Comparative vinification assays with selected Patagonian strains of Oenococcus oeni and Lactobacillus plantarum

Enhancing wine malolactic fermentation: Variable effect of yeast mannoproteins on Oenococcus oeni strains

Lactic acid bacteria (LAB), principally Oenococcus oeni, play crucial roles in wine production, contributing to the transformation of L-malic acid into L-lactic acid during malolactic fermentation (MLF). This fermentation is influenced by different factors, including the initial LAB population and wine stress factors, such as nutrient availability. Yeast mannoproteins can enhance LAB survival in wine. This study explored in model conditions the impact of a commercial mannoprotein extract on MLF dynamics in ten O. oeni strains. The results revealed strain-specific responses in fermentation kinetics and mannoprotein utilization. Mannoprotein addition influenced MLF outcomes, depending on the strain and concentration. The variability in MLF confirmed different technological aptitude of the strains used. The α-mannosidase enzymatic activity was determined and showed higher values in the supernatant than in whole cells. Moreover, α-mannosidase activity varied among strains, suggesting differential regulation in response to fermentation conditions. These findings highlight the importance of understanding mannoprotein interactions with O. oeni for optimizing MLF efficiency and enhancing wine quality. Further research under cellar conditions is needed to evaluate the potential of yeast mannoproteins to promote MLF.

Bioprospecting Indigenous Oenococcus oeni Strains from Chinese Wine Regions: Multivariate Screening for Stress Tolerance and Aromatic Competence

Malolactic fermentation (MLF), an essential enological process for wine deacidification and aroma development, is predominantly mediated by Oenococcus oeni (O. oeni). This investigation characterized 170 indigenous O. oeni isolates from two principal Chinese viticultural regions (Yinchuan, Ningxia, and Changli, Hebei) through polyphasic analysis. Forty-nine strains demonstrating genetic potential for efficient malate metabolism and biosafety compliance (absence of ethyl carbamate and biogenic amines genes) were subjected to adaptive laboratory evolution under enologically relevant stress conditions. Comparative evaluation with the superior indigenous strain SD-2a revealed eight stress-adapted isolates exhibiting superior MLF kinetics, completing L-malic acid degradation in Marselan wine. Solid-phase microextraction-gas chromatography-mass spectrometry (SPME-GC-MS) profiling identified three isolates' (3-31, 9-10, and 9-50) significant enhancement of key fermentation aromas in experimental fermentations. These oenologically adapted indigenous strains demonstrate promising potential as regional-specific starter cultures, providing a scientific foundation for developing terroir-expressive winemaking practices and optimizing microbial resources in China's wine industry.

Vineyard-mediated factors are still operative in spontaneous and commercial fermentations shaping the vinification microbial community and affecting the antioxidant and anticancer properties of wines

The grapevine and vinification microbiota have a strong influence on the characteristics of the produced wine. Currently we have a good understanding of the role of vineyard-associated factors, like cultivar, vintage and terroir in shaping the grapevine microbiota. Notwithstanding, their endurance along the vinification process remains unknown. Thus, the main objective of our study was to determine how these factors influence (a) microbial succession during fermentation (i.e., bacterial and fungal) and (b) the antioxidant, antimutagenic and anticancer potential of the produced wines. These were evaluated under different vinification strategies (i.e., spontaneous V1, spontaneous with preservatives V2, commercial V3), employed at near full-scale level by local wineries, for two cultivars (Roditis and Sideritis), two terroir types, and two vintages. Cultivar and vintage were strong and persistent determinants of the vinification microbiota, unlike terroir whose effect became weaker from the vineyard, and early fermentation stages, where non-Saccharomyces yeasts, filamentous fungi (i.e., Aureobasidium, Cladosporium, Lachancea, Alternaria, Aspergillus, Torulaspora) and acetic acid bacteria (AAB) (Gluconobacter, Acetobacter, Komagataeibacter) dominated, to late fermentation stages where Saccharomyces and Oenococcus become prevalent. Besides vineyard-mediated factors, the vinification process employed was the strongest determinant of the fungal community compared to the bacterial community were effects varied per cultivar. Vintage and vinification type were the strongest determinants of the antioxidant, antimutagenic and anticancer potential of the produced wines. Further analysis identified significant positive correlations between members of the vinification microbiota like the yeasts Torulaspora debrueckii and Lachancea quebecensis with the anticancer and the antioxidant properties of wines in both cultivars. These findings could be exploited towards a microbiota-modulated vinification process to produce high-quality wines with desirable properties and enhanced regional identity.

