Desiccation and thermal resistance of Salmonella and Enterococcus faecium NRRL B-2354 in almond meal as impacted by water activity and storage temperature

Effect of environmental conditions on the survival and transfer of Enterococcus faecium between wheat flour and selected contact surfaces

Low moisture food safety issues are frequently associated with Salmonella and its cross-contamination. As a non-pathogenic surrogate, the survival levels and transfer of Enterococcus faecium NRRL B-2354 on stainless steel (SS) and polypropylene (PP) coupons were investigated. The transfer rates of E. faecium between coupons and wheat flour were also determined at different temperature (13, 25, 37, and 49 °C) and humidity levels (45, 55, 65, and 75%). Results showed that survival of E. faecium on the coupons was not significantly affected by the selected material type. At 25 °C and 45% humidity, E. faecium with an inoculation level of ∼107 CFU/cm2 decreased by 2.69 ± 0.28 Log CFU/cm2 and 2.85 ± 0.32 Log CFU/cm2 on SS and PP surface after 96 h, respectively. While temperature did not significantly influence the transfer rate, humidity did. The highest transfer rate from coupons to wheat flour (5.10 ± 0.23%) occurred at 75% relative humidity. Rougher surfaces reduced the transfer rate from coupons to wheat flour, but not the reverse. Moreover, the transfer rate from coupons to wheat flour was significantly higher than the reverse. These findings highlight the significant role of environmental factors and surface properties in cross-contamination.

Heat Resistance, Virulence, and Gene Expression of Desiccation-Adapted Salmonella Enteritidis During Long-Term Storage in Low-Water Activity Foods

Desiccation stress could induce crossprotection and even affect virulence of Salmonella enterica. However, the influence of food matrices with low-water activity on desiccation adaptation of Salmonella still remains unclear. This study investigated the survival and adaptation of Salmonella Enteritidis in skim milk powder, ginger powder, and chocolate powder under desiccation storage conditions for a total of 12 weeks. High survival rates of Salmonella Enteritidis in all food matrices maintained over the long-term desiccation storage. Desiccation-adapted Salmonella Enteritidis enhanced heat resistance (p < 0.05) with the increase of storage time. Food composition plays an important role in the induction of crossresistance of desiccation-adapted Salmonella. After desiccation storage, Salmonella Enteritidis in ginger powder was most tolerant to heat treatment. Salmonella Enteritidis in skim milk powder was most resistant to the gastrointestinal simulation environment, and had strongest adhesion to Caco-2 cells. The effects of food composition on gene expression (rpoS, proV, otsA, otsB, grpE, dnaK, rpoH, and sigDE) in desiccation-adapted Salmonella Enteritidis were not significant (p > 0.05). At initial desiccation storage, osmotic protection-related genes (fadA, proV, otsA, and otsB), stress response regulator (rpoS), and heat-resistance-related genes (grpE, dnaK, and rpoH) were all significantly upregulated (p < 0.05). However, after 4-week storage, the expression level of desiccation-related genes, proV, otsA, otsB, grpE, dnaK, and rpoH, significantly decreased (p < 0.05). This study enables a better understanding of Salmonella's responses to long-term desiccation stress in different kinds of low-water activity foods.

Survival and thermal resistance of Salmonella in chocolate products with different water activities

Contamination of Salmonella in chocolate products has caused worldwide outbreaks and recalls. There is a lack of information on the impact of water activity (aw) on the stability of Salmonella in chocolate products during storage and thermal treatments. In this research, the survival and thermal resistance of a Salmonella cocktail (S. Enteritidis PT30, S. Tennessee K4643, S. Typhimurium S544) was examined in different chocolate products (dark chocolate, white chocolate, milk chocolate) at two aw levels (0.25, 0.50) over 12 months at 22 °C. A reduction of 4.19 log10 CFU/gof Salmonella was obtained in dark chocolate after 12 months (aw = 0.50, at 22 °C); less reductions were observed in white and milk chocolates. In all three products, more reductions were observed ataw = 0.50 than at aw = 0.25 over the 12-months storage. When treated at 80 °C, the D-values (time required to cause 1 log reduction) of the Salmonella cocktail in the chocolate samples with initial aw of 0.25 were 35.7, 25.2 and 11.6 min in dark, white and milk chocolate, respectively, before the storage. The D80°C -values of Salmonella cocktail in the samples with initial aw of 0.50 were 6.45, 7.46, and 3.98 min in dark, white and milk chocolate, respectively. After 12 months of storage at 22 °C, the D80°C-value of Salmonella cocktail decreased to 9.43 min (p < 0.05) in milk chocolate but remained 22.7 min in white chocolate with an aw of 0.25 at 22 °C. The data suggests that Salmonella can survive in chocolate products for up to 12 months, and its thermal resistance remained relatively stable. Thus, Salmonella is resistant to desiccation in chocolates, particularly in milk and white chocolates, and its thermal resistance remains during one-year storage, which could pose a potential threat for future outbreaks.

