Autotrophic denitrification by nitrate-dependent Fe(II) oxidation in a continuous up-flow biofilter

Iron-dependent autotrophic denitrification as a novel microbial driven and iron-mediated denitrification process: A critical review

Based on previous research results, iron-dependent autotrophic denitrification (IDAD) was evaluated in an all-around way to provide a theoretical basis for further research. First, this review systematically and comprehensively summarizes the development of IDAD technology and describes the physiological properties of relevant functional microorganisms and their potential mechanisms from different perspectives. Second, the possible Fe-N pathways involved in the reaction of different iron-based materials are discussed in detail. Then, the theoretical advantages of the IDAD process and potential problems are described, and the corresponding control strategies are summarized. The influence of key factors on denitrification is discussed in terms of operational and water quality parameters. In addition, the application and research direction of this technology in engineering are summarized. Finally, the latest development trends and prospects for future applications are discussed to promote an in-depth understanding of IDAD and its practical application in sewage treatment.

Tracking the nitrogen transformation in saline wastewater by marine anammox bacteria-based Fe(II)-driven autotrophic denitratation and anammox

Marine anammox bacteria-based Fe(II)-driven autotrophic denitratation and anammox (MFeADA) was investigated for nitrogen removal from saline wastewater for the first time. The study demonstrated that varying influent doses of Fe(II), which participate in the Fe cycle, significantly influenced nitrogen removal performance by altering the fate of nitrite. When 50 mg/L Fe(II) was added, the nitrogen removal was mainly performed by the anammox and Fe(II)-driven autotrophic denitratation (FeAD). As the Fe(II) rose to 100-150 mg/L, the anammox, FeAD and Feammox mainly occurred. Optimal nitrogen removal efficiency, reaching 93 %, was achieved at an influent Fe(II) concentration of 150 mg/L. As the Fe(II) reached 250 mg/L, however, nitrate was directly reduced to dinitrogen gas by the excessive Fe(II) through the Fe(II)-driven autotrophic denitrification (FeADN). Candidatus Scalindua (4.1 %), Marinicella (5.3 %) and SM1A02 (31.8 %) were the dominant functional microbes. In addition, the normalized nitrate reductase abundance was about 3.1 times that of nitrite reductase, leading to the occurrence of FeAD, which achieved a stable nitrite supply for marine anammox bacteria. This novel study can promote the practical implementation of the MFeADA process in nitrogen-laden saline wastewater treatment.

Novel insights into Feammox coupled with the NDFO: A critical review

Ammonium oxidation coupled with Fe(III) reduction, known as Feammox, and nitrate-dependent ferrous oxidation (NDFO) are two processes that can be synergistically achieved through the Fe(III)/Fe(II) cycle. This integrated approach enables the simultaneous removal of ammonia nitrogen (NH4+-N) and nitrate nitrogen (NO3--N) from wastewater, representing a novel method for complete nitrogen removal. This study presents a systematic and exhaustive examination of the Feammox-NDFO coupled process. An initial thorough exploration of the underlying mechanisms behind the coupling process is conducted, highlighting how the Fe(III)/Fe(II) cycle enables the concurrent occurrence of these reactions. Further, the functional microorganisms associated with and playing a crucial role in the Feammox-NDFO process are summarized. Next, the key influencing factors that govern the efficiency of the Feammox-NDFO process are explored. These include parameters such as pH, temperature, carbon source, iron source, nitrogen source, and various electron shuttles that may mediate electron transfer. Understanding the impact of these factors is essential for optimizing the process. The most recent trends and endeavors on the Feammox-NDFO coupling technology in wastewater treatment applications are also examined. This includes examining both laboratory-scale studies and field trials, highlighting their successes and challenges. Finally, an outlook is presented regarding the future advancement of the Feammox-NDFO technology. Areas of improvement and novel strategies that could further enhance the efficiency of simultaneous nitrogen removal from the iron cycle are discussed. In summary, this study aspires to offer a thorough comprehension of the Feammox-NDFO coupled process, with a focus on its mechanisms, influencing factors, applications, and prospects. It is anticipated to yield invaluable insights for the advancement of process optimization, thus sparking fresh ideas and strategies aimed at accomplishing the thorough elimination of nitrogen from wastewater via the iron cycle.

Optimization of operating parameters and microbiological mechanism of a low C/N wastewater treatment system dominated by iron-dependent autotrophic denitrification

Ferrous iron (Fe2+) reduces the amount of external carbon source used for the denitrification of low-C/N wastewater. The effects of key operating parameters on the efficiency of ferrous-dependent autotrophic denitrification (FDAD) and the functioning mechanism of the microbiome can provide a regulatory strategy for improving the denitrification efficiency of low C/N wastewater. In this study, the response surface method (RSM) was used to explore the influence of four important parameters-the molar ratio of Fe2+ to NO3--N (Fe/N), total organic carbon (TOC), the molar ratio of inorganic carbon to NO3--N (IC/N) and sludge volume (SV, %)-on the FDAD efficiency. Functional prediction and molecular ecological networks based on high-throughputs sequencing techniques were used to explore changes in the structure, function, and biomarkers of the sludge microbial community. The results showed that Fe/N and TOC were the main parameters affecting FDAD efficiency. Higher concentrations of TOC and high Fe/N ratios provided more electron donors and improved denitrification efficiency, but weakened the importance of biomarkers (Rhodanobacter, Thermomonas, Comamonas, Thauera, Geothrix and unclassified genus of family Gallionellaceae) in the sludge ecological network. When Fe/N > 4, the denitrification efficiency fluctuated significantly. Functional prediction results indicated that genes that dominated N2O and NO reduction and the genes that dominated Fe2+ transport showed a slight decrease in abundance at high Fe/N levels. In light of these findings, we recommend the following optimization ranges of parameters: Fe/N (3.5-4); TOC/N (0.36-0.42); IC/N (3.5-4); and SV (approximately 35%).

