1
|
Darwesh OM, Matter IA, Abdel-Maksoud MA, Al-Qahtani WH, El-Tayeb MA, Kodous AS, Aufy M. Development of nanocomposite-selenium filter for water disinfection and bioremediation of wastewater from Hg and AgNPs. Sci Rep 2024; 14:21443. [PMID: 39271750 PMCID: PMC11399127 DOI: 10.1038/s41598-024-70120-3] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 04/23/2024] [Accepted: 08/13/2024] [Indexed: 09/15/2024] Open
Abstract
Selenium nanoparticles (SeNPs) are used in several sectors as antitumor, antimicrobial, and environmental adsorbents. Thus, the present research objective was the production of bacterial-SeNPs as an active and environmentally-friendly antibacterial and adsorbent agents and application into novel nanocomposite filter. From a total of 25 samples (soil, wastewater, and water) obtained from different locations in Egypt, 60 selenium-resistant bacterial isolates were obtained (on a mineral salt medium supplemented with selenium ions). After screening (based on the conversion of selenium from ionic form to nanoform), a superior bacterial isolate for SeNPs formation was obtained and molecular identified as Bacillus pumilus isolate OR431753. The high yield of SeNPs was noted after optimization (glucose as carbon source, pH 9 at 30 °C). The produced SeNPs were characterized as approximately 15 nm-diameter spherical nanoparticles, in addition to the presence of organic substances around these particles like polysaccharides and aromatic amines (protein residues). Also, they have antibacterial activity increased after formation of nanocomposite with nano-chitosan (SeNPs/NCh) against several pathogens. The antibacterial activity (expressed as a diameter of the inhibitory zone) averaged between 2.1 and 4.3, 2.7 and 4.8 cm for SeNPs and SeNPs/NCh, respectively compared with 1.1 to 1.8 cm for Amoxicillin. The produced nanoselenium/chitosan was used as a biofilter to remove mercury (Hg) and AgNPs as model chemicals with serious toxicity and potential pollutant for water bodies in many industries. The new SeNPs/NCh biofilter has proven highly effective in individually removing mercury and AgNPs from their synthetic wastewaters, with an efficiency of up to 99%. Moreover, the removal efficiency of AgNPs stabilized at 99% after treating them with the syringe filter-Se nanocomposite for 4 cycles of treatment (5 min each).
Collapse
Affiliation(s)
- Osama M Darwesh
- Agricultural Microbiology Department, National Research Centre, 33 El-Buhouth St., Dokki, Cairo, 12622, Egypt.
| | - Ibrahim A Matter
- Agricultural Microbiology Department, National Research Centre, 33 El-Buhouth St., Dokki, Cairo, 12622, Egypt
| | - Mostafa A Abdel-Maksoud
- Botany and Microbiology Department, College of Science, King Saud University, Riyadh, Saudi Arabia
| | - Wahidah H Al-Qahtani
- Department of Food Sciences and Nutrition, College of Food and Agricultural Sciences, King Saud University, P.O. Box 270677, 11352, Riyadh, Saudi Arabia
| | - Mohamed A El-Tayeb
- Botany and Microbiology Department, College of Science, King Saud University, Riyadh, Saudi Arabia
| | - Ahmad S Kodous
- Department of Molecular Oncology, Cancer Institute (WIA), 38, Sardar Patel Road, P.O. Box 600036, Chennai, Tamilnadu, India
| | - Mohammed Aufy
- Department of Pharmaceutical Sciences, Division of Pharmacology and Toxicology, University of Vienna, Vienna, Austria
| |
Collapse
|
2
|
Vanin AP, Visentin EZ, Fontana RC, di Medeiros Leal MCB, de Avila E Silva S, Stokke BT, Carbonero ER, Camassola M. β-(1 → 3)(1 → 6)glucan from Schizophyllum commune 227E.32: High yield production via glucose/xylose co-metabolization. Carbohydr Polym 2023; 320:121176. [PMID: 37659785 DOI: 10.1016/j.carbpol.2023.121176] [Citation(s) in RCA: 1] [Impact Index Per Article: 0.5] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 05/02/2023] [Revised: 06/15/2023] [Accepted: 07/04/2023] [Indexed: 09/04/2023]
Abstract
A co-metabolization of xylose and glucose by Schizophyllum commune 227E.32 wild mushroom for exopolysaccharide (EPS) production is presented. Cultivations performed with S. commune 227E.32 at different xylose concentrations demonstrated that the concentration of 50 g·L-1 of xylose achieved the highest EPS production, around 4.46 g·L-1. Scale-up in a stirred tank reactor (STR) was performed. 10 % inoculum showed the highest cost/benefit ratio regarding sugar conversion and EPS production (Y P/S = 0.90 g·g-1), achieving 1.82 g·L-1 of EPS. Isolation, purification, and characterization were conducted with EPS produced in flasks and STR. GC-MS analysis showed glucose as main monosaccharide constituents for both isolates. 13C NMR and HSQC-edited showed that both EPS isolated consisted of a β-D-Glcp (1 → 3) main chain, partially substituted at O-6 with nonreducing β-D-Glcp ends on every third residue, similar to β-D-glucan isolated from S. commune basidiomes known as schizophyllan (SPG). The Mw was determined by GPC to 1.5 × 106 Da (flasks) and 1.1 × 106 Da (STR). AFM topographs revealed a semi-flexible appearance of the β-D-glucan, consistent with the triple helical structures adopted by SPG and overall contour length consistent with a high molar mass.
