Metabolism and pulmonary toxicity of intratracheally instilled cupric sulfate in rats

Pulmonary toxicity of synthetic amorphous silica - effects of porosity and copper oxide doping

Materials can be modified for improved functionality. Our aim was to test whether pulmonary toxicity of silica nanomaterials is increased by the introduction of: a) porosity; and b) surface doping with CuO; and whether c) these modifications act synergistically. Mice were exposed by intratracheal instillation and for some doses also oropharyngeal aspiration to: 1) solid silica 100 nm; 2) porous silica 100 nm; 3) porous silica 100 nm with CuO doping; 4) solid silica 300 nm; 5) porous silica 300 nm; 6) solid silica 300 nm with CuO doping; 7) porous silica 300 nm with CuO doping; 8) CuO nanoparticles 9.8 nm; or 9) carbon black Printex 90 as benchmark. Based on a pilot study, dose levels were between 0.5 and 162 µg/mouse (0.2 and 8.1 mg/kg bw). Endpoints included pulmonary inflammation (neutrophil numbers in bronchoalveolar fluid), acute phase response, histopathology, and genotoxicity assessed by the comet assay, micronucleus test, and the gamma-H2AX assay. The porous silica materials induced greater pulmonary inflammation than their solid counterparts. A similar pattern was seen for acute phase response induction and histologic changes. This could be explained by a higher specific surface area per mass unit for the most toxic particles. CuO doping further increased the acute phase response normalized according to the deposited surface area. We identified no consistent evidence of synergism between surface area and CuO doping. In conclusion, porosity and CuO doping each increased the toxicity of silica nanomaterials and there was no indication of synergy when the modifications co-occurred.

Use of the Cultex® Radial Flow System as an in vitro exposure method to assess acute pulmonary toxicity of fine dusts and nanoparticles with special focus on the intra- and inter-laboratory reproducibility

Exposure of the respiratory tract to airborne particles (including metal-dusts and nano-particles) is considered as a serious health hazard. For a wide range of substances basic knowledge about the toxic properties and the underlying pathomechanisms is lacking or even completely missing. Legislation demands the toxicological characterization of all chemicals placed on the market until 2018 (REACH). As toxicological in vivo data are rare with regard to acute lung toxicity or exhibit distinct limitations (e.g. inter-species differences) and legislation claims the reduction of animal experiments in general ("3R" principle), profound in vitro models have to be established and characterized to meet these requirements. In this paper we characterize a recently introduced advanced in vitro exposure system (Cultex® RFS) showing a great similarity to the physiological in vivo exposure situation for the assessment of acute pulmonary toxicity of airborne materials. Using the Cultex® RFS, human lung epithelial cells (A549 cells) were exposed to different concentrations of airborne metal dusts (nano- and microscale particles) at the air-liquid-interface (ALI). Cell viability (WST-1 assay) as a parameter of toxicity was assessed 24h after exposure with special focus on the intra- and inter-laboratory (three independent laboratories) reproducibility. Our results show the general applicability of the Cultex® RFS with regard to the requirements of the ECVAM (European Centre for the Validation of Alternative Methods) principles on test validity underlining its robustness and stability. Intra- and inter-laboratory reproducibility can be considered as sufficient if predefined quality criteria are respected. Special attention must be paid to the pure air controls that turned out to be a critical parameter for a rational interpretation of the results. Our results are encouraging and future work is planned to improve the inter-laboratory reproducibility, to consolidate the results so far and to develop a valid prediction model.

Acute and subacute toxicity of copper sulfate pentahydrate (CuSO(4)5.H(2)O) in the guppy (Poecilia reticulata)

Chemicals are used for treatment of aquatic diseases, but there is little data available about copper sulfate in small ornamental fish. The aim of the present study was to determine the TLm(24h) and evaluate the toxicity of copper sulfate in the guppy (Poecilia reticulata). The fish were subjected to an acute toxicity test for 24 hr, and the results showed a TLm(24h) value of 1.17 ppm. Severe hyperplasia and exfoliation of the epithelial cells of gill lamellae and obstruction of the internal cavities of renal tubules with necrotized renal epithelial cells sloughed from the basement membrane were observed. However, no significant changes, except for mild curling of gill lamellae, were found in a subacute toxicity test in which fish were exposed to 1/10 of the TLm(24h) value for 1 week. Therefore, use of less than 0.12 ppm of copper sulfate may be recommended as a therapeutic level.

