Liquid chromatographic tandem mass spectrometric determination of five coccidiostats in poultry eggs and feed

Simultaneous Analysis of Nicarbazin, Diclazuril, Toltrazuril, and Its Two Metabolites in Chicken Muscle and Eggs by In-Syringe Dispersive Solid-Phase Filter Clean-Up Followed by Liquid Chromatography-Tandem Mass Spectrometry

Nicarbazin (NICA) and triazine anticoccidial drugs (diclazuril (DIZ) and toltrazuril (TOZ)) are the primary strategy for preventing and treating coccidiosis. To prevent the development of drug resistance and mitigate the potential chronic toxicity to humans resulting from prolonged exposure, a liquid chromatography-tandem mass spectrometry method with high reliability and sensitivity was developed to determine NICA, DIZ, TOZ, and its two metabolites in chicken muscle and eggs. Upon establishing the extraction conditions involving 10 mL of acetonitrile and 10 min of sonication, in-syringe dispersive solid-phase extraction with silica was performed in combination with n-hexane clean-up. The selection of isotope peaks of precursor ions and low-mass range scanning allowed the two transitions for the quantification of all compounds. The limits of detection for DIZ and NICA were both 0.1 μg/kg, and for TOZ and metabolites, they were 0.3 μg/kg; the limits of quantitation were 0.3 and 1 μg/kg, respectively. The linear range was 0.25-50 ng/mL with a correlation coefficient r > 0.999. The average recoveries at three spiking levels in muscle and eggs were 90.1-105.2% and 94.0-103.7% with the relative standard deviations of 3.0-8.1% and 3.1-14.4%, respectively. The precision, accuracy, and stability were evaluated by three quality control samples.

Generation and Characterization of an Anti-diclazuril Monoclonal Antibody and Development of a Diagnostic Enzyme-Linked Immunosorbent Assay for Poultry

An anti-diclazuril monoclonal antibody (mAb) was developed for use in enzyme-linked immunosorbent assay (ELISA)-based detection of diclazuril with high sensitivity and specificity, which can be used to measure anti-coccidial drug residues. The anti-diclazuril mAb had a half-maximal inhibitory concentration of 0.449–0.517 ng/mL. The mAb cross-reactivity with toltrazuril, toltrazuril 18 sulfone, clozaril, monesin, madurmycin, and salinomycin was very minimal (< 0.1%). The detection limit of the ELISA using this mAb was 0.10 ng/mL and the sensitivity was 0.05 ng/mL. A standard curve generated in the range of 0.05–16.2 ng/mL had a linear correlation coefficient value of ≥ 0.99. The average recoveries of diclazuril from chicken and duck samples ranged from 85.0 to 102.5%.Intra- and inter-assay coefficients of variation ranged from 5.9 to 8.5% and 9.2 to 12.6%, respectively. Using the International Immunogenetics Information System^®, the VH domain of the mAb was found to be encoded by an IGHV3 family gene and had the following complementarity determining region (CDR) sequences: GFTFSRY (CDR1), SRGGS (CDR2), and GDDNYAFAY (CDR3). The VL domain was encoded by an IGKV1 family gene and had the following CDR sequences: KSSQSLLNSRTRKNYLA (CDR1), WASTRES (CDR2), and KQSYNLHT (CDR3). This study provides a method to generate anti-diclazuril mAbs and determine their variable region sequences. The diagnostic ELISA developed using this mAb may drive additional studies on the monitoring and detection of food and veterinary drug residues.

Solvent Front Position Extraction and some conventional sample preparation techniques for the determination of coccidiostats in poultry feed by LC-MS/MS

Solvent Front Position Extraction is a novel technique developed for effective sample preparation of biological samples containing coccidiostats prior to LC–MS/MS. In this study the technique was used for isolation and determination of seven coccidiostats, from both main groups being: ionophores and chemical coccidiostats. Its effectiveness was evaluated by comparing with other sample preparation procedures, used in European routine laboratories. Results obtained by Solvent Front Position Extraction were very satisfactory (linearity R² ≥ 0.971, recovery 90.1–111.1%, RSDr: 8.7–16.6%, RSD_R: 9.0–17.7%) and fulfilled requirements described in Commission Regulation (EU) 2021/808 of 22 March 2021, which showed great potential of the technique in sample preparation of coccidiostats in poultry feed.

