreactor systems: principles, applications, and scalability. Bioprocess Biosyst Eng 2022; 45:791-813. [PMID: 35303143 PMCID: PMC9033726 DOI: 10.1007/s00449-022-02711-1] [Citation(s) in RCA: 13] [Impact Index Per Article: 6.5] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 10/22/2021] [Accepted: 02/14/2022] [Indexed: 12/20/2022]
Abstract
Phototrophic microorganisms that convert carbon dioxide are being explored for their capacity to solve different environmental issues and produce bioactive compounds for human therapeutics and as food additives. Full-scale phototrophic cultivation of microalgae and cyanobacteria can be done in open ponds or closed photobioreactor systems, which have a broad range of volumes. This review focuses on laboratory-scale photobioreactors and their different designs. Illuminated microtiter plates and microfluidic devices offer an option for automated high-throughput studies with microalgae. Illuminated shake flasks are used for simple uncontrolled batch studies. The application of illuminated bubble column reactors strongly emphasizes homogenous gas distribution, while illuminated flat plate bioreactors offer high and uniform light input. Illuminated stirred-tank bioreactors facilitate the application of very well-defined reaction conditions. Closed tubular photobioreactors as well as open photobioreactors like small-scale raceway ponds and thin-layer cascades are applied as scale-down models of the respective large-scale bioreactors. A few other less common designs such as illuminated plastic bags or aquarium tanks are also used mainly because of their relatively low cost, but up-scaling of these designs is challenging with additional light-driven issues. Finally, this review covers recommendations on the criteria for photobioreactor selection and operation while up-scaling of phototrophic bioprocesses with microalgae or cyanobacteria.
Collapse
|
3
|
Helamieh M, Gebhardt A, Reich M, Kuhn F, Kerner M, Kümmerer K. Growth and fatty acid composition of Acutodesmus obliquus under different light spectra and temperatures. Lipids 2021; 56:485-498. [PMID: 34173670 DOI: 10.1002/lipd.12316] [Citation(s) in RCA: 3] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [Abstract] [Key Words] [Journal Information] [Subscribe] [Scholar Register] [Received: 03/01/2021] [Revised: 06/01/2021] [Accepted: 06/09/2021] [Indexed: 11/10/2022]
Abstract
The combined impact of temperature and light spectra on the fatty acid (FA) composition in microalgae has been sparsely investigated. The aim of this study was to investigate the interactions of light and temperature on the FA composition in Acutodesmus obliquus. For this purpose, A. obliquus was cultivated with different temperatures (20, 30, and 35°C), as well as broad light spectra (blue, green, and red light). Growth and FA composition were monitored daily. Microalgal FA were extracted, and a qualitative characterization was done by gas chromatography coupled with electron impact ionization mass spectrometry (GC-EI/MS). Compared to red light, green and blue light caused a higher percentage of the polyunsaturated fatty acids (PUFA) 16:4, 18:3, and 18:4, at all temperatures. The highest total percentage of these PUFA were observed at the lowest cultivation temperature and blue and green light. These data imply that a combination of lower temperatures and blue-green light (450-550 nm) positively influences the activity of specific FA-desaturases in A. obliquus. Additionally, a lower 16:1 trans/cis ratio was observed upon green and blue light treatment and lower cultivation temperatures. Remarkably, green light treatment resulted in a comparably high growth under all tested conditions. Therefore, a higher content of green light, compared to blue light might additionally lead to a higher biomass concentration. Microalgae cultivation with low temperatures and green light might therefore result in a suitable FA composition for the food industry and a comparably high biomass production.
