Escherichia colimultiple [Ni-Fe]-hydrogenases are sensitive to osmotic stress during glycerol fermentation but at different pHs

Syngas biological transformation into hydroxyectoine

Syngas from the gasification of organic wastes represents a promising feedstock for fostering a sustainable bioeconomy. However, its potential is currently constrained by the low-value products generated. Osmolytes, such as hydroxyectoine, are high-value compounds, however, their biological production as isolated osmolytes is not yet cost-effective. This study utilized shotgun genomics and laboratory validation to find a carboxydotrophic, halotolerant bacterium, Hydrogenibacillus schlegelii, that could produce hydroxyectoine using H2, CO and CO2 as the sole source of energy and carbon. Subsequently, NaCl concentration, temperature and syngas composition were optimized in semi-continuous bioreactors. Optimal conversion of CO into hydroxyectoine occurred at a gas composition of 70 %:10 % CO:H2 (v/v) (44.8 ± 10.1 mghydroxyectoine·gbiomass-1). NaCl concentrations of 5 % significantly enhanced hydroxyectoine content (46.7 ± 9.5 mghydroxyectoine·gbiomass-1), but negatively affected gas consumption. This study opens new perspectives for the valorisation of syngas into hydroxyectoine, and for new cell platforms for pharmaceutical production based on syngas.

Role of the Escherichia coli FocA and FocB formate channels in controlling proton/potassium fluxes and hydrogen production during osmotic stress in energy-limited, stationary phase fermenting cells

Escherichia coli FocA and FocB formate channels export formate or import it for further disproportionation by the formate hydrogenlyase (FHL) complex to H2 and CO2. Here, we show that under pH and osmotic stress FocA and FocB play important roles in regulating proton and potassium fluxes and couple this with H2 production in stationary-phase cells. Using whole-cell assays with glucose as electron donor, a focB mutant showed a 50 % decrease in VH2, while N'N'-dicyclohexylcarbodiimide (DCCD) treatment of osmotically stressed cells underlined the role of FOF1 ATPase in H2 production. At pH 7.5 and under osmotic stress FocB contributed to the proton flux but not to the potassium flux. At pH 5.5 both formate channels contributed to the proton and potassium fluxes. Particulalry, a focA mutant had 40 % lower potassium flux whereas the proton flux increased approximately two-fold. Moreover, at pH 5.5H2 production was totally inhibited by DCCD in the focA mutant. Taken together, our results suggest that depending on external pH, the formate channels play an important role in osmoregulation by helping to balance proton/potassium fluxes and H2 production, and thus assist the proton FOF1-ATPase in maintenance of ion gradients in fermenting stationary-phase cells.

Osmotic stress as a factor for regulating E. coli hydrogenase activity and enhancing H2 production during mixed carbon sources fermentation

Escherichia coli performs mixed-acid fermentation and produces molecular hydrogen (H2) via reversible hydrogenases (Hyd). H2 producing activity was investigated during hyper- and hypo-osmotic stress conditions when a mixture of carbon sources (glucose and glycerol) was fermented at different pHs. Hyper-osmotic stress decreased H2 production rate (VH2) ~30 % in wild type at pH 7.5 when glucose was supplemented, while addition of formate stimulated VH2 ~45% compared to hypo-stress conditions. Only in hyfG in formate assays was VH2 inhibited ~25% compared to hypo-stress conditions. In hypo-stress conditions addition of glycerol increased VH2 ~2 and 3 fold in hybC and hyfG mutants, respectively, compared to wild type. At pH 6.5 hyper-osmotic stress stimulated VH2 ~2 fold in all strains except hyaB mutant when glucose was supplemented, while in formate assays significant stimulation (~3 fold) was determined in hybC mutant. At pH 5.5 hyper-osmotic stress inhibited VH2 ~30% in wild type when glucose was supplemented, but in formate assays it was stimulated in all strains except hyfG. Taken together, it can be concluded that, depending on external pH and absence of Hyd enzymes in stationary-phase-grown osmotically stressed E. coli cells, H2 production can be stimulated significantly which can be applied in developing H2 production biotechnology.

Propionic and valproic acids have an impact on bacteria viability, proton flux and ATPase activity

Short-chain fatty acids like propionic (PPA) and valproic acids (VP) can alter gut microbiota, which is suggested to play a role in development of autism spectrum disorders (ASD). In this study we investigated the role of various concentrations of PPA and VP in gut enteric gram-negative Escherichia coli K12 and gram-positive Enterococcus hirae ATCC 9790 bacteria growth properties, ATPase activity and proton flux. The specific growth rate (µ) was 0.24 h-1 and 0.82 h-1 in E. coli and E. hirae, respectively. Different concentrations of PPA reduced the value of µ similarly in both strains. PPA affects membrane permeability only in E. hirae. PPA decreased DCCD-sensitive ATPase activity in the presence of K+ ions by 20% in E. coli and 40% in E. hirae suggesting the importance of the FOF1-K+ transport system in the regulation of PPA-disrupted homeostasis. Moreover, the H+ flux during PPA consumption could be the protective mechanism for enteric bacteria. VP has a selective effect on the µ depending on bacteria. The overwhelming effect of VP was detected on the K+-promoted ATPase activity in E. hirae. Taken together it can be suggested that PPA and VP have a disruptive effect on E. coli and E. hirae growth, viability, bioenergetic and biochemical properties, which are connected with the alteration of FOF1-ATPase activity and H+ flux rate or direction.