Microbial Diversity and Bioactive Compounds in Dried Lycium barbarum Fruits (Goji): A Comparative Study

This study compares the microbial diversity and content of bioactive compounds in dried goji berries available on the Polish market to those of the most highly valued goji berries from the Ningxia region in China. The content of phenols, flavonoids, and carotenoids were determined, as well as the antioxidant capacities of the fruits. The quantitative and qualitative composition of the microbiota inhabiting the fruits was assessed using metagenomics by high-throughput sequencing on the Illumina platform. The highest quality was demonstrated by naturally dried fruits from the Ningxia region. These berries were characterized by a high content of polyphenols and high antioxidant activity, as well as high microbial quality. The lowest antioxidant capacity was shown by goji berries cultivated in Poland. However, they contained a high amount of carotenoids. The highest microbial contamination was found in the goji berries available in Poland (>10⁶ CFU/g), which is important in terms of consumer safety. Despite the widely accepted benefits of consuming goji berries, both the country of cultivation and the preservation method may influence their composition, bioactivity, and microbial quality.

Practice and Progress: Updates on Outbreaks, Advances in Research, and Processing Technologies for Low-moisture Food Safety

Large, renowned outbreaks associated with low-moisture foods (LMFs) bring to light some of the potential, inherent risks that accompany foods with long shelf lives if pathogen contamination occurs. Subsequently, in 2013, Beuchat et al. (2013) noted the increased concern regarding these foods, specifically noting examples of persistence and resistance of pathogens in low-water activity foods (LWAFs), prevalence of pathogens in LWAF processing environments, and sources of and preventive measures for contamination of LWAFs. For the last decade, the body of knowledge related to LMF safety has exponentially expanded. This growing field and interest in LMF safety have led researchers to delve into survival and persistence studies, revealing that some foodborne pathogens can survive in LWAFs for months to years. Research has also uncovered many complications of working with foodborne pathogens in desiccated states, such as inoculation methods and molecular mechanisms that can impact pathogen survival and persistence. Moreover, outbreaks, recalls, and developments in LMF safety research have created a cascading feedback loop of pushing the field forward, which has also led to increased attention on how industry can improve LMF safety and raise safety standards. Scientists across academia, government agencies, and industry have partnered to develop and evaluate innovate thermal and nonthermal technologies to use on LMFs, which are described in the presented review. The objective of this review was to describe aspects of the extensive progress made by researchers and industry members in LMF safety, including lessons-learned about outbreaks and recalls, expansion of knowledge base about pathogens that contaminate LMFs, and mitigation strategies currently employed or in development to reduce food safety risks associated with LMFs.

Bioactivities and Microbial Quality of Lycium Fruits (Goji) Extracts Derived by Various Solvents and Green Extraction Methods

Goji berries, known for their health-promoting properties, are increasingly consumed around the world, often in the form of naturally- or freeze-dried fruits, further unprocessed. The aim of the study was to obtain dried goji berries extracts, characterized by high bioactivity and safety in terms of microbial contamination for the consumer. In the study, various solvents (water, ethanol, acetone, ethyl lactate, sunflower oil) and green extraction methods (heating and ultrasound-assisted extraction (UAE)) were used. In goji extracts, antioxidant activity and carotenoids content as bioactivity indicators, as well as total number of microorganisms were determined. Boiling of powdered dried goji fruits in water resulted in extracts with the best features, i.e., with high antioxidant properties (2.75−4.06 μmol of Trolox equivalent (TE)/mL), moderate to high content of carotenoids (0.67−1.86 mg/mL), and a reduced number of microorganisms compared with fruits. Extracts in 50% ethanol and 50% acetone were characterized primarily by very high antioxidant activity (3.09−4.90 μmol TE/mL). The high content of carotenoids (0.98−3.79 mg/mL) and high microbial quality (<10 CFU/g) were obtained by extraction in ethyl lactate by the UAE method. The results could be useful in the development of functional food based on goji berry ingredients.

Multi-Channel Optical Device for Solar-Driven Bacterial Inactivation under Real-Time Temperature Feedback

Solar-driven photothermal antibacterial devices have attracted a lot of interest due to the fact that solar energy is one of the cleanest sources of energy in the world. However, conventional materials have a narrow absorbance band, resulting in deficient solar harvesting. In addition, lack of knowledge on temperature change in these devices during the photothermal process has also led to a waste of energy. Here, we presented an elegant multi-channel optical device with a multilayer structure to simultaneously address the above-mentioned issues in solar-driven antibacterial devices. In the photothermal channel, semiconductor IrO₂ -nanoaggregates exhibited higher solar absorbance and photothermal conversion efficiency compared with nanoparticles. In the luminescence channel, thermal-sensitive Er-doped upconversion nanoparticles were utilized to reflect the microscale temperature in real-time. The bacteria were successfully inactivated during the photothermal effect under solar irradiation with temperature monitoring. This study could provide valuable insight for the development of smart photothermal devices for solar-driven photothermal bacterial inactivation in the future.