Design, Synthesis, and Characterization of Tracers and Development of a Fluorescence Polarization Immunoassay for Rapid Screening of 4,4'-Dinitrocarbanilide in Chicken Muscle

The compound, 4,4′-dinitrocarbanilide (DNC), is the marker residue of concern in edible tissues of broilers fed with diets containing anticoccidial nicarbazin (NIC). In this study, 25 fluorescein-labeled DNC derivatives (tracers) are synthesized and characterized to develop a rapid fluorescence polarization immunoassay (FPIA) for the detection of DNC in chickens using DNC monoclonal antibodies (mAbs). The effect of the tracer structure on the sensitivity of the FPIA is investigated. Our results show that after optimization, the half maximal inhibitory concentrations (IC₅₀) and limit of detection (LOD) of the FPIA in the buffer are 28.3 and 5.7 ng mL⁻¹, respectively. No significant cross-reactivity (CR < 0.89%) with 15 DNC analogues is observed. The developed FPIA is validated for DNC detection in spiked chicken homogenates, and recoveries ranged from 74.2 to 85.8%, with coefficients of variation <8.6%. Moreover, the total time needed for the detection procedure of the FPIA, including sample pretreatment, is <40 min, which has not been achieved in any other immunoassays for DNC from literature. Our results demonstrate that the FPIA developed here is a simple, sensitive, specific, and reproducible screening method for DNC residues in chickens.

Preparation of a Magnetic Nanoporous Polymer for the Fast and Efficient Extraction of 5-Nitroimidazoles in Milk

A magnetic nanoporous organic polymer (M-NOP) was prepared as a new adsorbent with excellent extraction capacity and rapid adsorption kinetics for 5-nitroimidazoles (5-NDZs). Hence, a rapid and effective method was proposed for determination of 5-NDZs in milk by combining M-NOP-based magnetic solid-phase extraction with high-performance liquid chromatography. Main extraction conditions were investigated. Under optimal conditions, good linear response was achieved in a range of 2.4-100 ng mL^-1 with a lower detection limit of 0.8-1.0 ng mL^-1. High accuracy with a recovery of 80.0-116.0% for the fortified samples, good repeatability with relative standard deviation below 10%, and a high enrichment factor of 97-111 were obtained. The rapid adsorption of 5-NDZs on M-NOP is mainly driven by H-bonding, π-stacking, and polar interactions. Finally, the M-NOP-based method was successfully used to determine 5-NDZs in milk samples. The M-NOP is expected to present promising application in the extraction and quantitative analysis of other compounds.

Current research, regulation, risk, analytical methods and monitoring results for nicarbazin in chicken meat: A perspective review

This review presents up-to-date information about current research on nicarbazin, one of the most used anticoccidials in poultry production. The focus is to elucidate regulation concerning nicarbazin, limits for its residues in food, how maximum residue limits in different countries are calculated regarding edible chicken tissues and the possible implications in human health. Analytical methods to extract and quantify this residue, expressed as dinitrocarbanilide (DNC) are presented and discussed, including qualitative screening and quantitative/confirmatory analytical methods. Monitoring results and occurrence of DNC residues in chicken meat are discussed. Additionally, the causes of eventual chicken meat contamination and possible solutions to reduce or eliminate DNC residue in tissues are also presented. The paper concludes with perspectives, the current state of DNC residue analysis and suggestions for future research, especially considering the gap in the study of residue recycling effect due to continuous chicken litter use.

A simple and high-throughput method for determination and confirmation of 14 coccidiostats in poultry muscle and eggs using liquid chromatography - quadrupole linear ion trap - tandem mass spectrometry (HPLC-QqLIT-MS/MS): Validation according to European Union 2002/657/EC

