Cultivation of Scenedesmus acuminatus in different liquid digestates from anaerobic digestion of pulp and paper industry biosludge

Engineered algal systems for the treatment of anaerobic digestate: A meta-analysis

The objective of this review was to provide quantitative insights into algal growth and nutrient removal in anaerobic digestate. To synthesize the relevant literature, a meta-analysis was conducted using data from 58 articles to elucidate key factors that impact algal biomass productivity and nutrient removal from anaerobic digestate. On average, algal biomass productivity in anaerobic digestate was significantly lower than that in synthetic control media (p < 0.05) but large variation in productivity was observed. A mixed-effects multiple regression model across study revealed that biological or chemical pretreatment of digestate significantly increase productivity (p < 0.001). In contrast, the commonly used practice of digestate dilution was not a significant factor in the model. High initial total ammonia nitrogen suppressed algal growth (p = 0.036) whereas initial total phosphorus concentration, digestate sterilization, CO2 supplementation, and temperature were not statistically significant factors. Higher growth corresponded with significantly higher NH4-N and phosphorus removal with a linear relationship of 6.4 mg NH4-N and 0.73 mg P removed per 100 mg of algal biomass growth (p < 0.001). The literature suggests that suboptimal algal growth in anaerobic digestate could be due to factors such as turbidity, high free ammonia, and residual organic compounds. This analysis shows that non-dilution approaches, such as biological or chemical pretreatment, for alleviating algal inhibition are recommended for algal digestate treatment systems.

Microalgae production in human urine: Fundamentals, opportunities, and perspectives

The biological treatment of source-separated human urine to produce biofuel, nutraceutical, and high-value chemicals is getting increasing attention. Especially, photoautotrophic microalgae can use human urine as media to achieve environmentally and economically viable large-scale cultivation. This review presents a comprehensive overview of the up-to-date advancements in microalgae cultivation employing urine in photobioreactors (PBRs). The standard matrices describing algal growth and nutrient removal/recovery have been summarized to provide a platform for fair comparison among different studies. Specific consideration has been given to the critical operating factors to understand how the PBRs should be maintained to achieve high efficiencies. Finally, we discuss the perspectives that emphasize the impacts of co-existing bacteria, contamination by human metabolites, and genetic engineering on the practical microalgal biomass production in urine.

Treatment of Liquid Digestate by Green Algal Isolates from Artificial Eutrophic Pond

The ability of aquatic microalgae to treat the liquid digestate obtained from the anaerobic digestion of plant waste was investigated. Microalgae were isolated from natural environment for a laboratory-scale cultivation and were then used to remove nutrients and organic contaminants from the liquid digestate. It was shown that the microalgae consortia (Tetradesmus obliquus, Microglena sp., Desmodesmus subspicatus) could reduce nitrogen, phosphates, and total COD by up to 70%, 57%, and 95%, respectively. A new algae genus Microglena was isolated, which in a consortium with Tetradesmus obliquus and Desmodesmus subspicatus exhibited a high efficiency in the removal of both organic contaminants and nutrients from the liquid fraction of digestate.

Enhancement of Metabolite Production in High-Altitude Microalgal Strains by Optimized C/N/P Ratio

This study evaluated the role of C/N/P in the increase in the synthesis of carbohydrates, proteins, and lipids in two high-mountain strains of algae (Chlorella sp. UFPS019 and Desmodesmus sp. UFPS021). Three carbon sources (sodium acetate, sodium carbonate, and sodium bicarbonate), and the sources of nitrogen (NaNO3) and phosphate (KH2PO4 and K2HPO4) were analyzed using a surface response (3 factors, 2 levels). In Chlorella sp. UFPS019, the optimal conditions to enhance the synthesis of carbohydrates were high sodium carbonate content (3.53 g/L), high KH2PO4 and K2HPO4 content (0.06 and 0.14 g/L, respectively), and medium-high NaNO3 (0.1875 g/L). In the case of lipids, a high concentration of sodium acetate (1.19 g/L) coupled with high KH2PO4 and K2HPO4 content (0.056 and 0.131 g/L, respectively) and a low concentration of NaNO3 (0.075 g/L) drastically induced the synthesis of lipids. In the case of Desmodesmus sp. UFPS021, the protein content was increased using high sodium acetate (2 g/L), high KH2PO4 and K2HPO4 content (0.056 and 0.131 g/L, respectively), and high NaNO3 concentration (0.25 g/L). These results demonstrate that the correct adjustment of the C/N/P ratio can enhance the capacity of high-mountain strains of algae to produce high concentrations of carbohydrates, proteins, and lipids.