A rapid and reliable method for the determination of Lactiplantibacillus plantarum during wine fermentation based on PMA-CELL-qPCR

Real-time monitoring of microbial dynamics during fermentation is essential for wine quality control. This study developed a method that combines the fluorescent dye propidium monoazide (PMA) with CELL-qPCR, which can distinguish between dead and live microbes for Lactiplantibacillus plantarum. This method could detect the quantity of microbes efficiently and rapidly without DNA extraction during wine fermentation. The results showed that (1) the PMA-CELL-qPCR enumeration method developed for L. plantarum was optimized for PMA treatment concentration, PMA detection sensitivity and multiple conditions of sample pretreatment in wine environment, and the optimized method can accurately quantify 10⁴-10⁸ CFU/mL of the target strain (L. plantarum) in multiple matrices; (2) when the concentration of dead bacteria in the system is 10⁴ times higher than the concentration of live bacteria, there is an error of 0.5-1 lg CFU/mL in the detection results. The optimized sample pretreatment method in wine can effectively reduce the inhibitory components in the qPCR reaction system; (3) the optimized PMA-CELL-qPCR method was used to monitor the dynamic changes of L. plantarum during the fermentation of Cabernet Sauvignon wine, and the results were consistent with the plate counting method. In conclusion, the live bacteria quantification method developed in this study for PMA-CELL-qPCR in L. plantarum wines is accurate in quantification and simple in operation, and can be used as a means to accurately monitor microbial dynamics in wine and other fruit wines.

Malolactic Fermentation: New Approaches to Old Problems

Malolactic fermentation (MLF) is the decarboxylation of L-malic acid to L-lactic acid by lactic acid bacteria (LAB). For the majority of wine production, secondary fermentation is crucial. MLF significantly impacts the quality of most red and some white wine. The outcomes of the spontaneously initiated and finished MLF are frequently unpredictable and can even cause the wine to deteriorate. As a result, individuals typically favour inoculating superior starter cultures when performing MLF. The MLF method for wine has, however, faced new difficulties because of the altered wine fermentation substrate environment brought on by global climate change, the growing demands of winemakers for production efficiency, and the rising demand for high-quality wine. To serve as a reference for the study of wine production and MLF in the current situation, this review primarily updates and summarises the research findings on increasing the effectiveness and dependability of MLF in recent years.

Identification and Characterization of Malolactic Bacteria Isolated from the Eastern Foothills of Helan Mountain in China

Malolactic fermentation (MLF) converts malic acid into lactic acid by lactic acid bacteria (LAB). MLF may affect potential wine quality impact as global warming intensifies, and the alcohol in the wine increases, which threatens MLF. Lactiplantibacillus plantarum is considered a new generation of MLF starter because of the ability of high ethanol tolerance and good enological characteristics. In this research, 132 LAB strains were isolated from the eastern foothills of Helan Mountain in Ningxia, China. Twenty-one higher ethanol tolerance isolates were obtained by 15% (v/v) ethanol preliminary screening. They were identified by 16S rRNA sequencing and differentiated by randomly amplified polymorphic DNA (RAPD). Stress factors include ethanol, pH, and SO₂, and the combination of stresses was used to screen stress-tolerance strains. β-D-glucosidase activity, MLF performance, and biogenic amine content were tested to evaluate the enological characteristics. GC-MS detected the volatile components of the wine after MLF. The results showed that twenty strains were identified as L. plantarum, and one strain was Lentilactobacillus hilgardii. Especially, the strains of A7, A18, A23, A50, and B28 showed strong resistance to high ethanol, low pH, and high SO₂. A7, A50, and B28 showed better β-D-glucosidase activity and thus were inoculated into cabernet sauvignon wines whose ethanol content was 14.75% (v/v) to proceed MLF. A7 finished MLF in 36 d, while the control strains Oenococcus oeni 31-DH and L. plantarum BV-S2 finished MLF in 24 d and 28 d, respectively. Nevertheless, A50 and B28 did not finish MLF in 36 d. The data showed that A7 brought a more volatile aroma than control. Notably, the esters and terpenes in the wine increased. These results demonstrated the potential applicability of L. plantarum A7 as a new MLF starter culture, especially for high-ethanol wines.

Technological Improvements on FML in the Chianti Classico Wine Production: Co-Inoculation or Sequential Inoculation?

Winemaking variables and techniques are known to affect the composition of wines. To obtain a rapid and safe fermentation course, with a reduced risk of proliferation of unwanted microbial species, frequent recourse is made to the use of selected microorganisms, which can greatly simplify the complex management of the fermentation process. In particular, selected strains of lactic acid bacteria are used, which are much more sensitive than yeasts to the operating conditions of the medium. In this regard, the overall aim of this research was to verify whether the early inoculation of homolactic acid bacteria for hexoses (Lactobacillus plantarum) carried out after 24 h, compared with that of saccharomycetes operating alcoholic fermentation, could be advantageous compared with a traditional innoculation with a different heterolactic bacterial strain for hexoses (Oenococcus oeni) operated at the end of alcoholic fermentation. The grape variety chosen was Sangiovese, the protagonist of Tuscan oenology. The evaluation focused on different aspects such as the management of winery operations, and the quality and longevity of the product; was carried out in all phases of winemaking; and analysed both from a chemical and sensory point of view.

