1
|
He L, Wang D, Zhu T, Lv Y, Li S. Pyrolysis recycling of pig manure biochar adsorption material for decreasing ammonia nitrogen in biogas slurry. THE SCIENCE OF THE TOTAL ENVIRONMENT 2023; 881:163315. [PMID: 37028657 DOI: 10.1016/j.scitotenv.2023.163315] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Subscribe] [Scholar Register] [Received: 02/06/2023] [Revised: 03/19/2023] [Accepted: 04/02/2023] [Indexed: 06/01/2023]
Abstract
Biochar adsorption materials have a good removal effect on ammonia nitrogen in piggery biogas slurry. However, the cost of biochar adsorption material is still high. If these materials can be recycled several times, the cost can be significantly reduced. Therefore, this paper investigated a new process of biochar adsorption material (C@Mg-P) pyrolysis cycle for reducing ammonia nitrogen in piggery biogas slurry. The effects of pyrolysis process conditions (pyrolysis temperature and pyrolysis time) and number of recycling times on reducing ammonia nitrogen in biogas slurry by C@Mg-P were studied, a preliminary investigation on the reaction mechanism of C@Mg-P for reducing ammonia nitrogen in biogas slurry was conducted, and the economic feasibility of the pyrolysis recycling process was analyzed. It was found that the NH3-N elimination efficiency by C@Mg-P was 79.16 % under the optimal conditions of 0.5 h and 100 °C. Second, C@Mg-P removed 70.31 % NH3-N after recycling 10 times. Chemical precipitation, ion exchange, physical adsorption and electrostatic attraction were the potential reaction mechanisms for NH3-N reduction by C@Mg-P. Moreover, C@Mg-P had a good decolorization effect on piggery biogas slurry with a 72.56 % decolorization rate. Compared with the non-pyrolyzed recycling process, the proposed process saved 80 % of the cost, thus representing an economically possible approach for pig manure biochar application in wastewater denitrification treatment.
Collapse
Affiliation(s)
- Lintong He
- College of Natural Resources and Environment, South China Agricultural University, Guangzhou 510642, China; Guangdong Provincial Key Laboratory of Agricultural & Rural Pollution Abatement and Environmental Safety, Guangzhou 510642, China
| | - Dehan Wang
- College of Natural Resources and Environment, South China Agricultural University, Guangzhou 510642, China; Guangdong Provincial Key Laboratory of Agricultural & Rural Pollution Abatement and Environmental Safety, Guangzhou 510642, China.
| | - Tianlang Zhu
- College of Natural Resources and Environment, South China Agricultural University, Guangzhou 510642, China; Guangdong Provincial Key Laboratory of Agricultural & Rural Pollution Abatement and Environmental Safety, Guangzhou 510642, China
| | - Yongzhen Lv
- College of Natural Resources and Environment, South China Agricultural University, Guangzhou 510642, China; Guangdong Provincial Key Laboratory of Agricultural & Rural Pollution Abatement and Environmental Safety, Guangzhou 510642, China
| | - Sicheng Li
- College of Natural Resources and Environment, South China Agricultural University, Guangzhou 510642, China; Guangdong Provincial Key Laboratory of Agricultural & Rural Pollution Abatement and Environmental Safety, Guangzhou 510642, China
| |
Collapse
|
2
|
Yan L, Zheng Y, Chen W, Liu S, Yin M, Jiang J, Yang M. Step feed mode synergistic mixed carbon source to improve sequencing batch reactor simultaneous nitrification and denitrification efficiency of domestic wastewater treatment. BIORESOURCE TECHNOLOGY 2022; 358:127440. [PMID: 35680088 DOI: 10.1016/j.biortech.2022.127440] [Citation(s) in RCA: 9] [Impact Index Per Article: 4.5] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 04/28/2022] [Revised: 06/03/2022] [Accepted: 06/05/2022] [Indexed: 06/15/2023]
Abstract
The limited efficiency of nitrogen removal has traditionally hindered wide application of simultaneous nitrification and denitrification (SND) technology. Here, the nitrogen removal characteristics of a sequencing batch reactor were studied by adopting a strategy of a step-feeding mode, synergistic regional oxygen limitation, and a mixed carbon source. The changes of the microbial population succession and nitrogen metabolism functional genes were analyzed. This strategy provided a favorable level of dissolved oxygen and continuous carbon sources for driving the denitrification process. The total nitrogen removal efficiency and SND rate reached 92.60% and 96.49%, respectively, by regulating the ratio of sodium acetate to starch in the step feed to 5:1. This procedure increased the relative abundance of denitrifying functional genes and induced the growth of a variety of traditional denitrifying bacteria and aerobic denitrifying bacteria participating in the process of nitrogen removal. Overall, this work offers a new strategy for achieving efficient SND.