Cardiopulmonary responses of intratracheally instilled tire particles and constituent metal components

Tire and brake wear particles contain transition metals, and contribute to near-road PM. We hypothesized that acute cardiopulmonary injury from respirable tire particles (TP) will depend on the amount of soluble metals. Respirable fractions of two types of TP (TP1 and TP2) were analyzed for water and acid-leachable metals using ICP-AES. Both TP types contained a variety of transition metals, including zinc (Zn), copper (Cu), aluminum, and iron. Zn and Cu were detected at high levels in water-soluble fractions (TP2 > TP1). Male Wistar Kyoto rats (12-14 wk) were intratracheally instilled, in the first study, with saline, TP1 or TP2 (5 mg/kg), and in the second study, with soluble Zn, Cu (0.5 micromol/kg), or both. Pulmonary toxicity and cardiac mitochondrial enzymes were analyzed 1 d, 1 wk, or 4 wk later for TP and 4 or 24 h later for metals. Increases in lavage fluid markers of inflammation and injury were observed at d 1 (TP2 > TP1), but these changes reversed by wk 1. No effects on cardiac enzymes were noted with either TP. Exposure of rats to soluble Zn and Cu caused marked pulmonary inflammation and injury but temporal differences were apparent (Cu effects peaked at 4 h and Zn at 24 h). Instillation of Zn, Cu, and Zn + Cu decreased the activity of cardiac aconitase, isocitrate dehydrogenase, succinate dehydrogenase, cytochrome-c-oxidase and superoxide dismutase suggesting mitochondrial oxidative stress. The observed acute pulmonary toxicity of TP could be due to the presence of water soluble Zn and Cu. At high concentrations these metals may induce cardiac oxidative stress.

Differential ability of transition metals to induce pulmonary inflammation

Transition metals are components of airborne particles and have been implicated in adverse health effects. The relative inflammatory potential of these metals is usually inferred from separate studies that focus on only one or a few individual metals. Comparisons of relative potency among several metals from these separate studies can be difficult. In one comprehensive study, we measured the pulmonary effects of equimolar doses of six metals in soluble form. Our purpose was to compare inflammatory potential and pulmonary toxicity among individual transition metals. Rats received saline, 0.1 or 1.0 micromol/kg of vanadium, nickel, iron(II), copper, manganese, or zinc as sulfates. Bronchoalveolar lavage (BAL) was performed at 0, 4, 16, or 48 h postinstillation. All treatments except V showed increased lactate dehydrogenase activity in BAL fluid; Cu- and Ni-exposed animals had the highest levels. Protein levels in BAL fluid were more than five times higher in Cu-exposed animals compared to other metal treatments at 16 and 48 h. At the 0.1 micromol/kg dose, only Cu induced significant neutrophilia at 16 and 48 h. For the 1.0 micromol/kg dose, all metals tested induced significant neutrophilia, with mean neutrophil numbers for Cu and Mn significantly higher compared to the other metals. At 48 h, neutrophil numbers were still elevated in all metal exposures. Only Mn caused substantial eosinophilia. At the 1.0 micromol/kg dose, only Cu induced macrophage inflammatory protein-2 (MIP-2) mRNA at 4 h. By 48 h, induction of MIP-2 mRNA was observed for all metal exposures except Cu, which subsequently returned to baseline levels. On an equimolar basis, Cu was the most proinflammatory metal, followed by Mn and Ni, while V, Fe(II), and Zn induced similar levels of inflammation. Overall, there were many similarities in the pulmonary responses of the metals we tested. However, we also observed divergent, metal-specific responses. These differential responses suggest that metals induce pulmonary inflammation by differing pathways or combinations of signals.

Copper-dependent inflammation and nuclear factor-kappaB activation by particulate air pollution

Particulate air pollution causes increased cardiopulmonary morbidity and mortality, but the chemical determinants responsible for its biologic effects are not understood. We studied the effect of total suspended particulates collected in Provo, Utah, an area where an increase in respiratory symptoms in relation to levels of particulate pollution has been well documented. Provo particulates caused cytokine-induced neutrophil chemoattractant-dependent inflammation of rat lungs. Provo particulates stimulated interleukin-6 (IL-6) and IL-8 production, increased IL-8 messenger RNA (mRNA) and enhanced expression of intercellular adhesion molecule-1 (ICAM-1) in cultured BEAS-2B cells, and stimulated IL-8 secretion in primary cultures of human bronchial epithelium. Cytokine secretion was preceded by activation of the transcription factor nuclear factor-kappaB (NF-kappaB) and was reduced by treatment of cultures with superoxide dismutase, deferoxamine, or N-acetylcysteine. These biologic effects were replicated by culturing BEAS cells with quantities of Cu2+ found in Provo extract. IL-8 secretion by BEAS cells could be modified by addition of normal constituents of airway lining fluid to the culture medium. Mucin significantly reduced IL-8 secretion, and ceruloplasmin significantly increased IL-8 secretion and activation of NF-kappaB. These findings suggest that copper ions may cause some of the biologic effects of inhaled particulate air pollution in the Provo region of the United States, and may provide an explanation for the sensitivity of asthmatic individuals to Provo particulates that has been observed in epidemiologic studies.