Behaviors and mechanisms of microbially-induced corrosion in metal-based water supply pipelines: A review

Microbially-induced corrosion (MIC) is unstoppable and extensively spread throughout drinking water distribution systems (DWDSs) as the cause of pipe leakage and deteriorating water quality. For maintaining drinking water safety and reducing capital inputs in pipe usage, the possible consequences from MIC in DWDSs is still a research hotspot. Although most studies have investigated the effects of changing environmental factors on MIC corrosion, the occurrence of MIC in DWDSs has not been discussed sufficiently. This review aims to fill this gap by proposing that the formation of deposits with microbial capture may be a source of MIC in newly constructed DWDSs. The microbes early attaching to the rough pipe surface, followed by chemically and microbially-induced mineral deposits which confers resistance to disinfectants is ascribed as the first step of MIC occurrence. MIC is then activated in the newly-built, viable, and accessible microenvironment while producing extracellular polymers. With longer pipe service, oligotrophic microbes slowly grow, and metal pipe materials gradually dissolve synchronously with electron release to microbes, resulting in pipe-wall damage. Different corrosive microorganisms using pipe material as a reaction substrate would directly or indirectly cause different types of corrosion. Correspondingly, the formation of scale layers may reflect the distribution of microbial species and possibly biogenic products. It is therefore assumed that the porous and loose layer is an ideal microbial-survival environment, capable of providing diverse and sufficient ecological niches. The usage and chelation of metabolic activities and metabolites, such as acetic, oxalic, citric and glutaric acids, may lead to the formation of a porous scale layer. Therefore, the microbial interactions within the pipe scale reinforce the stability of microbial communities and accelerate MIC. Finally, a schematic model of the MIC process is presented to interpret MIC from its onset to completion.

Synergistic effect of zero-valent iron and static magnetic field on wastewater purification and bioelectricity generation in electroactive constructed wetlands

This study investigated the enhancement effect of zero-valent iron and static magnetic field on the pollutant removal and power generation of electroactive constructed wetland. As demonstration, a conventional wetland was systematically modified by introducing zero-valent iron and then a static magnetic field, leading to progressive increases in pollutant (namely NH4+-N and chemical oxygen demand) removal efficiencies. By introducing both zero-valent iron and a static magnetic field, the power density increased four-fold to 9.2 mW/m2 and the internal resistance decreased by 26.7% to 467.4 Ω. Notably, static magnetic field decreased the relative abundance of electrochemically active bacteria (such as Romboutsia), while significantly enhancing species diversity. The permeability of the microbial cell membrane was improved, leading to a reduction in activation loss and internal resistance, thereby enhancing power generation capacity. Results showed that the addition of zero-valent iron and the applied magnetic field were beneficial to the pollutants removal and bioelectricity generation.

Autotrophic denitrification using Fe(II) as an electron donor: A novel prospective denitrification process

As a newly identified nitrogen loss pathway, the nitrate-dependent ferrous oxidation (NDFO) process is emerging as a research hotspot in the field of low carbon to nitrogen ratio (C/N) wastewater treatment. This review article provides an overview of the NDFO process and summarizes the functional microorganisms associated with NDFO from different perspectives. The potential mechanisms by which external factors such as influent pH, influent Fe(II)/N (mol), organic carbon, and chelating agents affect NDFO performance are also thoroughly discussed. As the electron-transfer mechanism of the NDFO process is still largely unknown, the extensive chemical Fe(II)-oxidizing nitrite-reducing pathway (NDFO_chem) of the NDFO process is described here, and the potential enzymatic electron transfer mechanisms involved are summarized. On this basis, a three-stage electron transfer pathway applicable to low C/N wastewater is proposed. Furthermore, the impact of Fe(III) mineral products on the NDFO process is revisited, and existing crusting prevention strategies are summarized. Finally, future challenges facing the NDFO process and new research directions are discussed, with the aim of further promoting the development and application of the NDFO process in the field of nitrogen removal.

Unchanged nitrate and nitrite isotope fractionation during heterotrophic and Fe(II)-mixotrophic denitrification suggest a non-enzymatic link between denitrification and Fe(II) oxidation

Natural-abundance measurements of nitrate and nitrite (NO_x) isotope ratios (δ¹⁵N and δ¹⁸O) can be a valuable tool to study the biogeochemical fate of NO_x species in the environment. A prerequisite for using NO_x isotopes in this regard is an understanding of the mechanistic details of isotope fractionation (¹⁵ε, ¹⁸ε) associated with the biotic and abiotic NO_x transformation processes involved (e.g., denitrification). However, possible impacts on isotope fractionation resulting from changing growth conditions during denitrification, different carbon substrates, or simply the presence of compounds that may be involved in NO_x reduction as co-substrates [e.g., Fe(II)] remain uncertain. Here we investigated whether the type of organic substrate, i.e., short-chained organic acids, and the presence/absence of Fe(II) (mixotrophic vs. heterotrophic growth conditions) affect N and O isotope fractionation dynamics during nitrate (NO₃^–) and nitrite (NO₂^–) reduction in laboratory experiments with three strains of putative nitrate-dependent Fe(II)-oxidizing bacteria and one canonical denitrifier. Our results revealed that ¹⁵ε and ¹⁸ε values obtained for heterotrophic (¹⁵ε-NO₃^–: 17.6 ± 2.8‰, ¹⁸ε-NO₃^–:18.1 ± 2.5‰; ¹⁵ε-NO₂^–: 14.4 ± 3.2‰) vs. mixotrophic (¹⁵ε-NO₃^–: 20.2 ± 1.4‰, ¹⁸ε-NO₃^–: 19.5 ± 1.5‰; ¹⁵ε-NO₂^–: 16.1 ± 1.4‰) growth conditions are very similar and fall within the range previously reported for classical heterotrophic denitrification. Moreover, availability of different short-chain organic acids (succinate vs. acetate), while slightly affecting the NO_x reduction dynamics, did not produce distinct differences in N and O isotope effects. N isotope fractionation in abiotic controls, although exhibiting fluctuating results, even expressed transient inverse isotope dynamics (¹⁵ε-NO₂^–: –12.4 ± 1.3 ‰). These findings imply that neither the mechanisms ordaining cellular uptake of short-chain organic acids nor the presence of Fe(II) seem to systematically impact the overall N and O isotope effect during NO_x reduction. The similar isotope effects detected during mixotrophic and heterotrophic NO_x reduction, as well as the results obtained from the abiotic controls, may not only imply that the enzymatic control of NO_x reduction in putative NDFeOx bacteria is decoupled from Fe(II) oxidation, but also that Fe(II) oxidation is indirectly driven by biologically (i.e., via organic compounds) or abiotically (catalysis via reactive surfaces) mediated processes co-occurring during heterotrophic denitrification.