Collapse
Affiliation(s)
- Mark Helamieh
- Institute of Sustainable and Environmental Chemistry, Leuphana University of Lüneburg, Lüneburg, Germany.,Strategic Science Consult Ltd., Hamburg, Germany
| | | | - Marco Reich
- Institute of Sustainable and Environmental Chemistry, Leuphana University of Lüneburg, Lüneburg, Germany
| | - Friedericke Kuhn
- Institute of Experimental Business Psychology, Leuphana University of Lüneburg, Lüneburg, Germany
| | | | - Klaus Kümmerer
- Institute of Sustainable and Environmental Chemistry, Leuphana University of Lüneburg, Lüneburg, Germany
| |
Collapse
|
4
|
Mangi KH, Larbi Z, Legrand J, Pruvost J, Si-Ahmed EK. Passive thermal regulation approach for Algofilm © photobioreactor through phase change. Chem Eng Res Des 2021. [DOI: 10.1016/j.cherd.2021.02.013] [Citation(s) in RCA: 4] [Impact Index Per Article: 1.3] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 12/07/2022]
|
5
|
Kwon G, Le LT, Jeon J, Noh J, Jang Y, Kang D, Jahng D. Effects of light and mass ratio of microalgae and nitrifiers on the rates of ammonia oxidation and nitrate production. Biochem Eng J 2020. [DOI: 10.1016/j.bej.2020.107656] [Citation(s) in RCA: 8] [Impact Index Per Article: 2.0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 12/17/2022]
|
6
|
Kwon G, Kim H, Song C, Jahng D. Co-culture of microalgae and enriched nitrifying bacteria for energy-efficient nitrification. Biochem Eng J 2019. [DOI: 10.1016/j.bej.2019.107385] [Citation(s) in RCA: 16] [Impact Index Per Article: 3.2] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 10/25/2022]
|
7
|
Annual outdoor cultivation of the diatom Thalassiosira weissflogii: productivity, limits and perspectives. ALGAL RES 2019. [DOI: 10.1016/j.algal.2019.101553] [Citation(s) in RCA: 16] [Impact Index Per Article: 3.2] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 12/20/2022]
|
8
|
Nwoba EG, Parlevliet DA, Laird DW, Alameh K, Moheimani NR. Light management technologies for increasing algal photobioreactor efficiency. ALGAL RES 2019. [DOI: 10.1016/j.algal.2019.101433] [Citation(s) in RCA: 61] [Impact Index Per Article: 12.2] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 12/14/2022]
|
9
|
Pruvost J, Goetz V, Artu A, Das P, Al Jabri H. Thermal modeling and optimization of microalgal biomass production in the harsh desert conditions of State of Qatar. ALGAL RES 2019. [DOI: 10.1016/j.algal.2018.12.006] [Citation(s) in RCA: 10] [Impact Index Per Article: 2.0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 10/27/2022]
|
10
|
Gupta S, Pawar SB, Pandey RA, Kanade GS, Lokhande SK. Outdoor microalgae cultivation in airlift photobioreactor at high irradiance and temperature conditions: effect of batch and fed-batch strategies, photoinhibition, and temperature stress. Bioprocess Biosyst Eng 2018; 42:331-344. [PMID: 30446818 DOI: 10.1007/s00449-018-2037-6] [Citation(s) in RCA: 13] [Impact Index Per Article: 2.2] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 09/07/2018] [Accepted: 11/02/2018] [Indexed: 01/13/2023]
Abstract
The microalgae Scenedesmus abundans cultivated in five identical airlift photobioreactors (PBRs) in batch and fed-batch modes at the outdoor tropical condition. The microalgae strain S. abundans was found to tolerate high temperature (35-45 °C) and high light intensity (770-1690 µmol m- 2 s- 1). The highest biomass productivities were 152.5-162.5 mg L- 1 day- 1 for fed-batch strategy. The biomass productivity was drastically reduced due to photoinhibition effect at a culture temperature of > 45 °C. The lipid compositions showed fatty acids mainly in the form of saturated and monounsaturated fatty acids (> 80%) in all PBRs with Cetane number more than 51. The fed-batch strategies efficiently produced higher biomass and lipid productivities at harsh outdoor conditions. Furthermore, the microalgae also accumulated omega-3 fatty acid (C18:3) up to 14% (w/w) of total fatty acid at given outdoor condition.
Collapse
Affiliation(s)
- Suvidha Gupta
- Academy of Scientific and Innovative Research (AcSIR), Ghaziabad, 201002, India.,Environmental Biotechnology and Genomics Division, CSIR-National Environmental Engineering Research Institute (NEERI), Nagpur, 440020, India
| | - Sanjay B Pawar
- Environmental Biotechnology and Genomics Division, CSIR-National Environmental Engineering Research Institute (NEERI), Nagpur, 440020, India.