Molecular tools for the analysis of the microbiota involved in malolactic fermentation: from microbial diversity to selection of lactic acid bacteria of enological interest

Winemaking is a complex process involving two successive fermentations: alcoholic fermentation, by yeasts, and malolactic fermentation (MLF), by lactic acid bacteria (LAB). During MLF, LAB can contribute positively to wine flavor through decarboxylation of malic acid with acidity reduction and other numerous enzymatic reactions. However, some microorganisms can have a negative impact on the quality of the wine through processes such as biogenic amine production. For these reasons, monitoring the bacterial community profiles during MLF can predict and control the quality of the final product. In addition, the selection of LAB from a wine-producing area is necessary for the formulation of native malolactic starter cultures well adapted to local winemaking practices and able to enhance the regional wine typicality. In this sense, molecular biology techniques are fundamental tools to decipher the native microbiome involved in MLF and to select bacterial strains with potential to function as starter cultures, given their enological and technological characteristics. In this context, this work reviews the different molecular tools (both culture-dependent and -independent) that can be applied to the study of MLF, either in bacterial isolates or in the microbial community of wine, and of its dynamics during the process.

Use of Apple Pomace as Substrate for Production of Lactiplantibacillus plantarum Malolactic Starter Cultures

The by-products of the food industry are an economic alternative as a source of nutrients to obtain biomass. At the same time, theiruse could solve the environmental problem related to their disposal, which is highly polluting due to their elevated biochemical oxygen demand. In this work, we seek to optimize the production of cellular biomass of two native Patagonian strains of Lactiplantibacillus plantarum (UNQLp 11 and UNQLp155), selected for its oenological and technological properties, using apple pomace (AP), a residue from the juice and cider industry. The supplementation of AP with yeast extract, salts, and Tween 80 (sAP), proved to maintain the growth of the Lpb. plantarum strains, similar to the commercial medium used to grow LAB (De Man, Rogosa, Sharpe, MRS). Cultures grown in sAP medium showed good tolerance to wine conditions (high ethanol content and low pH), demonstrated by its ability to consume L-malic acid. The subsequent inoculation of these cultures in sterile wines (Merlot and Pinot noir) was carried out at laboratory scale, evaluating cell viability and L-malic acid consumption for 21 days at 21 °C. Cultures grown in sAP media showed a similar performance to MRS media. Thus, sAP media proved to be a suitable substrate to grow oenological Lpb. plantarum strains where cultures (with high size inoculums) were able to drive malolactic fermentation, with an L-malic acid consumption higher than 90%.

Wine aroma profile modification by Oenococcus oeni strains from Rioja Alavesa region: selection of potential malolactic starters

Previously six selected Oenococcus oeni strains (P2A, P3A, P3G, P5A, P5C and P7B) have been submitted to further characterization in order to clarify their potential as malolactic starters. Laboratory scale vinifications gave an insight of the most vigorous strains: both P2A and P3A strains were able to conclude malolactic fermentation (MLF) in less than 15 days. The remaining strains showed good viability and were able to successfully finish MLF in the established analysis time, except for the strain P5A, which viability was totally lost after inoculation. Also spontaneous fermentation was not initiated. None of the strains was biogenic amine producer; however, P5C strain significantly increased the concentration of volatile phenol-precursor hydroxycinnamic acids after MLF. Regarding the evolution of wine aromatic compounds, main changes were detected for both ethyl and acetate esters after MLF; however, key aromatic compounds including alcohols, terpenes or acids were also found to significantly increase. Principal component analysis classified the strains in two distinct groups, each one correlated with different key volatile compounds. P2A, P3A, P3G and P5C strains were mainly linked to esters, while P7B and the commercial strain Viniflora OENOS showed higher score for diverse compounds as hexanoic acid, β-damascenone, linalool or 2-phenylethanol. These results confirmed the specific impact of each strain on wine aroma profile, which could lead to the production of wines with individual characteristics, in which the reliability and safety of MLF is also ensured.

Oenococcus oeni Lifestyle Modulates Wine Volatilome and Malolactic Fermentation Outcome

In this study, nine Oenococcus oeni strains were tested for their ability to adhere to polystyrene using mMRS and wine as culture media. Moreover, planktonic and biofilm-detached cells were investigated for their influence on malic acid degradation kinetics and aroma compound production. Three strains were able to adhere on polystyrene plates in a strain-dependent way. In particular, MALOBACT-T1 and ISO359 strains mainly grew as planktonic cells, while the ISO360 strain was found prevalent in sessile state. The strain-dependent adhesion ability was confirmed by confocal laser scanning microscopy. Planktonic and biofilm detached cells showed a different metabolism. In fact, biofilm-detached cells had a better malic acid degradation kinetic and influenced the aroma composition of resulting wines, acting on the final concentration of esters, higher alcohols, and organic acids. Oenococcus oeni in biofilm lifestyle seems to be a suitable tool to improve malolactic fermentation outcome, and to contribute to wine aroma. The industrial-scale application of this strategy should be implemented to develop novel wine styles.