Treatment and resource utilization of dairy liquid digestate by nitrification of biological aerated filter coupled with assimilation of Chlorella pyrenoidosa

Ammonia inhibition is considered a key issue when using liquid digestate for microalgae cultivation. To study the effect of pretreatment with a biological aerated filter (BAF) on microalgae culture with dairy liquid digestate, nitrification characteristics of BAFs under different hydraulic retention time (HRT) and the growth characteristics of Chlorella pyrenoidosa in effluents of BAFs were investigated. Results showed that the BAFs can rapidly nitrify ammonia nitrogen and significantly improve the light transmittance of liquid digestate (the maximum promotion rate was ~260%), and the effect improved as the HRT increased. Pretreatment of liquid digestate with BAFs can eliminate ammonia inhibition for C. pyrenoidosa. Furthermore, lipid, crude protein, and higher heating value (HHV) output were also not affected by HRT. The similar removal of nitrate nitrogen in microalgae culture systems using effluents with 6-h and 12-h HRT (21.59% and 21.07%, respectively) were recorded. The results suggested that BAF coupled with microalgae culture is a novel option on the resource utilization of dairy liquid digestate.

Water reuse and growth inhibition mechanisms for cultivation of microalga Euglena gracilis

BACKGROUND

Microalgae can contribute to more than 40% of global primary biomass production and are suitable candidates for various biotechnology applications such as food, feed products, drugs, fuels, and wastewater treatment. However, the primary limitation for large-scale algae production is the fact that algae requires large amounts of fresh water for cultivation. To address this issue, scientists around the world are working on ways to reuse the water to grow microalgae so that it can be grown in successive cycles without the need for fresh water.

RESULTS

In this study, we present the results when we cultivate microalgae with cultivation water that is purified and reused. Specifically, we purify the cultivation water using an ultrafiltration membrane (UFM) treatment and investigate how this treatment affects: the biomass and biochemical components of the microalgae; characteristics of microalgae growth inhibitors; the mechanism whereby potential growth inhibitors are secreted (followed using metabolomics analysis); the effect of activated carbon (AC) treatment and advanced oxidation processes (AOPs) on the removal of growth inhibitors of Euglena gracilis. Firstly, the results show that E. gracilis can be only cultivated through two growth cycles with water that has been filtered and reused, and the growth of E. gracilis is significantly inhibited when the water is used a third time. Secondly, as the number of reused water cycles increases, the Cl^- concentration gradually increases in the cultivation water. When the Cl^- concentration accumulates to a level of fivefold higher than that of the control, growth of E. gracilis is inhibited as the osmolality tolerance range is exceeded. Interestingly, the osmolality of the reused water can be reduced by replacing NH₄Cl with urea as the source of nitrogen in the cultivation water. Thirdly, E. gracilis secretes humic acid (HA)-which is produced by the metabolic pathways for valine, leucine, and isoleucine biosynthesis and by linoleic acid metabolism-into the cultivation water. Because HA contains large fluorescent functional groups, specifically extended π(pi)-systems containing C=C and C=O groups and aromatic rings, we were able to observe a positive correlation between HA concentration and the rate of inhibition of E. gracilis growth using fluorescence spectroscopy. Moreover, photosynthetic efficiency is adversely interfered by HA, thereby reductions in the synthetic efficiency of paramylon and lipid in E. gracilis. In this way, we are able to confirm that HA is the main growth inhibitor of E. gracilis. Finally, we verify that all the HA is removed or converted into nutrients efficiently by AC or UV/H₂O₂/O₃ treatments, respectively. As a result of these treatments, growth of E. gracilis is restored (AC treatment) and the amount of biomass is promoted (UV/H₂O₂/O₃ treatment).

CONCLUSIONS

These studies have important practical and theoretical significance for the cyclic cultivation of E. gracilis and for saving water resources. Our work may also provide a useful reference for other microalgae cultivation.

