Pharmacokinetic Comparability of Risankizumab Formulations in Prefilled Syringe and Auto-injector for Subcutaneous Injection

Clinical Bridging From Prefilled Syringe to On-body Injector for Risankizumab in Crohn's Disease

PURPOSE

This article describes the clinical development bridging strategy and key data to support the marketing application of the risankizumab on-body injection (OBI) system for the treatment of moderately to severely active Crohn's disease (CD), even though the OBI was not evaluated directly in the pivotal Phase III studies in CD.

METHODS

Three studies were conducted as part of the clinical bridging strategy. The pilot pharmacokinetics (PK) study was a Phase I, single-dose, 4-arm, open-label, randomized, parallel-group exploratory PK and tolerability study that assessed the effect of rate and volume of administration on the bioavailability (BA) of risankizumab and the extent of injection site-related pain after subcutaneous (SC) administration in healthy subjects. The pivotal BA/bioequivalence (BE) study was a relative BA/BE bridging study in healthy subjects to assess the relative BA of the to-be-marketed risankizumab OBI compared with the prefilled syringe (PFS) used in the Phase III CD studies. The OBI adhesive study was a randomized, open-label, non-drug interventional study in healthy subjects to assess the OBI adhesive effectiveness and skin tolerability at 2 different locations (abdomen and upper thigh) over different periods of time (5 and 30 minutes).

FINDINGS

The pilot PK study showed that risankizumab exposures were similar across different rates/volumes of SC administration in healthy subjects, thereby supporting further development of the OBI. Second, a pivotal BA/BE study showed comparability between the OBI and Phase III PFS with bioequivalent risankizumab AUCs and no clinically meaningful difference for Cmax based on the wide therapeutic window of risankizumab. In both studies, no new safety risks were identified. No impact of immunogenicity on PK profile or safety was observed for the OBI. Third, an adhesive OBI (without risankizumab) study showed that there were no differences in adhesion/skin tolerability observed over time (up to 30 minutes) or for location of adhesion, and the OBI device adhesion was well tolerated at both the abdomen and thigh locations.

IMPLICATIONS

These results supported the risankizumab OBI presentation approval in CD.

Pharmacokinetics and tolerability of prefilled syringe and auto-injector presentations of MSB11456: results of a randomized, single-dose study in healthy adults

BACKGROUND

Tocilizumab is a monoclonal immunoglobulin G interleukin-6 receptor antagonist. MSB11456 is a proposed tocilizumab biosimilar.

OBJECTIVE

To determine the pharmacokinetic equivalence of a single subcutaneous injection of MSB11456, when delivered via autoinjector (AI) and prefilled syringe (PFS), in healthy adult subjects.

RESEARCH DESIGN AND METHODS

In this randomized, open-label, single fixed-dose, crossover study, 91 subjects received subcutaneous administration of tocilizumab 162 mg via AI and PFS presentations. The primary endpoint pharmacokinetic parameters were analyzed using analysis of variance. Safety data were summarized descriptively.

RESULTS

There were no differences in pharmacokinetic parameters between presentations, and safety parameters were comparable. The 90% confidence intervals for the geometric least squares mean ratios of all primary pharmacokinetic parameters were contained within the predefined 80.00% to 125.00% bioequivalence limits, indicating pharmacokinetic equivalence between the AI and PFS.

CONCLUSIONS

MSB11456 administration via AI was bioequivalent to administration via PFS. MSB11456 can be administered by AI or PFS, increasing the available range of self-injection devices.

TRIAL REGISTRATION

The trial is registered at EudraCT, number 2020-003419-86.

A review of bridging clinical studies between different presentations of biological products approved by the United States Food and Drug Administration (US FDA)

INTRODUCTION

There is growing interest in the development of multiple presentations for biological products for subcutaneous (SC) injection for life cycle management and product differentiation. Bridging clinical studies are required to extrapolate the existing data package to new presentations.

AREAS COVERED

This review compiles information of bridging clinical studies conducted for biological products administered by the SC route and approved in more than one presentation by the United States Food and Drug Administration's Center for Drug Evaluation and Research up until 31 December 2021. Information regarding indication(s), presentation(s), approval pathways, approval timelines, and various aspects of bridging clinical studies was collected from published documents.

EXPERT OPINION

The type of bridging clinical study can depend on the extent of differences between presentations, existing data packages, and the stage of the product development. Design of a bridging clinical study should be based on the characteristics of a biological product and should be aimed at detecting the relevant differences between presentations. Single-dose comparative pharmacokinetics in normal healthy volunteers is the most common bridging clinical study design. Covariates like body weight and injection site should be considered during the design of these studies. The impact of the different user interfaces of presentations should also be considered.

Efficacy, safety, usability, and acceptability of risankizumab 150 mg formulation administered by prefilled syringe or by an autoinjector for moderate to severe plaque psoriasis

BACKGROUND

Risankizumab is approved for treatment of moderate to severe plaque psoriasis. Availability of a patient-controlled single self-injection of risankizumab may improve adherence and long-term management of psoriasis.

OBJECTIVE

To investigate efficacy, safety, and usability of a new risankizumab 150 mg/mL formulation administered as a single subcutaneous injection via prefilled syringe (PFS) or autoinjector (AI).

METHODS

Efficacy, safety, usability, and acceptability of risankizumab 150 mg/mL PFS or AI were investigated in adults with moderate to severe psoriasis in two phase 3 studies. Study 1 was a multicenter, randomized, double-blinded, placebo-controlled study that investigated 150 mg/mL risankizumab PFS; study 2 was a multicenter, single-arm, open-label study that investigated 150 mg/mL risankizumab AI.

RESULTS

At week 16, risankizumab 150 mg/mL demonstrated efficacy vs. placebo (Psoriasis Area and Severity Index ≥90% improvement (PASI 90), 62.9% vs. 3.8%; static Physician Global Assessment (sPGA) 0/1, 78.1% vs. 9.6%; both p< .001) in study 1; in study 2, PASI 90 and sPGA 0/1 were 66.7%, and 81.5%, respectively. All patients successfully self-administered study treatments via PFS or AI. Acceptability of self-injection was high in both studies. Efficacy and safety of risankizumab 150 mg/mL were comparable with results from previous risankizumab phase 3 studies using the 90 mg/mL formulation.

CONCLUSIONS

The efficacy, safety, and usability of 150 mg/mL risankizumab delivered as a single PFS or AI injection support use of this new formulation in patients with moderate to severe plaque psoriasis.

CLINICAL TRIALS

NCT03875482 and NCT0387508.