| | - R A Pandey
- CSIR-National Environmental Engineering Research Institute (NEERI), Nagpur, India
| | - Gajanan S Kanade
- Analytical Instruments Division, CSIR-National Environmental Engineering Research Institute (NEERI), Nagpur, India
| | - Satish K Lokhande
- Analytical Instruments Division, CSIR-National Environmental Engineering Research Institute (NEERI), Nagpur, India
| |
Collapse
|
11
|
|
12
|
Castrillo M, Díez-Montero R, Tejero I. Model-based feasibility assessment of a deep solar photobioreactor for microalgae culturing. ALGAL RES 2018. [DOI: 10.1016/j.algal.2017.12.004] [Citation(s) in RCA: 4] [Impact Index Per Article: 0.7] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 10/18/2022]
|
13
|
Racheva R, Tietgens N, Kerner M, Smirnova I. In situ continuous countercurrent cloud point extraction of microalgae cultures. Sep Purif Technol 2018. [DOI: 10.1016/j.seppur.2017.08.066] [Citation(s) in RCA: 9] [Impact Index Per Article: 1.5] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 10/18/2022]
|
14
|
Koller AP, Wolf L, Brück T, Weuster-Botz D. Studies on the scale-up of biomass production with Scenedesmus spp. in flat-plate gas-lift photobioreactors. Bioprocess Biosyst Eng 2017; 41:213-220. [DOI: 10.1007/s00449-017-1859-y] [Citation(s) in RCA: 11] [Impact Index Per Article: 1.6] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 07/12/2017] [Accepted: 10/22/2017] [Indexed: 01/07/2023]
|
15
|
Abomohra AEF, El-Sheekh M, Hanelt D. Screening of marine microalgae isolated from the hypersaline Bardawil lagoon for biodiesel feedstock. RENEWABLE ENERGY 2017; 101:1266-1272. [DOI: 10.1016/j.renene.2016.10.015] [Citation(s) in RCA: 31] [Impact Index Per Article: 4.4] [Reference Citation Analysis] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 09/02/2023]
|
16
|
Pruvost J, Le Borgne F, Artu A, Legrand J. Development of a thin-film solar photobioreactor with high biomass volumetric productivity (AlgoFilm©) based on process intensification principles. ALGAL RES 2017. [DOI: 10.1016/j.algal.2016.10.012] [Citation(s) in RCA: 38] [Impact Index Per Article: 5.4] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/29/2022]
|
17
|
Ooms MD, Dinh CT, Sargent EH, Sinton D. Photon management for augmented photosynthesis. Nat Commun 2016; 7:12699. [PMID: 27581187 PMCID: PMC5025804 DOI: 10.1038/ncomms12699] [Citation(s) in RCA: 113] [Impact Index Per Article: 14.1] [Reference Citation Analysis] [Abstract] [MESH Headings] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 12/23/2015] [Accepted: 07/22/2016] [Indexed: 11/09/2022] Open
Abstract
Microalgae and cyanobacteria are some of nature's finest examples of solar energy conversion systems, effortlessly transforming inorganic carbon into complex molecules through photosynthesis. The efficiency of energy-dense hydrocarbon production by photosynthetic organisms is determined in part by the light collected by the microorganisms. Therefore, optical engineering has the potential to increase the productivity of algae cultivation systems used for industrial-scale biofuel synthesis. Herein, we explore and report emerging and promising material science and engineering innovations for augmenting microalgal photosynthesis. Photosynthetic microalgae could provide an ecologically sustainable route to produce solar biofuels and high-value chemicals. Here, the authors review various optical management strategies used to manipulate the incident light in order to increase the efficiency of microalgae biofuel production.
Collapse
Affiliation(s)
- Matthew D. Ooms
- Department of Mechanical and Industrial Engineering and Institute for Sustainable Energy, University of Toronto, 5 Kings College Rd., Toronto, Ontario, Canada M5S3G8
| | - Cao Thang Dinh
- Department of Electrical and Computer Engineering, University of Toronto, 10 King's College Rd., Toronto, Ontario, Canada M5S3G4
| | - Edward H. Sargent
- Department of Electrical and Computer Engineering, University of Toronto, 10 King's College Rd., Toronto, Ontario, Canada M5S3G4
| | - David Sinton
- Department of Mechanical and Industrial Engineering and Institute for Sustainable Energy, University of Toronto, 5 Kings College Rd., Toronto, Ontario, Canada M5S3G8
| |
Collapse
|
18
|
Pruvost J, Le Borgne F, Artu A, Cornet JF, Legrand J. Industrial Photobioreactors and Scale-Up Concepts. PHOTOBIOREACTION ENGINEERING 2016. [DOI: 10.1016/bs.ache.2015.11.002] [Citation(s) in RCA: 27] [Impact Index Per Article: 3.4] [Reference Citation Analysis] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 12/12/2022]