Collapse
Affiliation(s)
- Ana Paula Vanin
- Enzymes and Biomass Laboratory, Institute of Biotechnology, University of Caxias do Sul, Caxias do Sul, RS, Brazil.
| | - Esther Ziliotto Visentin
- Enzymes and Biomass Laboratory, Institute of Biotechnology, University of Caxias do Sul, Caxias do Sul, RS, Brazil
| | - Roselei Claudete Fontana
- Enzymes and Biomass Laboratory, Institute of Biotechnology, University of Caxias do Sul, Caxias do Sul, RS, Brazil
| | | | - Scheila de Avila E Silva
- Computational Biology and Bioinformatics Laboratory, Bioinformatics Research Center, Institute of Biotechnology, University of Caxias do Sul, Caxias do Sul, RS, Brazil
| | - Bjørn Torger Stokke
- Biophysics and Medical Technology, Department of Physics, NTNU Norwegian University of Science and Technology, Trondheim, Norway
| | | | - Marli Camassola
- Enzymes and Biomass Laboratory, Institute of Biotechnology, University of Caxias do Sul, Caxias do Sul, RS, Brazil
| |
Collapse
|
3
|
Tang W, Huang C, Ling Z, He YC. Enhancing cellulosic digestibility of wheat straw by adding sodium lignosulfonate and sodium hydroxide to hydrothermal pretreatment. BIORESOURCE TECHNOLOGY 2023; 379:129058. [PMID: 37068525 DOI: 10.1016/j.biortech.2023.129058] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 03/16/2023] [Revised: 04/11/2023] [Accepted: 04/13/2023] [Indexed: 05/03/2023]
Abstract
Surfactant-assisted pretreatment has been widely reported to improve the enzymatic hydrolysis of lignocellulose by promoting removal of xylan and lignin. Hence, this work innovatively proposed the use of sodium lignosulfonate (SL) as an additive of alkaline pretreatment (AP), and evaluated its influence on the cellulosic digestibility of wheat straw (WS). The results displayed that the maximum of 72-h cellulosic digestibility could reach 83.5% as 15 g/L SL was introduced to the AP process (SAP), while the cellulosic digestibility of hydrothermal and alkaline pretreated WS was only 63.6% and 70.2%, respectively. These increments were subsequently attributed to the improvement of 6.5% xylan and 26.8% lignin accelerated by SAP, resulting in positive changes in structural characteristics such as accessibility, specific surface area, and cellulosic crystalline structure. The utilization of lignin-based surfactants in pretreatment has realized the economic feasibility of lignocellulosic biorefining and broadened the application prospect of surfactants.
Collapse
Affiliation(s)
- Wei Tang
- School of Pharmacy & School of Biological and Food Engineering, Jiangsu Key Laboratory of Advanced Catalytic Materials and Technology, National-Local Joint Engineering Research Center of Biomass Refining and High-Quality Utilization, Changzhou University, Changzhou 213164, Jiangsu Province, People's Republic of China
| | - Caoxing Huang
- Jiangsu Co-Innovation Center of Efficient Processing and Utilization of Forest Resources, College of Chemical Engineering, Nanjing Forestry University, Nanjing 210037, Jiangsu Province, People's Republic of China
| | - Zhe Ling
- Jiangsu Co-Innovation Center of Efficient Processing and Utilization of Forest Resources, College of Chemical Engineering, Nanjing Forestry University, Nanjing 210037, Jiangsu Province, People's Republic of China
| | - Yu-Cai He
- School of Pharmacy & School of Biological and Food Engineering, Jiangsu Key Laboratory of Advanced Catalytic Materials and Technology, National-Local Joint Engineering Research Center of Biomass Refining and High-Quality Utilization, Changzhou University, Changzhou 213164, Jiangsu Province, People's Republic of China; State Key Laboratory of Biocatalysis and Enzyme Engineering, Hubei Collaborative Innovation Center for Green Transformation of Bio-resources, Hubei Key Laboratory of Industrial Biotechnology, School of Life Sciences, Hubei University, Wuhan 430062, Hubei Province, People's Republic of China.