Influence of Climate on Soil and Wine Bacterial Diversity on a Vineyard in a Non-traditional Wine Region in Argentina

Argentina is the fifth world-wide wine producer, with an area of emerging importance in the Southwest of Buenos Aires Province, where climatic conditions are rather challenging. We studied the variations in soil and wine bacterial diversity through three consecutive vintages, and how climatic conditions affected said diversity. During the years of our study there were two harsh climatic events, a prolonged drought that extended over two vegetative periods, and an unseasonable spring frost in 2017. We found that the bacterial diversity reacted to these climatic events, given that there was a shift in the taxa exclusive to soil and wine, and shared by both, through time. Our results show a core of microorganisms in soil as well as in wine, belonging to different phyla that are conserved across the vintage years. A trend to an enrichment in Actinobacteria was detected in soil samples, whereas a high relative abundance of the Acetobacteraceae family and a scarcity of Lactic Acid Bacteria (LAB) were detected in the wine samples. We believe our results contribute to a better understanding of the impact of climatic conditions on the soil and wine microbiota, and can provide vintners with valuable knowledge for improving their wine production.

Optimization of Electrotransformation Parameters and Engineered Promoters for Lactobacillus plantarum from Wine

Robust and versatile promoters for Lactobacillus plantarum found in wine are necessary gene expression tools for genetic research involving wine stress. We optimized the electrotransformation parameters for L. plantarum XJ25 isolated from wine and engineered five promoters based on the promoter P₂₃; these promoters showed significantly different transcriptional activities under nonstress conditions. The activities of these promoters in vivo and the resulting growth burden to the host strain under different wine stresses were also evaluated. A range of colors (from white to dark pink) of the developing colonies with the plasmid pNZ8148 carrying an X-mCherry expression cassette, namely, P₂₃-mCherry, trcP₂₃-mCherry, P_OL1-mCherry, P_OL2-mCherry, P_OL3-mCherry, or P_OL4-mCherry, were analyzed. The applicability of the optimized electrotransformation parameters and synthetic promoters with different activities were also verified in several L. plantarum strains. Therefore, the optimized electrotransformation and these characterized promoters were determined to be suitable for applications in wine research in the future.

Whey permeate as a substrate for the production of freeze-dried Lactiplantibacillus plantarum to be used as a malolactic starter culture

The aim of this work was to obtain freeze-dried biomass of the native Patagonian Lactiplantibacillus plantarum strain UNQLp 11 from a whey permeate (WP)-based medium and compare it with the growth in commercial MRS broth medium. Survival and activity of the freeze-dried Lb. plantarum strain were investigated after inoculation in wine as a starter culture for malolactic fermentation (MLF). The effect of storage and rehydration condition of the dried bacteria and the nutrient supplementation of wine were also studied. The freeze-dried cultures from WP and those grown in MRS showed similar survival results. Rehydration in MRS broth for 24 h and the addition of a rehydration medium to wine as nutrient supplementation improved the survival under wine harsh conditions and guaranteed the success of MLF. Storage at 4 °C under vacuum was the best option, maintaining high cell viability for at least 56 days, with malic acid consumption higher than 90% after 7 days of inoculation in a wine-like medium. These results represent a significant advance for sustainable production of dried malolactic starter cultures in an environmentally friendly process, which is low cost and easy to apply in winemaking under harsh physicochemical conditions.

Polymicrobial interaction between Lactobacillus and Saccharomyces cerevisiae: coexistence-relevant mechanisms

The coordination of single or multiple microorganisms are required for the manufacture of traditional fermented foods, improving the flavour and nutrition of the food materials. However, both the additional economic benefits and safety concerns have been raised by microbiotas in fermented products. Among the fermented products, Lactobacillus and Saccharomyces cerevisiae are one of the stable microbiotas, suggesting their interaction is mediated by coexistence-relevant mechanisms and prevent to be excluded by other microbial species. Thus, aiming to guide the manufacture of fermented foods, this review will focus on interactions of coexistence-relevant mechanisms between Lactobacillus and S. cerevisiae, including metabolites communications, aggregation, and polymicrobial biofilm. Also, the molecular regulatory network of the coexistence-relevant mechanisms is discussed according to omics researches.