Evidence for Escherichia coli DcuD carrier dependent FOF1-ATPase activity during fermentation of glycerol

During fermentation Escherichia coli excrete succinate mainly via Dcu family carriers. Current work reveals the total and N,N'-dicyclohexylcarbodiimide (DCCD) inhibited ATPase activity at pH 7.5 and 5.5 in E. coli wild type and dcu mutants upon glycerol fermentation. The overall ATPase activity was highest at pH 7.5 in dcuABCD mutant. In wild type cells 50% of the activity came from the FOF1-ATPase but in dcuD mutant it reached ~80%. K+ (100 mM) stimulate total but not DCCD inhibited ATPase activity 40% and 20% in wild type and dcuD mutant, respectively. 90% of overall ATPase activity was inhibited by DCCD at pH 5.5 only in dcuABC mutant. At pH 7.5 the H+ fluxes in E. coli wild type, dcuD and dcuABCD mutants was similar but in dcuABC triple mutant the H+ flux decreased 1.4 fold reaching 1.15 mM/min when glycerol was supplemented. In succinate assays the H+ flux was higher in the strains where DcuD is absent. No significant differences were determined in wild type and mutants specific growth rate except dcuD strain. Taken together it is suggested that during glycerol fermentation DcuD has impact on H+ fluxes, FOF1-ATPase activity and depends on potassium ions.

Reduced use of phosphorus and water in sequential dark fermentation and anaerobic digestion of wheat straw and the application of ensiled steam-pretreated lucerne as a macronutrient provider in anaerobic digestion

BACKGROUND

Current EU directives demand increased use of renewable fuels in the transportation sector but restrict governmental support for production of biofuels produced from crops. The use of intercropped lucerne and wheat may comply with the directives. In the current study, the combination of ensiled lucerne (Medicago sativa L.) and wheat straw as substrate for hydrogen and methane production was investigated. Steam-pretreated and enzymatically hydrolysed wheat straw [WSH, 76% of total chemical oxygen demand (COD)] and ensiled lucerne (LH, 24% of total COD) were used for sequential hydrogen production through dark fermentation and methane production through anaerobic digestion and directly for anaerobic digestion. Synthetic co-cultures of extreme thermophilic Caldicellulosiruptor species adapted to elevated osmolalities were used for dark fermentation.

RESULTS

Based on 6 tested steam pretreatment conditions, 5 min at 200 °C was chosen for the ensiled lucerne. The same conditions as applied for wheat straw (10 min at 200 °C with 1% acetic acid) would give similar sugar yields. Volumetric hydrogen productivities of 6.7 and 4.3 mmol/L/h and hydrogen yields of 1.9 and 1.8 mol/mol hexose were observed using WSH and the combination of WSH and LH, respectively, which were relatively low compared to those of the wild-type strains. The combinations of WSH plus LH and the effluent from dark fermentation of WSH plus LH were efficiently converted to methane in anaerobic digestion with COD removal of 85-89% at organic loading rates of COD 5.4 and 8.5 g/L/day, respectively, in UASB reactors. The nutrients in the combined hydrolysates could support this conversion.

CONCLUSIONS

This study demonstrates the possibility of reducing the water addition to WSH by 26% and the phosphorus addition by 80% in dark fermentation with Caldicellulosiruptor species, compared to previous reports. WSH and combined WSH and LH were well tolerated by osmotolerant co-cultures. The yield was not significantly different when using defined media or hydrolysates with the same concentrations of sugars. However, the sugar concentration was negatively correlated with the hydrogen yield when comparing the results to previous reports. Hydrolysates and effluents from dark fermentation can be efficiently converted to methane. Lucerne can serve as macronutrient provider in anaerobic digestion. Intercropping with wheat is promising.

Identification of enhanced hydrogen and ethanol Escherichia coli producer strains in a glycerol-based medium by screening in single-knock out mutant collections

BACKGROUND

Earth's climate is warming as a result of anthropogenic emissions of greenhouse gases from fossil fuel combustion. Bioenergy, which includes biodiesel, biohydrogen and bioethanol, has emerged as a sustainable alternative fuel source. For this reason, in recent years biodiesel production has become widespread but this industry currently generates a huge amount of glycerol as a by-product, which has become an environmental problem in its own right. A feasible possibility to solve this problem is the use of waste glycerol as a carbon source for microbial transformation into biofuels such as hydrogen and ethanol. For instance, Escherichia coli is a microorganism that can synthesize these compounds under anaerobic conditions.

RESULTS

In this work an experimental procedure was established for screening E. coli single mutants to identify strains with enhanced ethanol and/or H2 productions compared to the wild type strain. In an initial screening of 150 single mutants, 12 novel strains (gnd, tdcE, rpiA nanE, tdcB, deoB, sucB, cpsG, frmA, glgC, fumA and gadB) were found to provide enhanced yields for at least one of the target products. The mutations, that improve most significantly the parameters evaluated (gnd and tdcE genes), were combined with other mutations in three engineered E. coli mutant strains in order to further redirect carbon flux towards the desired products.

CONCLUSIONS

This methodology can be a useful tool to disclose the metabolic pathways that are more susceptible to manipulation in order to obtain higher molar yields of hydrogen and ethanol using glycerol as main carbon source in multiple E. coli mutants.

Metabolic Engineering of Escherichia coli for Production of Mixed-Acid Fermentation End Products

Mixed-acid fermentation end products have numerous applications in biotechnology. This is probably the main driving force for the development of multiple strains that are supposed to produce individual end products with high yields. The process of engineering Escherichia coli strains for applied production of ethanol, lactate, succinate, or acetate was initiated several decades ago and is still ongoing. This review follows the path of strain development from the general characteristics of aerobic versus anaerobic metabolism over the regulatory machinery that enables the different metabolic routes. Thereafter, major improvements for broadening the substrate spectrum of E. coli toward cheap carbon sources like molasses or lignocellulose are highlighted before major routes of strain development for the production of ethanol, acetate, lactate, and succinate are presented.