Underestimation about the Contribution of Nitrate Reducers to Iron Cycling Indicated by Enterobacter Strain

Nitrate-reducing iron(II) oxidation (NRFO) has been intensively reported in various bacteria. Iron(II) oxidation is found to be involved in both enzymatic and chemical reactions in nitrate-reducing Fe(II)-oxidizing microorganisms (NRFOMs). However, little is known about the relative contribution of biotic and abiotic reactions to iron(II) oxidation for the common nitrate reducers during the NRFO process. In this study, the typical nitrate reducers, four Enterobacter strains E. hormaechei, E. tabaci, E. mori and E. asburiae, were utilized as the model microorganisms. The comparison of the kinetics of nitrate, iron(II) and nitrite and N₂O production in setups with and without iron(II) indicates a mixture of enzymatic and abiotic oxidation of iron(II) in all four Enterobacter strains. It was estimated that 22−29% of total oxidized iron(II) was coupled to microbial nitrate reduction by E. hormaechei, E. tabaci, E. mori, and E. asburiae. Enterobacter strains displayed an metabolic inactivity with heavy iron(III) encrustation on the cell surface in the NRFOmedium during days of incubation. Moreover, both respiratory and periplasmic nitrate-reducing genes are encoded by genomes of Enterobacter strains, suggesting that cell encrustation may occur with periplasmic iron(III) oxide precipitation as well as the surface iron(II) mineral coating for nitrate reducers. Overall, this study clarified the potential role of nitrate reducers in the biochemical cycling of iron under anoxic conditions, in turn, re-shaping their activity during denitrification because of cell encrustation with iron(III) minerals.

Review on corrosion and corrosion scale formation upon unlined cast iron pipes in drinking water distribution systems

The qualified finished water from water treatment plants (WTPs) may become discolored and deteriorated during transportation in drinking water distribution systems (DWDSs), which affected tap water quality seriously. This water stability problem often occurs due to pipe corrosion and the destabilization of corrosion scales. This paper provides a comprehensive review of pipe corrosion in DWDSs, including corrosion process, corrosion scale formation, influencing factors and monitoring technologies utilized in DWDSs. In terms of corrosion process, corrosion occurrence, development mechanisms, currently applied assays, and indices used to determine the corrosion possibility are summarized, as well as the chemical and bacterial influences. In terms of scale formation, explanations for the nature of corrosion and scale formation mechanisms are discussed and its typical multilayered structure is illustrated. Furthermore, the influences of water quality and microbial activity on scale transformation are comprehensively discussed. Corrosion-related bacteria at the genus level and their associated corrosion mechanism are also summarized. This review helps deepen the current understanding of pipe corrosion and scale formation in DWDSs, providing guidance for water supply utilities to ensure effective measures to maintain water quality stability and guarantee drinking water safety.

Salinity Impact on Composition and Activity of Nitrate-Reducing Fe(II)-Oxidizing Microorganisms in Saline Lakes

Nitrate-reducing Fe(II)-oxidizing (NRFeOx) microorganisms contribute to nitrogen, carbon, and iron cycling in freshwater and marine ecosystems. However, NRFeOx microorganisms have not been investigated in hypersaline lakes, and their identity, as well as their activity in response to salinity, is unknown. In this study, we combined cultivation-based most probable number (MPN) counts with Illumina MiSeq sequencing to analyze the abundance and community compositions of NRFeOx microorganisms enriched from five lake sediments with different salinities (ranging from 0.67 g/L to 346 g/L). MPN results showed that the abundance of NRFeOx microorganisms significantly (P < 0.05) decreased with increasing lake salinity, from 7.55 × 10³ to 8.09 cells/g dry sediment. The community composition of the NRFeOx enrichment cultures obtained from the MPNs differed distinctly among the five lakes and clustered with lake salinity. Two stable enrichment cultures, named FeN-EHL and FeN-CKL, were obtained from microcosm incubations of sediment from freshwater Lake Erhai and hypersaline Lake Chaka. The culture FeN-EHL was dominated by genus Gallionella (68.4%), while the culture FeN-CKL was dominated by genus Marinobacter (71.2%), with the former growing autotrophically and the latter requiring an additional organic substrate (acetate) and Fe(II) oxidation, caused to a large extent by chemodenitrification [reaction of nitrite with Fe(II)]. Short-range ordered Fe(III) (oxyhydr)oxides were the product of Fe(II) oxidation, and the cells were partially attached to or encrusted by the formed iron minerals in both cultures. In summary, different types of interactions between Fe(II) and nitrate-reducing bacteria may exist in freshwater and hypersaline lakes, i.e., autotrophic NRFeOx and chemodenitrification in freshwater and hypersaline environments, respectively. IMPORTANCE NRFeOx microorganisms are globally distributed in various types of environments and play a vital role in iron transformation and nitrate and heavy metal removal. However, most known NRFeOx microorganisms were isolated from freshwater and marine environments, while their identity and activity under hypersaline conditions remain unknown. Here, we demonstrated that salinity may affect the abundance, identity, and nutrition modes of NRFeOx microorganisms. Autotrophy was only detectable in a freshwater lake but not in the saline lake investigated. We enriched a mixotrophic culture capable of nitrate-reducing Fe(II) oxidation from hypersaline lake sediments. However, Fe(II) oxidation was probably caused by abiotic nitrite reduction (chemodenitrification) rather than by a biologically mediated process. Consequently, our study suggests that in hypersaline environments, Fe(II) oxidation is largely caused by chemodentrification initiated by nitrite formation by chemoheterotrophic bacteria, and additional experiments are needed to demonstrate whether or to what extent Fe(II) is enzymatically oxidized.

