1
|
Ding W, Fan X, Zhou X, Liu R, Chen C, Jin W, Sun J, Li X, Jiang G, Liu H. Performance and mechanisms of zero valent iron enhancing short-chain fatty acids production during thermophilic anaerobic fermentation of waste activated sludge. THE SCIENCE OF THE TOTAL ENVIRONMENT 2024; 912:169025. [PMID: 38056647 DOI: 10.1016/j.scitotenv.2023.169025] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 09/28/2023] [Revised: 11/28/2023] [Accepted: 11/29/2023] [Indexed: 12/08/2023]
Abstract
This work first explored the feasibility and possible mechanisms of zero valent iron (ZVI) pretreatment on the generation of short-chain fatty acids (SCFAs) during thermophilic anaerobic fermentation of waste activated sludge (WAS). Results showed that ZVI enhanced the quantity of SCFAs. On Day 6, the SCFAs production reached 455.84 ± 47.88 mg COD/g VSS at 5 g/L of ZVI addition, which increased by 63.80 % relative to control. The presence of ZVI can effectively promote butyric-based fermentation. ZVI accelerated the destruction of extracellular polymeric substances (EPS) and interior sludge cells, as well as improved biodegradation of soluble organics. Also, ZVI enhanced key enzyme activities (i.e., BK and CoA-), thus promoting degradation rates of acidogenesis (6.30 ± 0.84 mg/(gVSS·h) in glucose) and acetogenesis (74.63 ± 0.29 mg/(gVSS·h) in butyrate). Compared to Fe(III), the contribution of Fe(II) was higher among the decomposition products of ZVI. Besides, ZVI favored Proteobacteria and Actinobacteria, which enhanced acetate formation and organic compounds disassimilation of the process, respectively. The abundance of Tepidiphilus, Thermobrachium and Tepidimicrobium was increased, indicating promoting the system stability of SCFAs production in thermophilic anaerobic fermentation.
Collapse
Affiliation(s)
- Wanqing Ding
- State Key Laboratory of Urban Water Resource and Environment, School of Civil and Environmental Engineering, Harbin Institute of Technology (Shenzhen), Shenzhen, Guangdong 518055, China
| | - Xiumin Fan
- Shenzhen Ecological and Environmental Intelligent Management and Control Center, Shenzhen 518034, China
| | - Xu Zhou
- State Key Laboratory of Urban Water Resource and Environment, School of Civil and Environmental Engineering, Harbin Institute of Technology (Shenzhen), Shenzhen, Guangdong 518055, China.
| | - Ruining Liu
- State Key Laboratory of Urban Water Resource and Environment, School of Civil and Environmental Engineering, Harbin Institute of Technology (Shenzhen), Shenzhen, Guangdong 518055, China
| | - Chuan Chen
- State Key Laboratory of Urban Water Resource and Environment, School of Environment, Harbin Institute of Technology, Harbin, Heilongjiang Province 150090, China
| | - Wenbiao Jin
- State Key Laboratory of Urban Water Resource and Environment, School of Civil and Environmental Engineering, Harbin Institute of Technology (Shenzhen), Shenzhen, Guangdong 518055, China
| | - Jing Sun
- State Key Laboratory of Pollution Control and Resource Reuse, Key Laboratory of Yangtze River Water Environment, College of Environmental Science and Engineering, Tongji University, Shanghai 200092, China
| | - Xuan Li
- Centre for Technology in Water and Wastewater, School of Civil and Environmental Engineering, University of Technology Sydney, Ultimo, NSW 2007, Australia
| | - Guangming Jiang
- School of Civil, Mining and Environmental Engineering, University of Wollongong, NSW 2522, Wollongong, Australia
| | - Huan Liu
- Centre for Technology in Water and Wastewater, School of Civil and Environmental Engineering, University of Technology Sydney, Ultimo, NSW 2007, Australia
| |
Collapse
|
2
|
Alrowais R, Said N, Mahmoud-Aly M, Helmi AM, Nasef BM, Abdel Daiem MM. Influences of straw alkaline pretreatment on biogas production and digestate characteristics: artificial neural network and multivariate statistical techniques. ENVIRONMENTAL SCIENCE AND POLLUTION RESEARCH INTERNATIONAL 2024; 31:13638-13655. [PMID: 38253834 DOI: 10.1007/s11356-024-31945-7] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Grants] [Track Full Text] [Subscribe] [Scholar Register] [Received: 07/10/2023] [Accepted: 01/05/2024] [Indexed: 01/24/2024]
Abstract