|
19
|
Pruvost J, Cornet JF, Pilon L. Large-Scale Production of Algal Biomass: Photobioreactors. ALGAE BIOTECHNOLOGY 2016. [DOI: 10.1007/978-3-319-12334-9_3] [Citation(s) in RCA: 16] [Impact Index Per Article: 2.0] [Reference Citation Analysis] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 12/25/2022]
|
20
|
Möbius A, Boukis N, Hindersin S, Kerner M. Cultivation and Hydrothermal Gasification of MicroalgaeScenedesmus Obliquus- First Experimental Results. CHEM-ING-TECH 2015. [DOI: 10.1002/cite.201500002] [Citation(s) in RCA: 6] [Impact Index Per Article: 0.7] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/05/2022]
|
21
|
Theoretical investigation of microalgae culture in the light changing conditions of solar photobioreactor production and comparison with cyanobacteria. ALGAL RES 2015. [DOI: 10.1016/j.algal.2015.04.005] [Citation(s) in RCA: 40] [Impact Index Per Article: 4.4] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/19/2022]
|
22
|
Glembin P, Racheva R, Kerner M, Smirnova I. Micelle mediated extraction of fatty acids from microalgae cultures: Implementation for outdoor cultivation. Sep Purif Technol 2014. [DOI: 10.1016/j.seppur.2014.07.057] [Citation(s) in RCA: 19] [Impact Index Per Article: 1.9] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 10/24/2022]
|
23
|
Continuous microalgal cultivation in a laboratory-scale photobioreactor under seasonal day–night irradiation: experiments and simulation. Bioprocess Biosyst Eng 2014; 37:1535-42. [DOI: 10.1007/s00449-014-1125-5] [Citation(s) in RCA: 12] [Impact Index Per Article: 1.2] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 08/19/2013] [Accepted: 01/08/2014] [Indexed: 10/25/2022]
|
24
|
Metagenome survey of a multispecies and alga-associated biofilm revealed key elements of bacterial-algal interactions in photobioreactors. Appl Environ Microbiol 2013; 79:6196-206. [PMID: 23913425 DOI: 10.1128/aem.01641-13] [Citation(s) in RCA: 76] [Impact Index Per Article: 6.9] [Reference Citation Analysis] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 12/17/2022] Open
Abstract
Photobioreactors (PBRs) are very attractive for sunlight-driven production of biofuels and capturing of anthropogenic CO2. One major problem associated with PBRs however, is that the bacteria usually associated with microalgae in nonaxenic cultures can lead to biofouling and thereby affect algal productivity. Here, we report on a phylogenetic, metagenome, and functional analysis of a mixed-species bacterial biofilm associated with the microalgae Chlorella vulgaris and Scenedesmus obliquus in a PBR. The biofilm diversity and population dynamics were examined through 16S rRNA phylogeny. Overall, the diversity was rather limited, with approximately 30 bacterial species associated with the algae. The majority of the observed microorganisms were affiliated with Alphaproteobacteria, Betaproteobacteria, and Bacteroidetes. A combined approach of sequencing via GS FLX Titanium from Roche and HiSeq 2000 from Illumina resulted in the overall production of 350 Mbp of sequenced DNA, 165 Mbp of which was assembled in larger contigs with a maximum size of 0.2 Mbp. A KEGG pathway analysis suggested high metabolic diversity with respect to the use of polymers and aromatic and nonaromatic compounds. Genes associated with the biosynthesis of essential B vitamins were highly redundant and functional. Moreover, a relatively high number of predicted and functional lipase and esterase genes indicated that the alga-associated bacteria are possibly a major sink for lipids and fatty acids produced by the microalgae. This is the first metagenome study of microalga- and PBR-associated biofilm bacteria, and it gives new clues for improved biofuel production in PBRs.
Collapse
|
25
|
Abomohra AEF, Wagner M, El-Sheekh M, Hanelt D. Lipid and total fatty acid productivity in photoautotrophic fresh water microalgae: screening studies towards biodiesel production. JOURNAL OF APPLIED PHYCOLOGY 2013; 25:931-936. [DOI: 10.1007/s10811-012-9917-y] [Citation(s) in RCA: 50] [Impact Index Per Article: 4.5] [Reference Citation Analysis] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 09/02/2023]
|
26
|
The effect of discontinuous airlift mixing in outdoor flat panel photobioreactors on growth of Scenedesmus obliquus. Bioprocess Biosyst Eng 2013; 36:1653-63. [DOI: 10.1007/s00449-013-0939-x] [Citation(s) in RCA: 16] [Impact Index Per Article: 1.5] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 01/16/2013] [Accepted: 02/26/2013] [Indexed: 11/26/2022]
|
27
|
|