A simple and fast quantitative and confirmatory multi-residue method was developed and validated for the determination of 14 coccidiostats residues in poultry muscle and eggs using liquid chromatography-tandem mass spectrometry (LC/MS-MS). The compounds were analyzed in a single run including lasalocid A, maduramicin, monensin, narasin, salinomycin, semduramicin, robenidine, diclazuril, toltrazuril, trimethoprim, clopidol, amprolium, diaveridine and nicarbazin (as the marker residue dinitrocarbanilide). A low-cost extraction and clean up procedure was optimized without the need of solid-phase extraction. Samples were extracted with acetonitrile followed by low-temperature clean up. Chromatographic separation was achieved using a C18 column, using water and acetonitrile, both containing 5mmolL^-1 of formic acid and 1mmolL^-1 ammonium acetate, as mobile phase. Coccidiostats were ionized in negative and positive mode and monitored simultaneously. The method was fully validated according with Commission Decision 2002/657/EC and was applied for >100 samples from the Brazilian National Residue Control Plan (NRCP). Parameters as precision, reproducibility, trueness, CCα and CCβ were determined. Trueness values were within the range 73-115%. Precision (repeatability and intermediate precision) ranged from 0.4% to 21% and intralaboratory reproducibility ranged from 6.3% to 27%, depending on matrix.

Gas chromatography − mass spectral characteristics of six pharmacologically active compounds — analytical performance characteristics on a raw sewage impacted water sample

We have interrogated the characteristics of six pharmacologically active compounds in a hot gas chromatograph injector including some mass spectral characteristics in a quadrupole mass analyzer. The analytes are dimetridazole, metronidazole, chlorpromazine, trimethoprim, sulfamethazine, and dapsone. We have demonstrated the impact of the injector on the conversion efficiency of solvent to vapor in relation to analytes under investigation. The overall analytical performance of key parameters that were scrutinized and tested on a spiked raw sewer water sample using electron ionization (EI), positive chemical ionization (PCI), and negative chemical ionization (NCI) in the full and selected ion monitoring (SIM) scan modes are also presented. These parameters were the instrument detection limits (IDLs), method detection limits (MDLs), linearities, and percent recoveries. Correlation coefficients (R2) were greater than 0.9950 using all ionization and scan modes. Better MDLs were obtained using the SIM mode in all instances. The SIM mode MDLs ranged as follows: EI 0.308–0.711 and PCI 0.656–1.14 mg/L. Extremely good signals were observed in the NCI mode with dimetridazole and metronidazole where MDLs in the SIM mode were estimated to be 0.057 and 0.062 mg/L. Percent relative standard deviations (n = 3) were all less than 5% using EI employing full and SIM scan modes. Recoveries ranged from 55% to 96% in the full scan mode and from 67% to 94% in the SIM mode. Signal losses and ion population ratios in relation to the number of samples, i.e., scan speed and the mass scan range, are also interrogated.

Determination of 20 coccidiostats in egg and avian muscle tissue using ultra high performance liquid chromatography-tandem mass spectrometry

A quantitative, comprehensive multiresidue method which includes 20 coccidiostat residues has been developed. The method described uses a simple one-step liquid extraction with acetonitrile to isolate analytes from both the polyether ionophore and chemical classes of coccidiostats. Subsequent to a further concentration step, samples were analysed via UHPLC-MS/MS. The method was validated according to the Commission Decision 2002/657/EEC in egg and avian muscle. The method permitted quantitative confirmation for 13 compounds below target concentrations, and screening for a further 7 compounds. Within-laboratory repeatability gave accuracy values in the range of 68-129%, while reproducibility ranged between 75 and 123%. Calibration ranges were typically 1-50 μg kg⁻¹, although higher ranges were used for dinitrocarbanilide, imidocarb and toltrazuril residues. A regression coefficient (R²) value of greater than 0.98 was obtained for all analytes. Precision results ranged from 2.3 to 19.7% CV for egg and from 2.6 to 23.6% CV in muscle. CCα was in the range from 1.13 μg kg⁻¹ (clopidol) to 179 μg kg⁻¹ (lasalocid) in egg. In muscle, CCα ranged from 2.25 μg kg⁻¹ (aprinocid) to 4579 μg kg⁻¹ (dinitrocarbanilide). CCβ was from 1.29 μg kg⁻¹ (clopidol) to 209 μg kg⁻¹ (lasalocid) in egg, and 2.58 μg kg⁻¹ (arprinocid) to 6060 μg kg⁻¹ (dinitrocarbanilide) in muscle. Limits of quantification were 1 μg kg⁻¹ for all compounds, except imidocarb and dinitrocarbanilide (10 μg kg⁻¹), and toltrazuril and metabolites (50 μg kg⁻¹).