Collapse
Affiliation(s)
- Lilong Yan
- College of Resource and Environment, Northeast Agricultural University, Harbin 150030 China.
| | - Yaoqi Zheng
- College of Resource and Environment, Northeast Agricultural University, Harbin 150030 China
| | - Wanting Chen
- College of Resource and Environment, Northeast Agricultural University, Harbin 150030 China
| | - Shuang Liu
- College of Resource and Environment, Northeast Agricultural University, Harbin 150030 China
| | - Mingyue Yin
- College of Resource and Environment, Northeast Agricultural University, Harbin 150030 China
| | - Jishuang Jiang
- College of Resource and Environment, Northeast Agricultural University, Harbin 150030 China
| | - Mengya Yang
- College of Resource and Environment, Northeast Agricultural University, Harbin 150030 China
| |
Collapse
|
3
|
Sun Z, Li J, Fan Y, Meng J, Deng K. Efficiency and mechanism of nitrogen removal from piggery wastewater in an improved microaerobic process. THE SCIENCE OF THE TOTAL ENVIRONMENT 2021; 774:144925. [PMID: 33610988 DOI: 10.1016/j.scitotenv.2020.144925] [Citation(s) in RCA: 1] [Impact Index Per Article: 0.3] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 09/17/2020] [Revised: 12/12/2020] [Accepted: 12/28/2020] [Indexed: 06/12/2023]
Abstract
Characterized by high ammonium (NH4+ - N) and low ratio of chemical oxygen demand (COD) to total nitrogen (COD/TN), discharge of piggery wastewater has been identified as a primary pollution source resulting in water eutrophication. An improved microaerobic reactor, internal aerating microaerobic reactor (IAMR), was constructed to treat manure-free piggery wastewater without effluent recycle at dissolved oxygen of 0.3 mg/L and 32 °C. A removal rate of COD, NH4+ - N and TN averaged 77.9%, 94.6% and 82.6% was obtained in the reactor, with the concentration of 258.5, 235.5 and 335.2 mg/L in influent, respectively. 16S rDNA amplicon sequencing, carbon and nitrogen mass balance and stoichiometry indicated that heterotrophic nitrification-anammox was the dominant approach to nitrogen removal. Microbiome phenotypes showed that aerobic bacteria were the dominant microorganisms, and the microbiome oxidative stress tolerance was intensified along with the continuous operation of the IAMR, resulting in the survival of various facultative and anaerobic bacteria for nutrients removal. With the good nutrients removal, less energy consumption, and high tolerance to influent fluctuation, the improved IAMR was confirmed as a promising process for treating wastewater with high NH4+ - N and low COD/TN.