Oligotrophic Growth of Nitrate-Dependent Fe2+-Oxidising Microorganisms Under Simulated Early Martian Conditions

Nitrate-dependent Fe2+ oxidation (NDFO) is a microbially mediated process observed in many anaerobic, low-nutrient (oligotrophic) neutral-alkaline environments on Earth, which describes oxidation of Fe2+ to Fe3+ in tandem with microbial nitrate reduction. Evidence suggests that similar environments existed on Mars during the Noachian epoch (4.1-3.7 Ga) and in periodic, localised environments more recently, indicating that NDFO metabolism could have played a role in a potential early martian biosphere. In this paper, three NDFO microorganisms, Acidovorax sp. strain BoFeN1, Pseudogulbenkiania sp. strain 2002 and Paracoccus sp. strain KS1, were assessed for their ability to grow oligotrophically in simulated martian brines and in a minimal medium with olivine as a solid Fe2+ source. These simulant-derived media were developed from modelled fluids based on the geochemistry of Mars sample locations at Rocknest (contemporary Mars soil), Paso Robles (sulphur-rich soil), Haematite Slope (haematite-rich soil) and a Shergottite meteorite (common basalt). The Shergottite medium was able to support growth of all three organisms, while the contemporary Mars medium supported growth of Acidovorax sp. strain BoFeN1 and Pseudogulbenkiania sp. strain 2002; however, growth was not accompanied by significant Fe2+ oxidation. Each of the strains was also able to grow in oligotrophic minimal media with olivine as the sole Fe2+ source. Biomineralised cells of Pseudogulbenkiania sp. strain 2002 were identified on the surface of the olivine, representing a potential biosignature for NDFO microorganisms in martian samples. The results suggest that NDFO microorganisms could have thrived in early martian groundwaters under oligotrophic conditions, depending on the local lithology. This can guide missions in identifying palaeoenvironments of interest for biosignature detection. Indeed, biomineralised cells identified on the olivine surface provide a previously unexplored mechanism for the preservation of morphological biosignatures in the martian geological record.

A Novel Enrichment Culture Highlights Core Features of Microbial Networks Contributing to Autotrophic Fe(II) Oxidation Coupled to Nitrate Reduction

Fe(II) oxidation coupled to nitrate reduction (NRFO) has been described for many environments. Yet very few autotrophic microorganisms catalysing NRFO have been cultivated and their diversity, as well as their mechanisms for NRFO in situ remain unclear. A novel autotrophic NRFO enrichment culture, named culture BP, was obtained from freshwater sediment. After more than 20 transfers, culture BP oxidized 8.22 mM of Fe(II) and reduced 2.42 mM of nitrate within 6.5 days under autotrophic conditions. We applied metagenomic, metatranscriptomic, and metaproteomic analyses to culture BP to identify the microorganisms involved in autotrophic NRFO and to unravel their metabolism. Overall, twelve metagenome-assembled genomes (MAGs) were constructed, including a dominant Gallionellaceae sp. MAG (≥71% relative abundance). Genes and transcripts associated with potential Fe(II) oxidizers in culture BP, identified as a Gallionellaceae sp., Noviherbaspirillum sp., and Thiobacillus sp., were likely involved in metal oxidation (e.g., cyc2, mtoA), denitrification (e.g., nirK/S, norBC), carbon fixation (e.g., rbcL), and oxidative phosphorylation. The putative Fe(II)-oxidizing protein Cyc2 was detected for the Gallionellaceae sp. Overall, a complex network of microbial interactions among several Fe(II) oxidizers and denitrifiers was deciphered in culture BP that might resemble NRFO mechanisms in situ. Furthermore, 16S rRNA gene amplicon sequencing from environmental samples revealed 36 distinct Gallionellaceae taxa, including the key player of NRFO from culture BP (approx. 0.13% relative abundance in situ). Since several of these in situ-detected Gallionellaceae taxa were closely related to the key player in culture BP, this suggests that the diversity of organisms contributing to NRFO might be higher than currently known.

Improvement of nitrogen removal with iron scraps in floating treatment wetlands

Floating treatment wetland (FTW) in restoration of low C/N ratio wastewater was deemed to a frequently used method. However, the nitrate removal performance in floating beds was limited due to insufficient organic carbon sources. Iron scraps as a potential electron donor was beneficial to the NO₃^--N reduction. To research the removal performance and mechanism of denitrification in FTW with iron scraps, FTW with Iris pseudacorus was built, and iron scraps were added as an electron donor to improve nitrogen removal efficiency. The batch experimental results demonstrated that the proper mass ratio of iron scraps to NO₃^--N was 500:1. With iron scraps, the NO₃^--N removal efficiency of FTW and control system increased significantly to 98.04% and 44.42% respectively in 2 weeks, while there was no obvious influence on the removal of NH₄⁺-N. After adding iron scraps, the proportion of bacteria in the systems related to iron cycle and the relative abundance of nitrifying and denitrifying bacteria have increased obviously. By calculating the nitrogen balance, nitrogen reduction via plant uptake accounted for 8.79%, and the microbial denitrification was the main nitrogen removal pathway in FTW.

An efficient way to achieve stable and high-rate ferrous ion-dependent nitrate removal (FeNiR): Batch sludge replacement

Ferrous ion can be used as electron donor for denitrification in the ferrous ion-dependent nitrate removal (FeNiR). To prevent the FeNiR performance decrease caused by iron encrustation, a modified FeNiR process with batch sludge replacement was developed. Based on the decay kinetics of sludge mass and sludge activity, the sludge retention time (SRT) was determined as 40 days in the modified FeNiR process. To keep the FeNiR rate at 0.70 kg-N/(m³·d), the sludge replacement amount was 25% of total sludge every 10 days. The FeNiR efficiency stabilized around 70%. The batch sludge replacement could be an effective method to offset the active sludge decay caused by iron encrustation, and therefore led to the good FeNiR performance. The wasted FeNiR sludge was found to adsorb phosphate at a rate of 0.9 mg-P/(g VS min). The modified FeNiR process was proposed to be coupled with phosphate removal, achieving the co-removal of nitrate and phosphate. The coupled technology is promising due to the less consumption of resources and energy, as well as the less production of excessive sludge.