Biodiversity of Oenological Lactic Acid Bacteria: Species- and Strain-Dependent Plus/Minus Effects on Wine Quality and Safety

Winemaking depends on several elaborate biochemical processes that see as protagonist either yeasts or lactic acid bacteria (LAB) of oenological interest. In particular, LAB have a fundamental role in determining the quality chemical and aromatic properties of wine. They are essential not only for malic acid conversion, but also for producing several desired by-products due to their important enzymatic activities that can release volatile aromatic compounds during malolactic fermentation (e.g., esters, carbonyl compounds, thiols, monoterpenes). In addition, LAB in oenology can act as bioprotectors and reduce the content of undesired compounds. On the other hand, LAB can affect wine consumers’ health, as they can produce harmful compounds such as biogenic amines and ethyl carbamate under certain conditions during fermentation. Several of these positive and negative properties are species- and strain-dependent characteristics. This review focuses on these aspects, summarising the current state of knowledge on LAB’s oenological diversity, and highlighting their influence on the final product’s quality and safety. All our reported information is of high interest in searching new candidate strains to design starter cultures, microbial resources for traditional/typical products, and green solutions in winemaking. Due to the continuous interest in LAB as oenological bioresources, we also underline the importance of inoculation timing. The considerable variability among LAB species/strains associated with spontaneous consortia and the continuous advances in the characterisation of new species/strains of interest for applications in the wine sector suggest that the exploitation of biodiversity belonging to this heterogeneous group of bacteria is still rising.

β-Glucosidase Activity of Lactiplantibacillus plantarum UNQLp 11 in Different Malolactic Fermentations Conditions: Effect of pH and Ethanol Content

Lactiplantibacillus plantarum strain UNQLp 11 is a lactic acid bacterium with the potential to carry out malolactic fermentation (MLF) in red wines. Recently, the complete genome of UNQLp 11 was sequenced and this strain possesses four loci of the enzyme β-glucosidase. In order to demonstrate that these glucosidase enzymes could be functional under harsh wine conditions, we evaluated the hydrolysis of p-nitrophenyl-β-D-glucopyranoside (p-NPG) in synthetic wine with different ethanol contents (0%, 12%, and 14% v/v) and at different pH values (3.2, 3.5, and 3.8). Then, the hydrolysis of precursor n-octyl β-D-glucopyranoside was analyzed in sterile Pinot Noir wine (containing 14.5% v/v of ethanol, at different pH values) by headspace sorptive extraction gas chromatography-mass spectrometry (HSSE-GC/MS). The hydrolysis of p-NPG showed that β-glucosidase activity is very susceptible to low pH but induced in the presence of high ethanol content. Furthermore, UNQLp 11 was able to release the glycosilated precursor n-octyl, during MLF to a greater extent than a commercial enzyme. In conclusion, UNQLp 11 could improve the aromatic profile of the wine by the release of volatile precursors during MLF.

Influence of sea buckthorn juice addition on the growth of microbial food cultures

The aim of the article was to investigate the effect of sea buckthorn juice addition on the growth of microbial cultures in growth medium and juice mixtures. Pure sea buckthorn juice was found to inhibit the growth of all 11 monitored microbial cultures. Lactobacillus plantarum CCM 7039, Lactobacillus plantarum K816, Lactobacillus brevis CCM 1815 and, to a lesser extent, the probiotic strain Lactobacillus rhamnosus GG, grew in a growth medium containing a 25 % addition of sea buckthorn juice. Lactobacillus plantarum K816 and Lactobacillus brevis CCM 1815 grew better in this mixture than in pure growth medium. Moreover, we focused on finding a suitable ratio of sea buckthorn and apple juice for Lactobacillus plantarum CCM 7039, leading to malolactic fermentation, which results in an increase in the pH value and an improvement in the sensory properties of juices. The intention was to incorporate the highest possible addition of sea buckthorn juice while maintaining the viability of Lactobacillus plantarum CCM 7039 for malolactic fermentation to occur. The best results were achieved using 40 % sea buckthorn juice. Practical application of the results points to the possibility of preparing a fermented fruit beverage and a dairy product containing sea buckthorn juice. The results of this work extend the current options of sea buckthorn juice processing increasing thus the consumption of healthy juice.

Secondary Aroma: Influence of Wine Microorganisms in Their Aroma Profile

Aroma profile is one of the main features for the acceptance of wine. Yeasts and bacteria are the responsible organisms to carry out both, alcoholic and malolactic fermentation. Alcoholic fermentation is in turn, responsible for transforming grape juice into wine and providing secondary aromas. Secondary aroma can be influenced by different factors; however, the influence of the microorganisms is one of the main agents affecting final wine aroma profile. Saccharomyces cerevisiae has historically been the most used yeast for winemaking process for its specific characteristics: high fermentative metabolism and kinetics, low acetic acid production, resistance to high levels of sugar, ethanol, sulfur dioxide and also, the production of pleasant aromatic compounds. Nevertheless, in the last years, the use of non-saccharomyces yeasts has been progressively growing according to their capacity to enhance aroma complexity and interact with S. cerevisiae, especially in mixed cultures. Hence, this review article is aimed at associating the main secondary aroma compounds present in wine with the microorganisms involved in the spontaneous and guided fermentations, as well as an approach to the strain variability of species, the genetic modifications that can occur and their relevance to wine aroma construction.