| |
Collapse
|
4
|
Oraby أميرة عرابي A, Weickardt I, Zibek S. Foam Fractionation Methods in Aerobic Fermentation Processes. Biotechnol Bioeng 2022; 119:1697-1711. [PMID: 35394649 DOI: 10.1002/bit.28102] [Citation(s) in RCA: 8] [Impact Index Per Article: 2.7] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 11/29/2021] [Revised: 03/01/2022] [Accepted: 03/27/2022] [Indexed: 11/07/2022]
Abstract
Inherently occurring foam formation during aerobic fermentations of surface-active compounds can be exploited by fractionating the foam. This also serves as the first downstream processing step for product concentration and is used for in situ product recovery. Compared to other foam prevention methods, it does not interfere with fermentation parameters or alter broth composition. Nevertheless, parameters affecting the foaming behaviour are complex. Therefore, the specific foam fractionation designs need to be engineered for each fermentation individually. This still hinders a widespread industrial application. However, few available commercial approaches demonstrate the applicability of foam columns on an industrial scale. This systematic literature review highlights relevant design aspects and process demands that need to be considered for an application to fermentations and proposes a classification of foam fractionation designs and methods. It further analyses substance-specific characteristics associated with foam fractionation. Finally, solutions for current challenges are presented, and future perspectives are discussed. This article is protected by copyright. All rights reserved.
Collapse
Affiliation(s)
- Amira Oraby أميرة عرابي
- Fraunhofer Institute for Interfacial Engineering and Biotechnology IGB, Nobelstr. 12, 70569, Stuttgart, Germany.,Institute of Interfacial Process Engineering and Plasma Technology IGVP, University of Stuttgart, Nobelstr. 12, 70569, Stuttgart, Germany
| | - Isabell Weickardt
- Fraunhofer Institute for Interfacial Engineering and Biotechnology IGB, Nobelstr. 12, 70569, Stuttgart, Germany
| | - Susanne Zibek
- Fraunhofer Institute for Interfacial Engineering and Biotechnology IGB, Nobelstr. 12, 70569, Stuttgart, Germany.,Institute of Interfacial Process Engineering and Plasma Technology IGVP, University of Stuttgart, Nobelstr. 12, 70569, Stuttgart, Germany
| |
Collapse
|
5
|
Sánchez Muñoz S, Rocha Balbino T, Mier Alba E, Gonçalves Barbosa F, Tonet de Pier F, Lazuroz Moura de Almeida A, Helena Balan Zilla A, Antonio Fernandes Antunes F, Terán Hilares R, Balagurusamy N, César Dos Santos J, Silvério da Silva S. Surfactants in biorefineries: Role, challenges & perspectives. BIORESOURCE TECHNOLOGY 2022; 345:126477. [PMID: 34864172 DOI: 10.1016/j.biortech.2021.126477] [Citation(s) in RCA: 13] [Impact Index Per Article: 4.3] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 10/15/2021] [Revised: 11/26/2021] [Accepted: 11/28/2021] [Indexed: 06/13/2023]
Abstract
The use of lignocellulosic biomass (LCB) as feedstock has received increasing attention as an alternative to fossil-based refineries. Initial steps such as pretreatment and enzymatic hydrolysis are essential to breakdown the complex structure of LCB to make the sugar molecules available to obtain bioproducts by fermentation. However, these steps increase the cost of the bioproduct and often reduces its competitiveness against synthetic products. Currently, the use of surfactants has shown considerable potential to enhance lignocellulosic biomass processing. This review addresses the main mechanisms and role of surfactants as key molecules in various steps of biorefinery processes, viz., increasing the removal of lignin and hemicellulose during the pretreatments, increasing enzymatic stability and enhancing the accessibility of enzymes to the polymeric fractions, and improving the downstream process during fermentation. Further, technical advances, challenges in application of surfactants, and future perspectives to augment the production of several high value-added bioproducts have been discussed.