Improvement of ferrous ion-dependent nitrate removal (FeNiR) process with chelating ferrous ion as substrate

In order to improve the ferrous ion-dependent nitrate removal (FeNiR) process, hexametaphosphate chelated ferrous ion was used as substrate to replace the free ferrous ion. With hexametaphosphate chelated ferrous ion as substrate, the influent pH was adjusted to 6.8, and as a result a higher effluent pH (7.2) was detected. The volumetric removal rate (VRR) of nitrate kept at 0.42 ± 0.03 kg-N/(m³∙d) for 48 days and the corresponding nitrogen removal efficiency was 94.39 ± 4.57%. After 88 days of cultivation, FeNiR granules became small because of the oligotrophic substrate. The transmission electron microscope (TEM) analysis showed that less iron encrustation was formed on the surface or in the periplasm of FeNiR cells. The linear curve of the living cell percentage versus time showed that the death rate of FeNiR cells with chelated ferrous ion as substrate was much lower than that with free ferrous ion as substrate (0.4210 vs 0.9221). Without iron encrustation, both the FeNiR activity and alkaline phosphatase (ALP) activity of FeNiR cells kept at high level and thus the efficiency of the FeNiR reactor kept stable and high. With hexametaphosphate chelated ferrous ion as substrate, the pH in bulk liquid was high (pH = 7.2) resulting in the high FeNiR rate, and less iron encrustation was formed around cells ensuring the stability of high FeNiR rate. Therefore, using hexametaphosphate chelated ferrous ion as substrate was an efficient way to improve the FeNiR process.

Untangling the nitrate removal pathways for a constructed wetland- sponge iron coupled system and the impacts of sponge iron on a wetland ecosystem

Sponge iron (s-Fe⁰) is a potential alternative electron donor for nitrate reduction. To gain insight into the mechanism of denitrification in a constructed wetland- sponge iron coupled system (CW-Fe⁰ system), the removal performance and reduction characteristics of nitrate in constructed wetlands (CWs) with and without s-Fe⁰ application were compared. Results indicated that s-Fe⁰ intensified the removal of nitrate with a 6h-HRT. The nitrate removal efficiency was improved by 16-76 % with various influent NO₃^--N concentrations (10-30 mg L^-1) and at a chemical oxygen demand(COD)/N ratio of 5. The rates of chemical denitrification were positively correlated with the dosage of s-Fe⁰ and negatively correlated with the influent COD concentration. 16S rDNA sequencing revealed that hydrogen-utilizing autotrophic denitrifier of Hydrogenophaga was highly enriched (accounting for 10 % of the total OTUs) only in CW-Fe⁰ system. The micro-environment created by s-Fe⁰ was suitable for heterotrophic denitrifiers of Thauera, Tessaracoccus and Simplicispira. The determination of physiological indicators for plants showed that the application of s-Fe⁰ causes abiotic stress to wetland plants (Canna indica L.). Nevertheless, s-Fe⁰ can be used as a substrate for CWs, since it allows a high-efficiency removal of nitrate by mediating chemical denitrification and hydrogen-driven autotrophic denitrification.

Iron as electron donor for denitrification: The efficiency, toxicity and mechanism

For the treatment of low C/N wastewaters, methanol or acetate is usually dosed as electron donor for denitrification but such organics makes the process costly. To decrease the cost, iron which is the fourth most abundant element in lithosphere is suggested as the substitution of methanol and acetate. The peak volumetric removal rate (VRR) of nitrate nitrogen in the ferrous iron-dependent nitrate removal (FeNiR) reactor was 0.70 ± 0.04 kg-N/(m³·d), and the corresponding removal efficiency was 98%. Iron showed toxicity to cells by decreasing the live cell amount (dropped 56%) and the live cell activity (dropped 70%). The toxicity of iron was mainly expressed by the formation of iron encrustation. From microbial community data analysis, heterotrophs (Paracocccus, Thauera and Azoarcus) faded away while the facultative chemolithotrophs (Hyphomicrobium and Anaerolineaceae_uncultured) dominated in the reactor after replacing acetate with ferrous iron in the influent. Through scanning electron microscope (SEM) and transmission electron microscope (TEM), two iron oxidation sites in FeNiR cells were observed and accordingly two FeNiR mechanisms were proposed: 1) extracellular FeNiR in which ferrous iron was bio-oxidized extracellularly; and 2) intracellular FeNiR in which ferrous iron was chemically oxidized in periplasm. Bio-oxidation (extracellular FeNiR) and chemical oxidation (intracellular FeNiR) of ferrous iron coexisted in FeNiR reactor, but the former one predominated. Comparing with the control group without electron donor in the influent, FeNiR reactor showed 2 times higher and stable nitrate removal rate, suggesting iron could be used as electron donor for denitrification. However, further research works are still needed for the practical application of FeNiR in wastewater treatment.

Effects of disinfection efficiency on microbial communities and corrosion processes in drinking water distribution systems simulated with actual running conditions

The effects of disinfection efficiency on microbial communities and the corrosion of cast iron pipes in drinking water distribution systems (DWDSs) were studied. Two annular reactors (ARs) that simulated actual running conditions with UV/Cl₂ disinfection and chlorination alone were used. High chlorine consumption and corrosion rate were found in the AR with UV/Cl₂. According to functional genes and pyrosequencing tests, a high percentage of iron recycling bacteria was detected within the biofilm of the AR with Cl₂ at early running stage, whereas siderophore-producing bacteria were dominant in the biofilm of the AR with UV/Cl_2. At the early running stage, the sequential use of UV light and an initial high chlorine dosage suppressed the biomass and iron-recycling bacteria in both bulk water and biofilms, thereby forming less protective scales against further corrosion, which enhanced chlorine consumption. Non-metric multidimensional scaling analysis showed that the bacterial communities in the ARs shaped from within rather than being imported by influents. These results indicate that the initial high disinfection efficiency within the distribution system had not contributed to the accumulation of iron-recycling bacteria at the early running stages. This study offer certain implications for controlling corrosion and water quality in DWDSs.

