Report of a collaborative study for assessing the potency of hepatitis B vaccines

Assessing the impact of hepatitis B immune globulin (HBIG) on responses to hepatitis B vaccine during co-administration

INTRODUCTION

A hepatitis B vaccination (HepB) series with an initial dose of hepatitis B immune globulin (HBIG) is the recommended prophylaxis for infants born to mothers with chronic hepatitis B virus (HBV) infection and for HBV-exposed persons without known protection. The HepB and HBIG are administered at different sites (limbs). Instances of HepB and HBIG administered at the same site are documented but the impact on immune responses to HepB remains unanswered.

METHODS

Newborn and adult BALB/c mice received one dose of HepB at time zero alone or with HBIG in the same or different sites, followed by 2 additional doses of HepB at 3 and 10 weeks (newborn mice) or 4 and 16 weeks (adult mice). To study memory responses mice were given a 4th, booster, dose of HepB at 26 weeks and B cells analyzed.

RESULTS

Administration of HepB with HBIG resulted in reduced responses to HepB following the first 2 doses, regardless of site, compared to mice that received HepB only. Lower levels of antibody to HBV surface antigen (anti-HBs) were observed at the end of the 3-dose series (p < 0.0001) in all groups of newborn mice that received HepB and HBIG. In adult mice, this difference was only seen when HepB and HBIG were delivered at the same site. However, following a HepB booster at 26 weeks, HBsAg-specific B-cell expansion and memory phenotype were not impacted by initial HBIG administration CONCLUSION: Administration of HBIG with HepB can delay and reduce responses to HepB in mice. Our findings suggest that the initial circulating levels of HBIG could prevent infection despite an impaired response to vaccine and support the current recommendation of assessing seroprotection after series completion for infants born to HBV carrier mothers, including in cases where vaccine and HBIG are administered incorrectly at the same site.

Comparison between in vitro potency tests for Cuban Hepatitis B vaccine: contribution to the standardization process

Quality control of recombinant Hepatitis B vaccines performed by National Control Laboratories prior to marketing vaccine batches requires in vivo and or a well validated in vitro potency assays as recommended by WHO technical series. The in vitro test must also demonstrate its suitability for monitoring the consistency of the vaccine manufacturer. The aim of this study was to establish the relationship between both in vitro potency tests performed by Cuban manufacturer and National Control Laboratory for Hepatitis B vaccine and the suitability of our method for monitoring the manufacturer's test results and consistency. We also intended to contribute to the standardisation process consisting of in vitro methods for this vaccine.

Quantitative estimation of diphtheria and tetanus toxoids. 5. Comparative assays in mice and in guinea-pigs of two diphtheria toxoid preparations

Two freeze-dried international reference diphtheria toxoids of different origin were compared in biological assays in guinea-pigs and mice under different adjuvant conditions. When the antigenic content in the two toxoids was used as denominator for determination of relative potency, that is to say quantitation of immunogenic power per unit amount of antigen, the design of the animal assay proved to have a major influence. Similar observations have been made previously also for tetanus vaccines. It is concluded that diphtheria vaccines as well as tetanus vaccines can hardly be quantitated unambiguously using the currently recommended potency assays in animals. A new scheme for control of toxoid vaccine production is suggested, with more emphasis on the control of the bulk purified toxoid, which would make the release of final products more simple and rapid.