Effect of ethanol on the microstructure and rheological properties of whey proteins: Acid-induced cold gelation

Formation mechanism and stability of egg white fluid gels under ultrahigh-pressure homogenization pretreatment and synergistic heating effect

The thermal sterilization process of protein beverages inevitably leads to the formation of insoluble thermal aggregates, greatly reducing the texture and taste of protein beverages. In this study, homogenized egg white (HEW) was obtained by ultrahigh-high-pressure (UHP) homogenization pretreatment of egg white (EW), and then a special egg white fluid gel (EWFG) was prepared by water bath heating. The results showed that the optimal conditions for preparing EWFG were three cycles at 20 MPa homogenizing pressure and heating in a water bath at 72℃ for 10 min. Under these conditions, the EWFG was a milky-white homogeneous liquid with an average particle size of about 560 nm. Measurements of the physicochemical properties of HEW and EWFG showed that the UHP homogenization treatment reduced the viscosity of HEW, decreased the particle size of protein aggregates, and increased the zeta potential, which altered the interactions of proteins during the subsequent heating process and facilitated the formation of homogeneous and dispersed EWFG. EWFG showed good stability at pH 6-10 and in low-concentration saline and medium-concentration sucrose solutions. The EWFG obtained by the present treatment is more suitable for factory-scale production and has great potential for protein beverage applications.

Structural and aggregation changes of silver carp myosin induced with alcohols: Effects of ethanol, 1,2-propanediol, and glycerol

This study investigated the effects of ethanol, 1,2-propanediol, and glycerol on the structure and aggregation behavior of silver carp (Hypophthalmichthys molitrix) myosin. All alcohols induced extensive alteration in the tertiary structure of myosin. Both ethanol and 1,2-propanediol further promoted an increase in the content of β-sheets in myosin and induced myosin aggregation. While glycerol had almost no impact on the secondary structure of myosin. Molecular dynamics simulations revealed that increasing the concentration of ethanol and 1,2-propanediol affected the overall structural changes in the myosin heavy chain (MHC), while glycerol exerted a more pronounced effect on the MHC tail when compared to the MHC head. Disruption of the hydration layers induced by ethanol and 1,2-propanediol contributed to local structural changes in myosin. Glycerol at a concentration of 20% induced the formation of a larger hydration layer around the MHC tail, which facilitated the stabilization of the protein structure.

Modulating the texture of heat-set gels of phosphorylated walnut protein isolates through Glucono-δ-lactone acidification

The gelation of walnut protein isolates has not been extensively studied, mainly due to their inherent poor dispersity. This study investigated the gelation of alkaline-extracted walnut protein isolates (AWPI) and phosphorylated walnut protein isolates (PWPI) induced by heat treatment with glucono-δ-lactone (GDL) acidification, focusing on the impact of GDL concentrations on microstructure, rheology, and texture of the resulting gels. The PWPI gel exhibited lower hardness but a smoother structure than the AWPI gel. Notably, acidification with GDL (0.6-1.2%) significantly increased the stiffness of PWPI gels, increasing storage modulus and yield stress 10-50 times, while weakening AWPI gels. Varying concentrations of GDL effectively modulated the microstructure of the PWPI gels, leading to the altered texture (from a soft-solid state to a well-self-supporting stiff-solid gel) and water holding capacity (from approximately 46% to 85%). Additionally, hydrophobic interactions and disulfide bonds were identified as the primary forces involved in the gels.

The Characteristics of Whey Protein and Blueberry Juice Mixed Fermentation Gels Formed by Lactic Acid Bacteria

The properties of blueberry juice and whey protein gels formed by the mixed fermentation of L. plantarum 67 and L. paracasei W125 were investigated. The state of the gels, including the colour and surface morphology of the microspheres, showed significant changes with different fermentation times. The polyphenolic, flavonoid, and protein release of whey protein or combined blueberry juice fermented gels under in vitro digestion were investigated. The whey protein and blueberry juice fermented gels had more small pores, with a honeycomb structure, compared to whey protein fermented gels. The hardness of the gels was increased after fermentation for 7 h for the whey protein gels and whey protein mixture blueberry juice gels. The storage modulus and water-holding capacity of the gels were increased between fermentation times of 6 h and 8 h. The swelling rates of the whey protein gels fermented for 7 h and whey protein mixed blueberry juice gels fermented for 8 h and kept in pepsin-free simulated gastric fluid for 1 h had higher values. The release of polyphenols, flavonoids, and protein for the fermented gels was higher at fermentation of 7 h in the in vitro digestion experiment. We found that the chewiness of the whey protein gels, or whey protein mixed fermentation gels, was higher at a fermentation time of 7.5 h and 8 h. However, the cohesiveness values were not significantly different. Therefore, whey protein fermented gels and whey protein mixed blueberry juice fermented gels should be fermented for more than 7 h. This facilitates the release of polyphenols, flavonoids, and protein in the gastric juices.