Spontaneous fermentation in wine production as a controllable technology

This study focuses on the isolation of a consortium of microorganisms from spontaneously fermenting must that naturally contain lactic acid bacteria, non-saccharomyces yeasts, and saccharomyces yeasts. To collect the greatest diversity of microorganisms, the consortium was taken from the point of micro-sparkling. Based on the growth curves, isolation was performed using individual special nutrient media, and the isolates were subsequently multiplied in the nutrient medium. Individual isolates were then used for fermentation tests to monitor the percentage of fermented sugar and hydrogen sulphide production. The highest fermentation abilities were achieved in the isolates containing Saccharomyces cerevisiae and Zygosaccharomyces bailii. The smallest amount of ethanol was formed from the isolates containing Hanseniaspora uvarum, while Candida sake isolate produced the lowest amount of hydrogen sulphide and Zygosaccharomyces bailii produced the highest. The other isolates produced an average amount. Based on these results, a consortium containing the given isolates in a certain ratio was compiled.

Effect of Biofilm Formation by Lactobacillus plantarum on the Malolactic Fermentation in Model Wine

Biofilm life-style of Lactobacillus plantarum (L. plantarum) strains was evaluated in vitro as a new and suitable biotechnological strategy to assure L-malic acid conversion in wine stress conditions. Sixty-eight L. plantarum strains isolated from diverse sources were assessed for their ability to form biofilm in acid (pH 3.5 or 3.2) or in ethanol (12% or 14%) stress conditions. The effect of incubation times (24 and 72 h) on the biofilm formation was evaluated. The study highlighted that, regardless of isolation source and stress conditions, the ability to form biofilm was strain-dependent. Specifically, two clusters, formed by high and low biofilm producer strains, were identified. Among high producer strains, L. plantarum Lpls22 was chosen as the highest producer strain and cultivated in planktonic form or in biofilm using oak supports. Model wines at 12% of ethanol and pH 3.5 or 3.2 were used to assess planktonic and biofilm cells survival and to evaluate the effect of biofilm on L-malic acid conversion. For cells in planktonic form, a strong survival decay was detected. In contrast, cells in biofilm life-style showed high resistance, assuring a prompt and complete L-malic acid conversion.

Effect of Co-Inoculation of Candida zemplinina, Saccharomyces cerevisiae and Lactobacillus plantarum for the Industrial Production of Negroamaro Wine in Apulia (Southern Italy)

The employment of multi-species starter cultures has growing importance in modern winemaking for improving the complexity and wine attributes. The assessment of compatibility for selected species/strains at the industrial-scale is crucial to assure the quality and the safety associated with fermentations. An aspect particularly relevant when the species belong to non-Saccharomyces, Saccharomyces spp. and malolactic bacteria, three categories with different biological characteristics and oenological significance. To the best of our knowledge, the present report is the first study regarding the utilization of a combined starter culture composed of three strains of non-Saccharomyces, Saccharomyces cerevisiae and Lactobacillus plantarum for production of wine at the industrial scale. More in-depth, this work investigated the oenological potential of the autochthonous characterized strains from the Apulian region (Southern Italy), Candida zemplinina (syn. Starmerella bacillaris) 35NC1, S. cerevisiae (NP103), and L. plantarum (LP44), in co-inoculation following a complete scale-up scheme. Microbial dynamics, fermentative profiles and production of volatile secondary compounds were assessed in lab-scale micro-vinification tests and then the performances of the mixed starter formulation were further evaluated by pilot-scale wine production. The above results were finally validated by performing an industrial-scale vinification on 100HL of Negroamaro cultivar grape must. The multi-starter formulation was able to rule the different stages of the fermentation processes effectively, and the different microbial combinations enhanced the organoleptic wine features to different extents. The findings indicated that the simultaneous inoculation of the three species affect the quality and quantity of several volatile compounds, confirming that the complexity of the wine can reflect the complexity of the starter cultures. Moreover, the results underlined that the same mixed culture could differently influence wine quality when tested at the lab-, pilot- and industrial-scale. Finally, we highlighted the significance of employment non-Saccharomyces and L. plantarum, together with S. cerevisiae, autochthonous strains in the design of custom-made starter culture formulation for typical regional wine production with pronounced unique quality.

Modifications of Phenolic Compounds, Biogenic Amines, and Volatile Compounds in Cabernet Gernishct Wine through Malolactic Fermentation by Lactobacillus plantarum and Oenococcus oeni

Malolactic fermentation is a vital red wine-making process to enhance the sensory quality. The objective of this study is to elucidate the starter cultures’ role in modifying phenolic compounds, biogenic amines, and volatile compounds after red wine malolactic fermentation. We initiated the malolactic fermentation in Cabernet Gernishct wine by using two Oenococcus oeni and two Lactobacillus plantarum strains. Results showed that after malolactic fermentation, wines experienced a content decrease of total flavanols and total flavonols, accompanied by the accumulation of phenolic acids. The Lactobacillus plantarum strains, compared to Oenococcus oeni, exhibited a prevention against the accumulation of biogenic amines. The malolactic fermentation increased the total esters and modified the aromatic features compared to the unfermented wine. The Lactobacillus plantarum strains retained more aromas than the Oenococcus oeni strains did. Principal component analysis revealed that different strains could distinctly alter the wine characteristics being investigated in this study. These indicated that Lactobacillus plantarum could serve as a better alternative starter for conducting red wine malolactic fermentation.