Nitrogen cycling during wastewater treatment

Many wastewater treatment plants in the world do not remove reactive nitrogen from wastewater prior to release into the environment. Excess reactive nitrogen not only has a negative impact on human health, it also contributes to air and water pollution, and can cause complex ecosystems to collapse. In order to avoid the deleterious effects of excess reactive nitrogen in the environment, tertiary wastewater treatment practices that ensure the removal of reactive nitrogen species need to be implemented. Many wastewater treatment facilities rely on chemicals for tertiary treatment, however, biological nitrogen removal practices are much more environmentally friendly and cost effective. Therefore, interest in biological treatment is increasing. Biological approaches take advantage of specific groups of microorganisms involved in nitrogen cycling to remove reactive nitrogen from reactor systems by converting ammonia to nitrogen gas. Organisms known to be involved in this process include autotrophic ammonia-oxidizing bacteria, heterotrophic ammonia-oxidizing bacteria, ammonia-oxidizing archaea, anaerobic ammonia oxidizing bacteria (anammox), nitrite-oxidizing bacteria, complete ammonia oxidizers, and dissimilatory nitrate reducing microorganisms. For example, in nitrifying-denitrifying reactors, ammonia- and nitrite-oxidizing bacteria convert ammonia to nitrate and then denitrifying microorganisms reduce nitrate to nonreactive dinitrogen gas. Other nitrogen removal systems (anammox reactors) take advantage of anammox bacteria to convert ammonia to nitrogen gas using NO as an oxidant. A number of promising new biological treatment technologies are emerging and it is hoped that as the cost of these practices goes down more wastewater treatment plants will start to include a tertiary treatment step.

Microbial reduction of nitrate in the presence of zero-valent iron

Microbial reduction of nitrate in the presence of zero-valent iron (ZVI) was evaluated in anoxic shake flasks to assess the feasibility of ZVI-facilitated biological nitrate removal. Nitrate was completely reduced within 3days in the presence of both ZVI and microorganisms (ZVI-M). In contrast, only 75% of the nitrate was reduced in the presence of ZVI but without microbial inoculum. Nitrate removal was affected by ZVI-M flasks initial pH, nitrate concentration and ZVI dosage. Nitrate removal in the inoculated ZVI flasks system could be divided into two phases: adaptation phase and log phase which could be described by first-order kinetic equations. The analysis of bacterial communities in the inoculated flasks in the absence and presence of ZVI, indicated that the addition of ZVI increased the relative abundance of Methylotenera spp., Alcaligenes eutrophus, Pseudomonas spp. which might play an important role in nitrogen removal. The presence of ZVI could enhance biological denitrification through four mechanisms: the biological reduction of nitrate with 1) electrons derived directly from ZVI; 2) with hydrogen released from ZVI; 3) with Fe²⁺ released from ZVI; and 4) with acetate generated by homoacetogens which utilize H₂ released from ZVI.

A horizontal permeable reactive barrier stimulates nitrate removal and shifts microbial ecology during rapid infiltration for managed recharge

We present results from field experiments linking hydrology, geochemistry, and microbiology during infiltration at a field site that is used for managed aquifer recharge (MAR). These experiments measured how a horizontal permeable reactive barrier (PRB) made of woodchips impacted subsurface nitrate removal and microbial ecology. Concentrations of dissolved organic carbon consistently increased in infiltrating water below the PRB, but not in un-amended native soil. The average nitrate removal rate in soils below the PRB was 1.5 g/m²/day NO₃-N, despite rapid infiltration (up to 1.9 m/d) and a short fluid residence time within the woodchips (≤6 h). In contrast, 0.09 g/m²/day NO₃-N was removed on average in native soil. Residual nitrate in infiltrating water below the PRB was enriched in δ¹⁵N and δ¹⁸O, with low and variable isotopic enrichment factors that are consistent with denitrification during rapid infiltration. Many putative denitrifying bacteria were significantly enhanced in the soil below a PRB; Methylotenera mobilis and genera Microbacterium, Polaromonas, and Novosphingobium had log₂ fold-changes of +4.9, +5.6, +7.2, and +11.8, respectively. These bacteria were present before infiltration and were not enhanced in native soil. It appears that the woodchip PRB contributed to favorable conditions in the underlying soil for enhanced nitrate removal, quantitatively shifting soil microbial ecology. These results suggest that using a horizontal PRB could improve water quality during rapid infiltration for MAR.

An alternative approach for nitrate and arsenic removal from wastewater via a nitrate-dependent ferrous oxidation process

Owing to the high efficiency of converting nitrate to nitrogen gas with ferrous iron as the electron donor, the process of nitrate-dependent ferrous oxidation (NDFeO) has been considered suitable to treat wastewater that contains nitrate but lacks organic matter. Meanwhile, arsenic immobilization often has been found during the NDFeO reaction. Thus, it was strongly expected that nitrate and arsenic could be removed simultaneously in co-contaminated wastewater through the NDFeO process. However, in the current work, arsenic was not removed during the NDFeO process when the pH was high (above 8), though the nitrate reduction rate was over 90%. Meanwhile, the biosolid particles from the NDFeO process demonstrated strong adsorption ability for arsenic when the pH was below 6. Yet, the adsorption became weak when the pH was above 7. Fourier transform infrared (FTIR) spectroscopy analysis revealed that the main activated component for arsenic adsorption was iron oxide in these particles, which was easily crippled under high pH conditions. These results implied that co-removal of nitrate and arsenic in wastewater treatment using NDFeO was difficult to carry out under high pH conditions. Thus, a two-step approach in which nitrate was removed first by NDFeO followed by arsenic adsorption with NDFeO biosolids was more feasible.