Multi-mycotoxin analysis in eggs using a QuEChERS-based extraction procedure and ultra-high-pressure liquid chromatography coupled to triple quadrupole mass spectrometry

A reliable and rapid method has been developed for the determination of 10 mycotoxins (beauvericin, enniatin A, A1, B1, citrinin, aflatoxin B1, B2, G1, G2 and ochratoxin A) in eggs at trace levels. Ultra-high-pressure liquid chromatography coupled to tandem mass spectrometry (UHPLC-MS/MS) has been used for the analysis of these compounds in less than 7 min. Mycotoxins have been extracted from egg samples using a QuEChERS-based extraction procedure (Quick, Easy, Cheap, Effective, Rugged and Safe) without applying any further clean-up step. Extraction, chromatographic and detection conditions were optimised in order to increase sample throughput and sensitivity. Matrix-matched calibration was used for quantification. Blank samples were fortified at 10, 25, 50 and 100 μg kg(-1), and recoveries ranged from 70% to 110%, except for ochratoxin A and aflatoxin G1 at 10 μg kg(-1), and aflatoxin G2 at 50 μg kg(-1). Relative standard deviations were lower than 25% in all the cases. Limits of detection ranged from 0.5 μg kg(-1) (for aflatoxins B1, B2 and G1) to 5 μg kg(-1) (for enniatin A, citrinin and ochratoxin A) and limits of quantification ranged from 1 μg kg(-1) (for aflatoxins B1, B2 and G1) to 10 μg kg(-1) (for enniatin A, citrinin and ochratoxin A). Seven samples were analyzed and aflatoxins B1, B2, G1, G2, and beauvericin were detected at trace levels.

Development and validation of a multi-residue liquid chromatography-tandem mass spectrometry confirmatory method for eleven coccidiostats in eggs

A confirmatory method for the determination of residues of eleven coccidiostats including ionophore antibiotics: lasalocid, maduramycin, monensin, narasin, salinomycin, semduramycin and chemical coccidiostats: decoquinate, diclazuril, halofuginone, nicarbazin and robenidine in poultry eggs was developed and validated. The sample was extracted with acetonitrile, defatted with hexane and cleaned-up on a silica SPE cartridge. The analytes were identified and quantified by liquid chromatography-tandem mass spectrometry (LC-MS/MS). The method performance characteristics required by Commission Decision 2002/657/EC were estimated adopting a more flexible and simple validation design. In this alternative approach the experimental study focuses on a larger dynamic range with progressively increasing validation levels. Each of them presents equal concentrations of all the analytes. On the contrary the classical Decision plan investigates a restricted concentration range necessarily different for each analyte being determined by the individual permitted limit (0.5-1.5 times the permitted limit). As a consequence each validation level involves the simultaneous fortification with complex mixtures containing different concentrations of each analyte. Adopting this alternative strategy the validation of several substances with significantly different permitted limits is considerably simplified and a deeper knowledge of the method is achieved. The results proved that the method enables the confirmation of regulated coccidiostats in eggs at the levels required in the official control of residues (CCα in the range of 2.2-174 μg kg(-1), depending on the coccidiostat). The repeatability (CV(r) in the range of 1.1-19%) and within-laboratory reproducibility (CV(Rw) in the range of 1.8-30%) are also acceptable. The procedure was successfully verified in the proficiency test and implemented in the national residue control plan.

Development of a multi-class method for the quantification of veterinary drug residues in feedingstuffs by liquid chromatography-tandem mass spectrometry

