Using the agricultural environment to select better surrogates for foodborne pathogens associated with fresh produce

Estimating the Risk of Acute Gastrointestinal Disease Attributed to E. coli O157:H7 in Irrigation Water and Agricultural Soil: A Quantitative Microbial Risk Assessment

Introduction: The occurrence of E. coli O157:H7 in the agricultural environment poses a serious threat to public health. The primary aim was to estimate the probability of illness caused by E. coli O157:H7 in irrigation water and agricultural soil niches. Methods: The Quantitative Microbial Risk Assessment was used and the risks were characterized using the Monte Carlo simulation with 10,000 iterations. Results: The mean levels of E. coli O157:H7 in the irrigation water and agricultural soil samples was 1.328 × 103 CFU/100 mL (Range: 0.00 to 13.000 × 103 CFU/100 mL) and 2.482 × 103 CFU/g (Range: 0.167 × 103 to 16.333 × 103 CFU/g), respectively. The risk of infection in humans exposed to this water and soil was 100%. In addition, a high risk of acute diarrheal disease was estimated at 25.0 × 10−2 for humans exposed to contaminated water and/or soil. Summary: These results exceeded the WHO diarrheal disease risk standard of 1.0 × 10−3. These findings demonstrated a high probability of acute gastrointestinal disease among humans exposed to E. coli O157:H7 in irrigation water and agricultural soil samples collected from the study sites representing a huge public health threat.

Disrupting Irreversible Bacterial Adhesion and Biofilm Formation with an Engineered Enzyme

Biofilm formation is often attributed to postharvest bacterial persistence on fresh produce and food handling surfaces. In this study, a predicted glycosyl hydrolase enzyme was expressed, purified, and validated for the removal of microbial biofilms from biotic and abiotic surfaces under conditions used for chemical cleaning agents. Crystal violet biofilm staining assays revealed that 0.1 mg/ml of enzyme inhibited up to 41% of biofilm formation by Escherichia coli O157:H7, E. coli 25922, Salmonella enterica serovar Typhimurium, and Listeria monocytogenes. Furthermore, the enzyme was effective at removing mature biofilms, providing a 35% improvement over rinsing with a saline solution alone. Additionally, a parallel-plate flow cell was used to directly observe and quantify the impact of enzyme rinses on E. coli O157:H7 cells adhering to spinach leaf surfaces. The presence of 1 mg/liter enzyme resulted in nearly 6-times-higher detachment rate coefficients than a deionized (DI) water rinse, while the total cells removed from the surface increased from 10% to 25% over the 30-min rinse time, reversing the initial phases of biofilm formation. Enzyme treatment of all 4 cell types resulted in significantly reduced cell surface hydrophobicity and collapse of negatively stained E. coli 25922 cells imaged by electron microscopy, suggesting potential polysaccharide surface modification of enzyme-treated bacteria. Collectively, these results point to the broad substrate specificity and robustness of the enzyme for different types of biofilm stages, solution conditions, and pathogen biofilm types and may be useful as a method for the removal or inhibition of bacterial biofilm formation. IMPORTANCE In this study, the ability of an engineered enzyme to reduce bacterial adhesion and biofilm formation of several foodborne pathogens was demonstrated, representing a promising option for enhancing or replacing chlorine and other chemical sanitizers in food processing applications. Specifically, significant reductions of biofilms of the pathogens Escherichia coli O157:H7, Salmonella Typhimurium, and Listeria monocytogenes are observed, as are reductions in initial adhesion. Enzymes have the added benefits of being green, sustainable alternatives to chemical sanitizers, as well as having a minimal impact on food properties, in contrast to many alternative antimicrobial options such as bleach that aim to minimize food safety risks.