Simultaneous removal of nitrate and phosphate from wastewater by siderite based autotrophic denitrification

The potential of simultaneous removal of nitrate and phosphate from wastewater by a single anaerobic Fe(II) oxidizing denitrifiers (the strain PXL1) was assessed using siderite biofilters under different influent TOC concentrations and hydraulic retention times (HRTs) over a 160-day trial. Higher TOC concentrations promoted NO₃^- removal, while there was no significant influence on PO₄^3- removal. Lowering down HRT from 10 h to 5 h did not significantly influence NO₃^- and PO₄^3- removal. The NO₃^- removal performance and microbial community structure in the biofilters indicated that NO₃^- was reduced to N₂ by both strain PXL1 and heterotrophic Acidovorax delafieldii. Iron content analysis of the used siderite along the biofilters showed that PO₄^3- removal was improved by the bio-oxidation of Fe(II) in siderite to Fe(III) via the strain PXL1. The coexistence of the strain PXL1 and natural siderite in nitrate-contaminated aquifers provides a practical technology for in situ remediation of nutrient contaminated waterbodies.

Growth and Population Dynamics of the Anaerobic Fe(II)-Oxidizing and Nitrate-Reducing Enrichment Culture KS

Most isolated nitrate-reducing Fe(II)-oxidizing microorganisms are mixotrophic, meaning that Fe(II) is chemically oxidized by nitrite that forms during heterotrophic denitrification, and it is debated to which extent Fe(II) is enzymatically oxidized. One exception is the chemolithoautotrophic enrichment culture KS, a consortium consisting of a dominant Fe(II) oxidizer, Gallionellaceae sp., and less abundant heterotrophic strains (e.g., Bradyrhizobium sp., Nocardioides sp.). Currently, this is the only nitrate-reducing Fe(II)-oxidizing culture for which autotrophic growth has been demonstrated convincingly for many transfers over more than 2 decades. We used 16S rRNA gene amplicon sequencing and physiological growth experiments to analyze the community composition and dynamics of culture KS with various electron donors and acceptors. Under autotrophic conditions, an operational taxonomic unit (OTU) related to known microaerophilic Fe(II) oxidizers within the family Gallionellaceae dominated culture KS. With acetate as an electron donor, most 16S rRNA gene sequences were affiliated with Bradyrhizobium sp. Gallionellaceae sp. not only was able to oxidize Fe(II) under autotrophic and mixotrophic conditions but also survived over several transfers of the culture on only acetate, although it then lost the ability to oxidize Fe(II). Bradyrhizobium spp. became and remained dominant when culture KS was cultivated for only one transfer under heterotrophic conditions, even when conditions were reverted back to autotrophic in the next transfer. This study showed a dynamic microbial community in culture KS that responded to changing substrate conditions, opening up questions regarding carbon cross-feeding, metabolic flexibility of the individual strains in KS, and the mechanism of Fe(II) oxidation by a microaerophile in the absence of O₂IMPORTANCE Nitrate-reducing Fe(II)-oxidizing microorganisms are present in aquifers, soils, and marine and freshwater sediments. Most nitrate-reducing Fe(II) oxidizers known are mixotrophic, meaning that they need organic carbon to continuously oxidize Fe(II) and grow. In these microbes, Fe(II) was suggested to be chemically oxidized by nitrite that forms during heterotrophic denitrification, and it remains unclear whether or to what extent Fe(II) is enzymatically oxidized. In contrast, the enrichment culture KS was shown to oxidize Fe(II) autotrophically coupled to nitrate reduction. This culture contains the designated Fe(II) oxidizer Gallionellaceae sp. and several heterotrophic strains (e.g., Bradyrhizobium sp.). We showed that culture KS is able to metabolize Fe(II) and a variety of organic substrates and is able to adapt to dynamic environmental conditions. When the community composition changed and Bradyrhizobium became the dominant community member, Fe(II) was still oxidized by Gallionellaceae sp., even when culture KS was cultivated with acetate/nitrate [Fe(II) free] before being switched back to Fe(II)/nitrate.

High diversity of potential nitrate-reducing Fe(II)-oxidizing bacteria enriched from activated sludge

Nitrate-dependent Fe(II) oxidation (NDFO) has been discovered in various environments including activated sludge and can potentially be used to remove nitrate from wastewater. In this study, NDFO sludge was successfully enriched from activated sludge under high Fe(II) concentrations over 100 days and the denitrification rate achieved 1.37 mmol N/(gVSS day). High-throughput sequencing of the bacterial 16S rRNA gene was used to investigate the microbial community structure dynamics during the enrichment process. The results showed that the microbial community changed significantly and high diversity of potential Fe(II)-oxidizing bacteria (FeOB) was observed in the enriched sludge. Thermomonas and Gallionella were the dominant bacterial genera in the enriched sludge and their relative abundances accounted for 9.49 and 4.08%, respectively. Furthermore, it was found that potential FeOB were also abundantly present in activated sludge samples of common municipal wastewater treatment plants. Collectively, this study demonstrated that NDFO could be successfully performed by enriched activated sludge and high diversity of bacteria is involved in this process, and the results also provide baseline information for future research and engineering application of NDFO process.

Magnetite and Green Rust: Synthesis, Properties, and Environmental Applications of Mixed-Valent Iron Minerals

Mixed-valent iron [Fe(II)-Fe(III)] minerals such as magnetite and green rust have received a significant amount of attention over recent decades, especially in the environmental sciences. These mineral phases are intrinsic and essential parts of biogeochemical cycling of metals and organic carbon and play an important role regarding the mobility, toxicity, and redox transformation of organic and inorganic pollutants. The formation pathways, mineral properties, and applications of magnetite and green rust are currently active areas of research in geochemistry, environmental mineralogy, geomicrobiology, material sciences, environmental engineering, and environmental remediation. These aspects ultimately dictate the reactivity of magnetite and green rust in the environment, which has important consequences for the application of these mineral phases, for example in remediation strategies. In this review we discuss the properties, occurrence, formation by biotic as well as abiotic pathways, characterization techniques, and environmental applications of magnetite and green rust in the environment. The aim is to present a detailed overview of the key aspects related to these mineral phases which can be used as an important resource for researchers working in a diverse range of fields dealing with mixed-valent iron minerals.