Sequential inoculum of Hanseniaspora guilliermondii and Saccharomyces cerevisiae for winemaking Campanino on an industrial scale

In this study, the effect of sequential inoculation with non-Saccharomyces (Hanseniaspora guilliermondii) and Saccharomyces cerevisiae yeast on the distinctive characteristics of the Campanino white wine was investigated. For this purpose, three independent winemaking experiments were carried out on an industrial scale (batches A, B and C). In detail, the first one was carried out using the sequential inoculation technique while the other two, using a S. cerevisiae single-strain starter or no inoculation representing the control batches. Microbiological and chemical parameters and sensorial profiles of the wines were defined. Interestingly, the results showed that when sequential cultures (H. guilliermondii in a sequential mixture with S. cerevisiae) were used, a better wine aroma and quality was observed. More specifically, the wine obtained by sequential inoculation showed lower acetic acid values and enhanced volatile profiles than the wine from the control batches. Finally, sensorial analysis confirmed that the sequential cultures led to an improvement in wine flavour. Therefore, results suggest that the sequential inoculation using non-Saccharomyces and Saccharomyces yeast represents a biotechnological practice that can improve the quality features of traditional white wine. It has been shown for the first time that on an industrial scale H. guilliermondii could be used in sequential inoculum with S. cerevisiae in making white Campanino wine.

Advantages of Using Blend Cultures of Native L. plantarum and O. oeni Strains to Induce Malolactic Fermentation of Patagonian Malbec Wine

The malolactic fermentation (MLF) of Patagonian Malbec wine inoculated with blend cultures of selected native strains of Lactobacillus plantarum and Oenococcus oeni was monitored during 14 days, analyzing the strains ability to modify the content of some organic acids and to change the volatile compounds profile. The performance of the LAB strains was tested as single and blends cultures of both species. An implantation control by RAPD PCR was also carried out to differentiate among indigenous and inoculated strains. The L. plantarum strains UNQLp11 and UNQLp155 and the O. oeni strain UNQOe73.2 were able to remain viable during the monitoring time of MLF, whereas the O. oeni strain UNQOe31b showed a decrease of five log CFU at day 14. The four strains assayed showed a similar behavior in wine whether they were inoculated individually or as blend cultures. All strains were able to consume L-malic acid, particularly the L. plantarum strains, which showed the highest consumption values at day 14, both as single or blend cultures. The changes in the volatile compounds profile of Malbec wine samples, before and after MLF, were determined by HS-SPME and GC-MS technique. Wines inoculated with blend cultures containing strain UNQLp155 showed a decrease in the total alcohols content and an increase in the total esters content. On the other hand, wines inoculated with single cultures of strains UNQLp155, UNQOe31b or UNQOe73.2 showed no significant decrease in the total alcohols concentration but a significant increase in the total esters content. When strain UNQLp11 was inoculated as single or as blend culture with strain UNQOe31b, wines exhibited an increase in the total alcohols content, and a decrease in the total esters content. The content of diethyl succinate showed the greatest increase at final of MLF, and a particular synergistic effect in its synthesis was observed with a blend culture of strains UNQLp155 and UNQOe73.2. These results suggest that the use of blend cultures formulated with strains belonging to L. plantarum and O. oeni species could offer an interesting advantage to induce MLF in Malbec wines, contributing to diversify their aromatic profiles.

Lactobacillus plantarum with Functional Properties: An Approach to Increase Safety and Shelf-Life of Fermented Foods

Lactobacillus plantarum (widespread member of the genus Lactobacillus) is one of the most studied species extensively used in food industry as probiotic microorganism and/or microbial starter. The exploitation of Lb. plantarum strains with their long history in food fermentation forms an emerging field and design of added-value foods. Lb. plantarum strains were also used to produce new functional (traditional/novel) foods and beverages with improved nutritional and technological features. Lb. plantarum strains were identified from many traditional foods and characterized for their systematics and molecular taxonomy, enzyme systems (α-amylase, esterase, lipase, α-glucosidase, β-glucosidase, enolase, phosphoketolase, lactase dehydrogenase, etc.), and bioactive compounds (bacteriocin, dipeptides, and other preservative compounds). This review emphasizes that the Lb. plantarum strains with their probiotic properties can have great effects against harmful microflora (foodborne pathogens) to increase safety and shelf-life of fermented foods.