Effectiveness of a peracetic acid solution on Escherichia coli reduction during fresh-cut lettuce processing at the laboratory and industrial scales

Fresh leafy greens like lettuce can be consumed raw and are susceptible to foodborne pathogens if they become contaminated. Recently, the number of reported pathogenic foodborne outbreaks related to leafy greens has increased. Therefore, it is important to try to alleviate the human health burden associated with these outbreaks. Processing of fresh-cut lettuce, including washing, is a step in the supply chain that needs to be well controlled to avoid cross-contamination. Current measures to control the quality of lettuce during washing include the use of chemicals like chlorine; however, questions regarding the safety of chlorine have prompted research for alternative solutions with peracetic acid (PAA). This study evaluates the effectiveness of a PAA (c.a. 75 mg/L) solution on the reduction of a commensal E. coli strain during the washing of fresh-cut lettuce. Experiments were performed at the laboratory scale and validated at the industrial scale. We observed that the use of PAA was not adversely affected by the organic load in the water. The contact time and dose of the PAA showed to be relevant factors, as observed by the approximately 5-log reduction of E. coli in the water. Results showed that once introduced during washing, E. coli remained attached to the lettuce, thus supporting the need to control for pathogenic bacteria earlier in the supply chain (e.g., during primary production) as well as during washing. Moreover, our results showed that the use of PAA during washing did not have an apparent effect on the levels of fluorescent pseudomonads (FP) and total heterotrophic bacteria (THB) in lettuce. Overall, our results at the laboratory and industrial scales confirmed that during the processing of fresh-cut produce, where the accumulation of soil, debris, and other plant exudates can negatively affect washing, the use of a PAA (c.a. 75 mg/L) solution was an effective and safe wash water disinfectant that can potentially be used at the industrial scale.

In vitro and in situ inhibition of some food-borne pathogens by essential oils from date palm (Phoenix dactylifera L.) spathe

Essential oils extracted by hydro-distillation form date palm spathe (byproduct from date palm plants) were tested for their antibacterial activity against some food-borne pathogens. Listeria monocytogenes ATCC 7644, Staphylococcus aureus ATCC 29243, Salmonella enterica subsp. enterica serovar Enteritidis ATCC 13076 and E. coli ATCC 25922 were inhibited (11-13 mm inhibition zones) by spathe essential oils (SEOs) using the agar well assay (in vitro test). Staphylococcus aureus ATCC 29243 and E. coli ATCC 25922 were not detected in chicken meat treated with 1% (v/w) SEOs and subjected to abusive storage conditions (20 °C for 18 h). When treated with 0.5% SEO, counts of S. aureus and E. coli increased by only 0.2 and 0.7 log₁₀ cfu/g, respectively, compared to the initial inoculated level in meat samples stored at 20 °C for 18 h. SEOs possessed DPPH radical scavenging activity with IC₅₀ of 0.61 μg/ml. Forty one compounds were major constituents detected by GC-MS analysis of SEOs. 3,4-Dimethoxytoluene (38.12%) and 5,9-Undecadien-2-one (12.45%) were major compounds in extracted oils. Density and refractive index of SEOs were 0.987 and 1.5905, respectively. SOEs are added-value products from date palm, which could be employed in food industry and pharmaceuticals. The study is the first report on antibacterial activity of SEOs against L. monocytogenes ATCC 7644 and other standard food-borne pathogens in agar diffusion assay and food model (chicken meat). DPPH radical scavenging activity of SEOs has not previously been documented.

Escherichia coli O157:H7 and Salmonella Typhimurium adhesion to spinach leaf surfaces: Sensitivity to water chemistry and nutrient availability

This study investigated the effects of solution chemistry and growth conditions on bacterial deposition on spinach leaf surfaces using a parallel plate flow cell. Two food safety pathogens of concern and two non-pathogen bacterial surrogates (environmental E. coli isolates) were grown in ideal (LB media) and nutrient-restricted (M9 media) conditions. Bacterial attachment was quantified as mass transfer rate coefficients for cells suspended in 10 mM KCl, CaCl₂ and artificial groundwater, and cell and leaf surfaces were extensively characterized (zeta potential, hydrophobicity, extracellular polymer (EPS) composition). Between the pathogens, E. coli O157:H7 attachment was greater than that of Salmonella Typhimurium, attributed to measurable variability in cell surface charge and hydrophobicity. When grown in M9 media, both pathogens were significantly more adhesive to spinach surfaces (p < 0.01) than when grown in LB media. Surrogates did not follow this trend and showed minimal changes in adhesion kinetics and surface properties between growth conditions. EPS sugar/protein ratios were reduced in some of the highest attachment scenarios, suggesting that changes in EPS composition in favor of proteins may play a role. These results show the importance of growth conditions and solution complexities in understanding mechanisms of aqueous bacterial adhesion to food surfaces.