Anaerobic digestion is one of the best options for producing valuable end products (biogas and biofertilizer). The aim of this study was to investigate the influences of thermoalkaline pretreatment of wheat straw on biogas production and digestate characteristics from codigestion with waste-activated sludge. Different alkaline conditions (NaOH, KOH and Na2CO3) and pretreatment durations (1, 3 and 5 h) were used for straw pretreatment. Batch anaerobic codigestion of sludge and pretreated straw was conducted under different pretreatment conditions. A feedforward neural network (FFNN) model, logistic model and statistical analysis were applied to the experimental data to predict biogas and investigate the significance and relationships among the variables. NaOH pretreatment for 5 h showed the best treatment conditions: biogas yield was 6.59 times higher than that without treatment. Moreover, the proportions of total solids, total volatile solids, chemical oxygen demand and microbial count removed reached 63.52%, 74.60%, 78.15% and 82.22%, respectively. The methane content was 67.50%, indicating that the biogas had a high quality. The thermoalkaline pretreatment significantly affected biogas production and digestate characteristics, allowing it to be used as a biofertilizer. Experimental data were successfully modelled for predicting biogas production using the applied models. The R2 values reached 0.985 and 0.999 for the logistic and FFNN models, respectively.
Collapse
Affiliation(s)
- Raid Alrowais
- Department of Civil Engineering, College of Engineering, Jouf University, Sakakah, 72388, Saudi Arabia
| | - Noha Said
- Environmental Engineering Department, Faculty of Engineering, Zagazig University, Zagazig, 44519, Egypt
| | - Mohamed Mahmoud-Aly
- Plant Physiology Division, Department of Agricultural Botany, Faculty of Agriculture, Cairo University, Giza, 12613, Egypt
| | - Ahmed M Helmi
- Computer Engineering Department, Engineering and Information Technology College, Buraydah Private Colleges, Buraydah, 51418, Kingdom of Saudi Arabia
- Computer and Systems Engineering Department, Faculty of Engineering, Zagazig University, Zagazig, 44519, Egypt
| | - Basheer M Nasef
- Computer and Systems Engineering Department, Faculty of Engineering, Zagazig University, Zagazig, 44519, Egypt
| | - Mahmoud M Abdel Daiem
- Environmental Engineering Department, Faculty of Engineering, Zagazig University, Zagazig, 44519, Egypt.
- Civil Engineering Department, College of Engineering, Shaqra University, 11911, Al-Duwadmi, Ar Riyadh, Saudi Arabia.
| |
Collapse
|
3
|
Ćwiertniewicz-Wojciechowska M, Cema G, Ziembińska-Buczyńska A. Sewage sludge pretreatment: current status and future prospects. ENVIRONMENTAL SCIENCE AND POLLUTION RESEARCH INTERNATIONAL 2023; 30:88313-88330. [PMID: 37453013 PMCID: PMC10412499 DOI: 10.1007/s11356-023-28613-7] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Grants] [Track Full Text] [Subscribe] [Scholar Register] [Received: 07/13/2022] [Accepted: 07/01/2023] [Indexed: 07/18/2023]
Abstract
Sewage sludge is regarded by wastewater treatment plants as problematic, from a financial and managerial point of view. Thus, a variety of disposal routes are used, but the most popular is methane fermentation. The proportion of macromolecular compounds in sewage sludges varies, and substrates treated in methane fermentation provide different amounts of biogas with various quality and quantity. Depending on the equipment and financial capabilities for methane fermentation, different methods of sewage sludge pretreatment are available. This review presents the challenges associated with the recalcitrant structure of sewage sludge and the presence of process inhibitors. We also examined the diverse methods of sewage sludge pretreatment that increase methane yield. Moreover, in the field of biological sewage sludge treatment, three future study propositions are proposed: improved pretreatment of sewage sludge using biological methods, assess the changes in microbial consortia caused with pretreatment methods, and verification of microbial impact on biomass degradation.
Collapse
Affiliation(s)
| | - Grzegorz Cema
- Department of Environmental Biotechnology, Silesian University of Technology, Akademicka 2A, 44-100, Gliwice, Poland
| | | |
Collapse
|