Pulmonary clearance and inflammatory potency of intratracheally instilled or acutely inhaled nickel sulfate in rats

Rats were exposed to nickel sulfate (NiSO4) either by intratracheal (IT) instillation or by acute aerosol inhalation, and pulmonary clearance of Ni and pulmonary inflammatory responses were studied. The half-time of Ni in the lung (initial lung burden = 50 micrograms Ni/rat) was about 32 h in both the IT instillation and inhalation groups. Ni retention in the lung tissue following IT instillation of NiSO4 was saturable with reference to dose, suggesting that clearance rate of Ni from the rat lung depends on lung burden of Ni. Lung inflammatory responses were evaluated by biochemical, elemental and cytological indicators in bronchoalveolar lavage fluid (BALF) following IT instillation of NiSO4. Activities of lactate dehydrogenase and beta-glucuronidase, contents of lysozyme, protein, sulfur and calcium, and the number of polymorphonuclear leukocytes were increased with a peak at 2-3 days post-instillation, while BALF alkaline phosphatase (ALP) activity was significantly decreased after IT instillation of NiSO4. Lung tissue ALP activity was also decreased by NiSO4. Because Ni does not inhibit ALP directly, the decrease in ALP activity is probably due to functional changes of type II cells (a major source of BALF ALP). Thiobarbituric acid reacting substances in the lung tissue were not changed by NiSO4, suggesting that lipid peroxidation plays a minimal, if any role, in the Ni-induced inflammation in the rat lung.

Pulmonary clearance and toxicity of intratracheally instilled cupric oxide in rats

Pulmonary clearance and toxicity of cupric oxide (CuO) dusts, which are probably formed in refining and smelting factories, were investigated. Groups of three rats received intratracheal (i.t.) instillation of CuO at a dose of 20 micrograms Cu/rat in time-course experiments (up to 7 days post-instillation). Other groups of three rats received i.t. instillation of CuO at doses of 2.5, 5, 10, 30, 50 and 100 micrograms Cu/rat and were killed at 2 days post-instillation in dose-effect experiments. Intratracheally instilled CuO particles were cleared from the lung with a half-time of 37 h. Copper binding metallothionein (MT) was induced in a dose-dependent manner and detected at 12 h to 3 days post-instillation. Rapid clearance of CuO from the lung and induction of MT at 12 h post-instillation suggest that CuO particles were solubilized and then cleared from the lung. The acute pulmonary toxicity of CuO was evaluated by cytological (numbers of macrophages and polymorphonuclear leukocytes), biochemical and elemental inflammatory indices (lactate dehydrogenase and beta-glucuronidase activities and protein, sulfur, phosphorus and calcium contents) in the bronchoalveolar lavage (BAL) fluid. These inflammatory indices peaked at 12 h to 3 days post-instillation, and increased with dose over the dose range, except for phosphorus content. Dose-effect relationships in BAL inflammatory indicators of CuO-injected (i.t.) groups were compared to those of CuSO4-injected (i.t.) groups. The results of the comparison indicated that there was no significant difference in acute inflammatory potency between CuSO4 (soluble form of Cu) and CuO (insoluble form of Cu) in the rat lung.

Localization and health effects of lanthanum chloride instilled intratracheally into rats

Lanthanum (La) is one of the rare earths used in diverse high technology fields for which sufficient data for assessing its health effects have been lacking. The biological effects and metabolic behaviors of La were studied by instilling lanthanum chloride intratracheally into male Wistar rats. The distribution of La among tissues revealed that the metal remains mostly in the lung with a biological half-time of 244 days. The subcellular localization by transmission electron microscopy with an X-ray microanalyzer indicated that La localizes in macrophages as high electron-dense granular inclusions in lysosomes and on the cell surface and basement membranes of type I pneumocytes among lung cells. The pulmonary health effects were examined by biological indices of the bronchoalveolar lavage fluid (BALF) and lung tissue. The acute toxicity estimated by lactate dehydrogenase activity in BALF was comparable to those of yttrium and copper that had been determined under the same protocol. Microscopic examination of the lung indicated a characteristic increase in the number of eosinophils.