Changes in the volatile profile of Pinot noir wines caused by Patagonian Lactobacillus plantarum and Oenococcus oeni strains

The ability of Patagonian L. plantarum and O. oeni strains to change the volatile profile of a sterile Pinot noir wine was studied through fermentation assays, at laboratory scale. Two strains of each LAB species were selected based on data regarding to their ability to survive in wine and to consume l-malic acid. Both O. oeni strains but only one L. plantarum (UNQLp 11) strain were able to remain viable, consuming l-malic acid through the fermentation assay with a concomitant increase of l-lactic acid. The volatile profile of Pinot noir wine, before and after LAB inoculation, was measured by using HS-SPME gas chromatography technique. This analysis showed that alcohols were the main volatile compounds after alcoholic fermentation and that after fermentation with the selected LAB strains, a decrease in the volatile alcohols concentration and an increase in the volatile esters concentration could be observed. The O. oeni UNQOe 73.2 strain produced the most notable change in the volatile profile, with the production of some important odorant esters at higher concentration, compared to O. oeni UNQOe 31b strain. Although, L. plantarum UNQLp 11 strain showed a better performance in the consumption of l-malic acid, this strain had a low capacity to modify the volatile compounds profile after incubation in red wine. The results found in the present work showed that different strains selected as potential malolactic starters could have different behavior when are incubated in real wine. Although L. plantarum UNQLp 11 strain showed a good consumption of l-malic acid, the O. oeni UNQOe 73.2 strain exhibited superior capacity to improve the flavor of wine due to its esterase activity that produce an increase of fruity and creamy odorants.

Starter cultures as biocontrol strategy to prevent Brettanomyces bruxellensis proliferation in wine

Brettanomyces bruxellensis is a common and significant wine spoilage microorganism. B. bruxellensis strains generally detain the molecular basis to produce compounds that are detrimental for the organoleptic quality of the wine, including some classes of volatile phenols that derive from the sequential bioconversion of specific hydroxycinnamic acids such as ferulate and p-coumarate. Although B. bruxellensis can be detected at any stage of the winemaking process, it is typically isolated at the end of the alcoholic fermentation (AF), before the staring of the spontaneous malolactic fermentation (MLF) or during barrel aging. For this reason, the endemic diffusion of B. bruxellensis leads to consistent economic losses in the wine industry. Considering the interest in reducing sulfur dioxide use during winemaking, in recent years, biological alternatives, such as the use of tailored selected yeast and bacterial strains inoculated to promote AF and MLF, are actively sought as biocontrol agents to avoid the “Bretta” character in wines. Here, we review the importance of dedicated characterization and selection of starter cultures for AF and MLF in wine, in order to reduce or prevent both growth of B. bruxellensis and its production of volatile phenols in the matrix.

Sub-optimal pH Preadaptation Improves the Survival of Lactobacillus plantarum Strains and the Malic Acid Consumption in Wine-Like Medium

Forty-two oenological strains of Lb. plantarum were assessed for their response to ethanol and pH values generally encountered in wines. Strains showed a higher variability in the survival when exposed to low pH (3.5 or 3.0) than when exposed to ethanol (10 or 14%). The study allowed to individuate the highest ethanol concentration (8%) and the lowest pH value (4.0) for the growth of strains, even if the maximum specific growth rate (μ_max) resulted significantly reduced by these conditions. Two strains (GT1 and LT11) preadapted to 2% ethanol and cultured up to 14% of ethanol showed a higher growth than those non-preadapted when they were cultivated at 8% of ethanol. The evaluation of the same strains preadapted to low pH values (5.0 and 4.0) and then grown at pH 3.5 or 3.0 showed only for GT1 a sensitive μ_max increment when it was cultivated in MRS at pH 3 after a preadaptation to pH 5.0. The survival of GT1 and LT11 was evaluated in Ringer's solution at 14% ethanol after a long-term adaptation in MRS with 2% ethanol or in MRS with 2% ethanol acidified at pH 5.0 (both conditions, BC). Analogously, the survival was evaluated at pH 3.5 after a long-term adaptation in MRS at pH 5.0 or in MRS BC. The impact of the physiologic state (exponential phase vs stationary phase) on the survival was also evaluated. Preadapted cells showed the same behavior of non-preadapted cells only when cultures were recovered in the stationary phase. Mathematical functions were individuated for the description of the survival of GT1 and LT11 in MRS at 14% ethanol or at pH 3.5. Finally, a synthetic wine (SW) was used to assess the behavior of Lb. plantarum GT1 and LT11 preadapted in MRS at 2% ethanol or at pH 5.0 or in BC. Only GT1 preadapted to pH 5.0 and collected in the stationary phase showed constant values of microbial counts after incubation for 15 days at 20°C. In addition, after 15 days the L-malic acid resulted completely degraded and the pH value increased of about 0.3 units.