A simple multi-residue method was developed for detecting and quantifying 33 analytes from 13 classes of antibiotics (tetracyclines (3), quinolones (7), penicillins (3), ionophore coccidiostats (7), macrolides (3), sulfonamides (1), quinoxalines (2), phenicols (2), lincosamides (1), diaminopyrimidines (1), polypeptides (1), streptogramins (1) and pleuromutilins (1)) in animal feeds. Extraction and clean-up procedures were optimized with spiked piglet feed. Samples were extracted by ultrasonic-assisted extraction with a mixture of methanol/acetonitrile/McIlvaine buffer at pH 4.6 (37.5/37.5/25, v/v/v) containing 0.3% of EDTA-Na(2), followed by a clean up using a dispersive solid-phase extraction (d-SPE) with PSA (primary secondary amine). Detection of antibiotics was achieved by liquid chromatography-electrospray tandem mass spectrometry (LC-ESI-MS/MS) within 28 min using both positive and negative ESI mode. Average recoveries ranged from 51% (oxytetracycline) to 116% (tilmicosin) with associated relative standard deviations of 7.3% and 9.0% and an overall mean of 87%. Limits of quantification ranged from 3.8 ngg(-1) (lincomycin) to 65.0 ngg(-1) (bacitracin). Following optimization, the method was further verified for bovine and lamb feeding stuffs; negative matrix effects were evaluated and overcome by a standard addition method.

Multi-residue confirmatory method for the determination of twelve coccidiostats in chicken liver using liquid chromatography tandem mass spectrometry

The confirmatory LC-MS/MS method for the determination of residues for twelve coccidiostats including ionophore antibiotics (lasalocid, maduramycin, monensin, narasin, salinomycin, semduramycin) and chemical coccidiostats (clazuril, decoquinate, diclazuril, halofuginone, nicarbazin and robenidine) in poultry liver has been developed. The sample preparation was based on extraction with acetonitrile, defatting with Alumina columns and clean-up on Oasis HLB spe. The separation of analytes was performed on PhenylHexyl column with a gradient of acetonitrile, methanol and the ammonium formate pH 4.0. For all analytes, at least 2 diagnostic fragmentation ions were monitored. The validation, performed according to the CD 2002/657/EC, proved the suitability of the method for the confirmatory analysis of the coccidiostats. For lasalocid, however, low reproducibility was observed and the proper quantification could not be performed with this method.

Use of antigen mimics to produce specific antibodies to anti-coccidial drugs

A range of polyclonal antibodies was successfully produced to the coccidiostatic drugs diclazuril and robenidine. Initial attempts to make immunogenic complexes of both drugs were ineffective due to difficulties encountered while trying to couple the compounds to large carrier proteins. Structural mimics, which could act as haptens for each drug, were sought and identified. The compounds identified were more open to chemical manipulation and were conjugated to carrier proteins to produce effective immunogens. The most sensitive antisera produced displayed IC50s of 1.5 ng/ml and 13 ng/ml for diclazuril and robenidine respectively. The antibody for diclazuril was shown to be specific, cross-reacting only with clazuril by 15%. The robenidine antibody displayed a low cross-reactivity of 1.2% to the compound used to produce the antibody.

Development and validation of a lateral flow device for the detection of nicarbazin contamination in poultry feeds

Concentrations of the coccidiostat nicarbazin as low as 2 mg/kg in feed can result in violative drug residues arising in poultry liver. A lateral flow device (LFD) was developed for the detection of contaminating concentrations of nicarbazin following solvent extraction of poultry feeds. Test results, as determined by both visual and instrumental measurement, are available within minutes. For 22 feed samples, nicarbazin-free and fortified at 2 mg/kg, the % relative inhibition ranged from 0 to 45% and from 53 to 85%, respectively. Nicarbazin contamination at the critical concentration (2 mg/kg) can be determined in all cases providing the sampling is representative. A wide range of feed samples taken at a mill that incorporated nicarbazin into poultry feed were analyzed. Data generated for these samples by both the LFDs and a mass spectrometric method were compared, and a significant correlation was achieved.

Incidence of residues of nine anticoccidials in eggs

A survey of the presence of residues of anticoccidials was performed. Three hundred and twenty egg samples, purchased in eight different European countries, were analysed for the presence of nine different compounds: dimetridazole, diclazuril, halofuginone, robenidine, nicarbazin, narasin, salinomycin, lasalocid and monensin. Analyses were performed by LC-MS/MS. Of the samples analysed, 114 (35.6%) contained one or more of the nine anticoccidials in concentrations ranging from 0.1 to 63 microg kg-1. Salinomycin and lasalocid account for more than 60% of all positive samples. Almost 90% of all positive samples contained less than 2 microg kg-1. Results were put into perspective of the farming method and country of origin.