Efficient production of fatty acid methyl esters by a wastewater-isolated microalgae-yeast co-culture

Improving the competitiveness of biodiesel production by microalgae cultures requires the application of several strategies to obtain a high content of lipids, rapid biomass growth and a capacity to adapt to different kinds of environment, with the aim of using non-renewable nutrient sources. Therefore, the use of an individual indigenous microalgae strain or a consortium from natural or anthropogenic sites is now considered an alternative for biofuel production. This study examined the temporal behaviour of secondary metabolites produced by a native microalgae and yeast consortium isolated from wastewater, which was characterized by a genetic identification method based on the MiSeq system. The predominant species in the consortium was Scenedesmus obliquus, representing 68% of the organisms. In addition, the consortium contained a number of yeast species, including Candida pimensis (43%), Arthroderma vanbreuseghemii (23%), Diaporthe aspalathi/Diaporthe meridionalis (25%) and Hericium americanum (3%). This indigenous co-culture of microalgae and yeast showed biomass productivity of 0.06 g l^-1 day^-1, with a content of 30% (w/w) carbohydrates, 4% (w/w) proteins and 55% (w/w) lipids. Transesterification of the extracted lipids produced fatty acid methyl esters (FAMEs), which were analysed by gas chromatography (GC). The FAMEs included methyl pentadecanoate (1.90%), cis-10-pentanedecanoic acid methyl ester (1.36%), methyl palmitate (2.64%), methyl palmitoleate (21.36%), methyl oleate (64.95%), methyl linolenate (3.83%) and methyl linolelaidate (3.95%). This composition was relevant for biodiesel production based on the co-culture of indigenous microalgae and yeast consortia.

Effect of Pre-Corrected pH on the Carbohydrate Hydrolysis of Bamboo during Hydrothermal Pretreatment

To confirm the prospects for application of pre-corrected pH hydrothermal pretreatment in biorefineries, the effects of pH on the dissolution and degradation efficiency of carbohydrates were studied. The species composition of the hydrolysate was analyzed using high efficiency anion exchange chromatography and UV spectroscopy. The result showed that the greatest balance between the residual solid and total dissolved solids was obtained at pH 4 and 170 °C. Maximum recovery rates of cellulose and lignin were as expected, whereas hemicellulose had the least recovery rate. The hemicellulose extraction rate was 42.19%, and the oligomer form accounted for 93.39% of the product. The physicochemical properties of bamboo with or without pretreatment was characterized. Compared with the traditional hydrothermal pretreatment, the new pretreatment bamboo has higher fiber crystallinity and thermal stability. In the pretreatment process, the fracture of β-aryl ether bond was inhibited and the structural dissociation of lignin was reduced. The physicochemical properties of bamboo was protected while the hemicellulose was extracted efficiently. It provides theoretical support for the efficient utilization of all components of woody biomass.

Insights into the resources generation from pulp and paper industry wastes: Challenges, perspectives and innovations

Pulp and paper industry is swiftly budding to fulfill industrial needs and with the growth of this industry, a large amount of waste has also generated which includes biological sludge generated from the wood digestion process, fly ash accumulation and lime mud produced in chemical reagent recovery circuit. There are many health hazards associated with generated wastes and this waste material can be utilized in sustainable ways to generate useful resources through technological innovations. This review highlights a few useful aspects of waste conversion to resources like the production of green energy, sorbent development, and clinker preparation. The generation of resources from such wastes is a revolutionary and innovative concept for sustainable development including valorization of the generated waste to integrate pulp and paper industry with biorefinery. This review paper focuses on the sustainable utilization of waste from such industry along with its efficiency and future challenges.

Microalgae grow on source separated human urine in Nordic climate: Outdoor pilot-scale cultivation

Human urine contributes approximately 80% of nitrogen and 50% of phosphorous in urban wastewaters while having a volume of only 1-1.5 L/d per capita compared to 150-200 L/d per capita of wastewater generated. There is interest to study source separation of urine and search methods to recover the nutrients form the urine. In this study, the objective was to use the nutrients in source separated urine for outdoor cultivation of microalgae in Nordic climate. A freshwater green microalga Scenedesmus acuminatus was grown in different dilutions (1:20 and 1:15) of source separated human urine, in a semi-continuously operated outdoor raceway pond with a liquid volume of 2000 L, at hydraulic retention time of 15 d. The microalgae could remove 52% nitrogen and 38% phosphorus even at culture temperatures as low as 5 °C, while obtaining a biomass density of 0.34 g VSS/L. Harvested microalgal biomass could be used to produce methane with a yield of 285 L CH₄/kg volatile solids.