Collapse
Affiliation(s)
- Salvador Sánchez Muñoz
- Bioprocesses and sustainable products laboratory. Department of Biotechnology, Engineering School of Lorena, University of São Paulo (EEL-USP), 12.602.810. Lorena, SP, Brazil
| | - Thércia Rocha Balbino
- Bioprocesses and sustainable products laboratory. Department of Biotechnology, Engineering School of Lorena, University of São Paulo (EEL-USP), 12.602.810. Lorena, SP, Brazil
| | - Edith Mier Alba
- Bioprocesses and sustainable products laboratory. Department of Biotechnology, Engineering School of Lorena, University of São Paulo (EEL-USP), 12.602.810. Lorena, SP, Brazil
| | - Fernanda Gonçalves Barbosa
- Bioprocesses and sustainable products laboratory. Department of Biotechnology, Engineering School of Lorena, University of São Paulo (EEL-USP), 12.602.810. Lorena, SP, Brazil
| | - Fernando Tonet de Pier
- Bioprocesses and sustainable products laboratory. Department of Biotechnology, Engineering School of Lorena, University of São Paulo (EEL-USP), 12.602.810. Lorena, SP, Brazil
| | - Alexandra Lazuroz Moura de Almeida
- Bioprocesses and sustainable products laboratory. Department of Biotechnology, Engineering School of Lorena, University of São Paulo (EEL-USP), 12.602.810. Lorena, SP, Brazil
| | - Ana Helena Balan Zilla
- Bioprocesses and sustainable products laboratory. Department of Biotechnology, Engineering School of Lorena, University of São Paulo (EEL-USP), 12.602.810. Lorena, SP, Brazil
| | - Felipe Antonio Fernandes Antunes
- Bioprocesses and sustainable products laboratory. Department of Biotechnology, Engineering School of Lorena, University of São Paulo (EEL-USP), 12.602.810. Lorena, SP, Brazil
| | - Ruly Terán Hilares
- Laboratório de Materiales, Universidad Católica de Santa María - UCSM. Urb. San José, San José s/n, Yanahuara, Arequipa, Perú
| | - Nagamani Balagurusamy
- Bioremediation laboratory. Faculty of Biological Sciences, Autonomous University of Coahuila (UA de C), Torreón Campus, 27000 Coah, México
| | - Júlio César Dos Santos
- Biopolymers, bioreactors, and process simulation laboratory. Department of Biotechnology, Engineering School of Lorena, University of São Paulo (EEL-USP), 12.602.810. Lorena, SP, Brazil
| | - Silvio Silvério da Silva
- Bioprocesses and sustainable products laboratory. Department of Biotechnology, Engineering School of Lorena, University of São Paulo (EEL-USP), 12.602.810. Lorena, SP, Brazil.
| |
Collapse
|
6
|
Hou H, Li S, Meng Z, Li Z, Darwesh OM, Zheng H. Removal of Cu ions in wastewater through a combined foam separation–cell adsorption approach. Chem Eng Technol 2021. [DOI: 10.1002/ceat.202100482] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/07/2022]
Affiliation(s)
- Hongya Hou
- School of Chemical Engineering and Technology Hebei University of Technology Tianjin 300130 China
| | - SiYu Li
- School of Chemical Engineering and Technology Hebei University of Technology Tianjin 300130 China
| | - ZhiChao Meng
- School of Chemical Engineering and Technology Hebei University of Technology Tianjin 300130 China
| | - Zhiqiang Li
- School of Chemical Engineering and Technology Hebei University of Technology Tianjin 300130 China
| | - Osama M. Darwesh
- Department of Agricultural Microbiology National Research Centre Cairo 12622 Egypt
| | - Huijie Zheng
- School of Chemical Engineering and Technology Hebei University of Technology Tianjin 300130 China
| |
Collapse
|
7
|
Darwesh OM, Mahmoud MS, Barakat KM, Abuellil A, Ahmad MS. Improving the bioremediation technology of contaminated wastewater using biosurfactants produced by novel bacillus isolates. Heliyon 2021; 7:e08616. [PMID: 34988315 PMCID: PMC8703238 DOI: 10.1016/j.heliyon.2021.e08616] [Citation(s) in RCA: 4] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [Abstract] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 10/24/2021] [Revised: 11/28/2021] [Accepted: 12/14/2021] [Indexed: 11/29/2022] Open
Abstract
Biosurfactants have many advantages outside chemical one, led for application it through different sectors. So, the present study aimed for improving the bioremediation technology of contaminated wastewater using biosurfactants produced by novel bacillus isolates. In this regard, Bacillus thuringiensis and Bacillus toyonensis strains were obtained as most producing isolates of highly active biosurfactants. The optimized conditions for high biosurfactants yield production were established. Also, the stability of the produced biosurfactants at various conditions, pH, temperature and salinity was studied. The biosurfactant has been reported up to 120 °C, pH 12 and 10% of NaCl. The identified biosurfactants, decanoic acid and oleamide were applied for wastewater remediation from oil residues and pathogens contamination. The biosurfactant was had high antibacterial activity compared with references antimicrobial drugs, as well as it is enhanced bioremediation technology for petroleum oil residues contaminating sites. Thus, we can say, these biosurfactants could achieve the objectives of sustainable development.
Collapse
|