Insights into Nitrate-Reducing Fe(II) Oxidation Mechanisms through Analysis of Cell-Mineral Associations, Cell Encrustation, and Mineralogy in the Chemolithoautotrophic Enrichment Culture KS

Most described nitrate-reducing Fe(II)-oxidizing bacteria (NRFeOB) are mixotrophic and depend on organic cosubstrates for growth. Encrustation of cells in Fe(III) minerals has been observed for mixotrophic NRFeOB but not for autotrophic phototrophic and microaerophilic Fe(II) oxidizers. So far, little is known about cell-mineral associations in the few existing autotrophic NRFeOB. Here, we investigate whether the designated autotrophic Fe(II)-oxidizing strain (closely related to Gallionella and Sideroxydans) or the heterotrophic nitrate reducers that are present in the autotrophic nitrate-reducing Fe(II)-oxidizing enrichment culture KS form mineral crusts during Fe(II) oxidation under autotrophic and mixotrophic conditions. In the mixed culture, we found no significant encrustation of any of the cells both during autotrophic oxidation of 8 to 10 mM Fe(II) coupled to nitrate reduction and during cultivation under mixotrophic conditions with 8 to 10 mM Fe(II), 5 mM acetate, and 4 mM nitrate, where higher numbers of heterotrophic nitrate reducers were present. Two pure cultures of heterotrophic nitrate reducers (Nocardioides and Rhodanobacter) isolated from culture KS were analyzed under mixotrophic growth conditions. We found green rust formation, no cell encrustation, and only a few mineral particles on some cell surfaces with 5 mM Fe(II) and some encrustation with 10 mM Fe(II). Our findings suggest that enzymatic, autotrophic Fe(II) oxidation coupled to nitrate reduction forms poorly crystalline Fe(III) oxyhydroxides and proceeds without cellular encrustation while indirect Fe(II) oxidation via heterotrophic nitrate-reduction-derived nitrite can lead to green rust as an intermediate mineral and significant cell encrustation. The extent of encrustation caused by indirect Fe(II) oxidation by reactive nitrogen species depends on Fe(II) concentrations and is probably negligible under environmental conditions in most habitats.IMPORTANCE Most described nitrate-reducing Fe(II)-oxidizing bacteria (NRFeOB) are mixotrophic (their growth depends on organic cosubstrates) and can become encrusted in Fe(III) minerals. Encrustation is expected to be harmful and poses a threat to cells if it also occurs under environmentally relevant conditions. Nitrite produced during heterotrophic denitrification reacts with Fe(II) abiotically and is probably the reason for encrustation in mixotrophic NRFeOB. Little is known about cell-mineral associations in autotrophic NRFeOB such as the enrichment culture KS. Here, we show that no encrustation occurs in culture KS under autotrophic and mixotrophic conditions while heterotrophic nitrate-reducing isolates from culture KS become encrusted. These findings support the hypothesis that encrustation in mixotrophic cultures is caused by the abiotic reaction of Fe(II) with nitrite and provide evidence that Fe(II) oxidation in culture KS is enzymatic. Furthermore, we show that the extent of encrustation caused by indirect Fe(II) oxidation by reactive nitrogen species depends on Fe(II) concentrations and is probably negligible in most environmental habitats.

Evidence for the Existence of Autotrophic Nitrate-Reducing Fe(II)-Oxidizing Bacteria in Marine Coastal Sediment

Nitrate-reducing Fe(II)-oxidizing microorganisms were described for the first time ca. 20 years ago. Most pure cultures of nitrate-reducing Fe(II) oxidizers can oxidize Fe(II) only under mixotrophic conditions, i.e., when an organic cosubstrate is provided. A small number of nitrate-reducing Fe(II)-oxidizing cultures have been proposed to grow autotrophically, but unambiguous evidence for autotrophy has not always been provided. Thus, it is still unclear whether or to what extent Fe(II) oxidation coupled to nitrate reduction is an enzymatically catalyzed and energy-yielding autotrophic process or whether Fe(II) is abiotically oxidized by nitrite from heterotrophic nitrate reduction. The aim of the present study was to find evidence for the existence of autotrophic nitrate-reducing Fe(II) oxidizers in coastal marine sediments. Microcosm incubations showed that with increasing incubation times, the stoichiometric ratio of reduced nitrate/oxidized Fe(II) [NO₃⁻_reduced/Fe(II)_oxidized] decreased, indicating a decreasing contribution of heterotrophic denitrification and/or an increasing contribution of autotrophic nitrate-reducing Fe(II) oxidation over time. After incubations of sediment slurries for >10 weeks, nitrate-reducing activity ceased, although nitrate was still present. This suggests that heterotrophic nitrate reduction had ceased due to the depletion of readily available organic carbon. However, after the addition of Fe(II) to these batch incubation mixtures, the nitrate-reducing activity resumed, and Fe(II) was oxidized, indicating the activity of autotrophic nitrate-reducing Fe(II) oxidizers. The concurrent reduction of ¹⁴C-labeled bicarbonate concentrations unambiguously proved that autotrophic C fixation occurred during Fe(II) oxidation and nitrate reduction. Our results clearly demonstrated that autotrophic nitrate-reducing Fe(II)-oxidizing bacteria were present in the investigated coastal marine sediments.

IMPORTANCE Twenty years after the discovery of nitrate-reducing Fe(II) oxidizers, it is still controversially discussed whether autotrophic nitrate-reducing Fe(II)-oxidizing microorganisms exist and to what extent Fe(II) oxidation in this reduction/oxidation process is enzymatically catalyzed or which role abiotic side reactions of Fe(II) with reactive N species play. Most pure cultures of nitrate-reducing Fe(II) oxidizers are mixotrophic; i.e., they need an organic cosubstrate to maintain their activity over several cultural transfers. For the few existing autotrophic isolates and enrichment cultures, either the mechanism of nitrate-reducing Fe(II) oxidation is not known or evidence for their autotrophic lifestyle is controversial. In the present study, we provide evidence for the existence of autotrophic nitrate-reducing Fe(II) oxidizers in coastal marine sediments. The evidence is based on stoichiometries of nitrate reduction and Fe(II) oxidation determined in microcosm incubations and the incorporation of carbon from CO₂ under conditions that favor the activity of nitrate-reducing Fe(II) oxidizers.