Designation and characterization of cold-set egg white protein/dextran sulfate hydrogel for curcumin entrapment

This study aimed to design a cold-set hydrogel of egg white protein (EWP) with good mechanical properties for encapsulating curcumin. Dextran sulfate (DS) and transglutaminase (TGase) were used to control the aggregation and gelation behavior of EWP at preheating step and gelation step, respectively. The optimum soluble protein aggregate size was obtained in the EWP/DS mixture at a mass ratio of 10 under 85 °C preheated (HED₁₀). The presence of TGase further enhanced the cross-linking degree between protein aggregates during the gelation step. The highest gel hardness was found in HED₁₀ hydrogel with TGase, which is almost 10 times the pure EWP gel. Besides, the HED hydrogels effectively slowed down the release rate of curcumin in gastrointestinal digestion. This work provides a theoretical basis for the development of cold-set EWP hydrogel with good mechanical strength by sulfated polysaccharide addition and TGase cross-linking as encapsulation delivery systems.

Macro- and Nanoscale Effect of Ethanol on Bovine Serum Albumin Gelation and Naproxen Release

We report extended ethanol-induced gelation procedures of bovine serum albumin (BSA) at 37 °C and investigate the release behavior of a spin-labeled naproxen derivative (SL-NPX) from these hydrogels. The macroscopic mechanical properties of these gels during formation were studied using rheology, while a nanoscopic, more molecular view was obtained by analyzing the secondary structure of the protein during gelation via infrared (ATR-IR) spectroscopy. To evaluate the potential use of BSA hydrogels in controlled drug delivery, SL-NPX-BSA interaction was investigated in detail by continuous-wave electron paramagnetic resonance (CW EPR) spectroscopy, which provides information on the interaction of the small drug molecules and the hydrogel. In addition to CW EPR spectroscopy, dynamic light scattering (DLS), which provides insight into the size and nature of released components, was applied to characterize the combined influence of incubation time, ethanol, SL-drug, and BSA concentration on release behavior. It was found that the alteration of initial drug loading percentage, hydrogel incubation time as well as BSA and alcohol concentrations affect and thus tune the release rate of SL-NPX from BSA hydrogels. These results lead to the conclusion that BSA hydrogels as controlled release systems offer a remarkable fine-tuning capability for pharmaceutical applications due to the variety of gelation parameters.

Reversibility of the gel, rheological, and structural properties of alcohol pretreated fish gelatin: Effect of alcohol types

The reversibility of gel property of alcohol (methanol, ethanol)-pretreated fish gelatin (FG) were investigated through removing alcohol solutions by freeze drying. Results showed that the gel strength and the hardness of FG could be retained (1%, 40%) or even improved (1% methanol) using low or high concentration alcohol solutions, while decreased in medium concentration alcohol solutions. Compared with untreated FG, rheology results showed that, all alcohol solutions pretreated FG had lower apparent viscosity, while higher alcohol solutions pretreated ones decreased the gel and melt points and shorten the gelation time. Sodium dodecyl-sulfate polyacrylamide gel electrophoresis showed that methanol pretreated FG had the higher α contents than those of ethanol pretreated. Circular dichroism spectra results indicated that β-sheet could be decreased after removing ethanol solutions, whereas the β-sheet increased after removing the methanol solutions. Moreover, low field nuclear magnetic resonance relaxation test showed that pretreated FG had lower transverse relaxation times of internal water (T₂₁ and T₂₂ ) compared to that of the untreated FG. Overall, FG still retains higher gel properties after removing the low or high alcohol concentrations.

Physicochemical properties of human breast milk during the second year of lactation

The present study examined the microstructure as well as the physicochemical properties of human milk during the second year of lactation in an attempt to explore its applicability for the formulation of food products. It was observed that human milk fat globules (MFG) droplet size increased within 3 days of milk extraction due to coalescence, as evidenced by confocal microscopy. Furthermore, a gradual decrease of the average MFG size was noted from the sixteenth (16th) to twenty-fifth (25th) month of lactation. It was also found that the size of casein micellar structures increased upon acidification to pH 4.3 (isoelectric point of human caseins). In addition, human milk proteins enhanced the stability of oil-in-water emulsions against coalescence compared to cow, sheep, and goat milk proteins employed as macromolecular emulsifying ingredients. The cold-acid-gels of human milk proteins showed a less elastic behavior than the other milk samples, possibly due to the different structure, composition and size of human casein micelles. Furthermore, the DSC thermograms showed that human whey proteins are denatured in the same temperature range as do the cow whey proteins, but exhibit different thermal transition profiles. Overall, the findings of this research confirm that both the structure and the physicochemical properties of human milk are affected by the stage of lactation. Moreover, the particular composition and structure of human milk proteins seem to be responsible for the special functional characteristics of human milk that may lead towards the formulation of innovative products.

Removal of phenolic compounds from de-oiled sunflower kernels by aqueous ethanol washing

Selective removal of phenolic compounds (PCs) from de-oiled sunflower kernel is generally considered a key step for food applications, but this often leads to protein loss. PC removal yield and protein loss were assessed during an aqueous or aqueous ethanol washing process with different temperatures, pH-values and ethanol contents. PC yield and protein loss increased when the ethanol content was < 60% or when a higher temperature was applied. Our main finding is that preventing protein loss should be the key objective when selecting process conditions. This can be achieved using solvents with high ethanol content. Simulation of the multi-step exhaustive process showed that process optimization is possible with additional washing steps. PC yield of 95% can be achieved with only 1% protein loss using 9 steps and 80% ethanol content at 25℃. The functional properties of the resulting concentrates were hardly altered with the use of high ethanol solvents.