Collapse
Affiliation(s)
- Zhenju Sun
- State Key Laboratory of Urban Water Resource and Environment, Harbin Institute of Technology, 73 Huanghe Road, Harbin 150090, PR China
| | - Jianzheng Li
- State Key Laboratory of Urban Water Resource and Environment, Harbin Institute of Technology, 73 Huanghe Road, Harbin 150090, PR China
| | - Yiyang Fan
- State Key Laboratory of Urban Water Resource and Environment, Harbin Institute of Technology, 73 Huanghe Road, Harbin 150090, PR China
| | - Jia Meng
- State Key Laboratory of Urban Water Resource and Environment, Harbin Institute of Technology, 73 Huanghe Road, Harbin 150090, PR China.
| | - Kaiwen Deng
- State Key Laboratory of Urban Water Resource and Environment, Harbin Institute of Technology, 73 Huanghe Road, Harbin 150090, PR China
| |
Collapse
|
4
|
Liu J, Yu S, Cong D, Yue J, Yang C, Wang X, Ni C, Wang T. Optimization of a novel single air-lift sequencing bioreactor for raw piggery wastewater treatment: Nutrients removal and microbial community structure analysis. BIORESOURCE TECHNOLOGY 2021; 321:124431. [PMID: 33264743 DOI: 10.1016/j.biortech.2020.124431] [Citation(s) in RCA: 12] [Impact Index Per Article: 4.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 09/25/2020] [Revised: 11/14/2020] [Accepted: 11/16/2020] [Indexed: 06/12/2023]
Abstract
In this study, a sequencing batch and intermittent air-lift bioreactor (SBIAB) was evaluated under the three independent variables to treat raw piggery wastewater. The effects of hydraulic retention time (HRT), air flow rate and sludge retention time (SRT) on the nutrients removal of SBIAB were researched. The optimum values of HRT, air flow rate and SRT were 8 d, 2 l/min and 20 d, respectively. Meanwhile, the removal rates of chemical oxygen demand (COD), NH4+-N, total nitrogen (TN) and total phosphorus (TP) were up to 89.5%, 93.5%, 61.1% and 57.3%, respectively. Generally, the nutrients removal performance could be enhanced with increasing HRT from 6 to 10 d, while it was inhibited at air flow rate of 3 l/min. Higher air flow rate caused the alkaline pH and high free ammonia concentration, which imposed restrictions on the process of wastewater treatment. In the SBIAB, a coupling of aerobic/anoxic/anaerobic zone was formed according to the changes of oxidation-reduction potential (ORP) values at the optimum condition. Microbial community structure analysis indicated that the functional microbes including Brachymonas, Prokaryote, Giesbergeria, Comamonadaceae bacterium, Clostridiales bacterium, Comamonas, Tissierella, Aequorivita were enriched in the SBIAB, which played a significant role in the removal of complex organics and nitrogen.
Collapse
Affiliation(s)
- Jia Liu
- Heilongjiang Province Key Laboratory of Cold Region Wetland Ecology and Environment Research, School of Geography and Tourism, Harbin University, 109 Zhongxing Road, Harbin 150086, China.
| | - Shaopeng Yu
- Heilongjiang Province Key Laboratory of Cold Region Wetland Ecology and Environment Research, School of Geography and Tourism, Harbin University, 109 Zhongxing Road, Harbin 150086, China
| | - Donglai Cong
- Heilongjiang Province Key Laboratory of Cold Region Wetland Ecology and Environment Research, School of Geography and Tourism, Harbin University, 109 Zhongxing Road, Harbin 150086, China
| | - Junguang Yue
- Heilongjiang Province Key Laboratory of Cold Region Wetland Ecology and Environment Research, School of Geography and Tourism, Harbin University, 109 Zhongxing Road, Harbin 150086, China
| | - Chunxue Yang
- Heilongjiang Province Key Laboratory of Cold Region Wetland Ecology and Environment Research, School of Geography and Tourism, Harbin University, 109 Zhongxing Road, Harbin 150086, China
| | - Xiaodi Wang
- Heilongjiang Province Key Laboratory of Cold Region Wetland Ecology and Environment Research, School of Geography and Tourism, Harbin University, 109 Zhongxing Road, Harbin 150086, China
| | - Chao Ni
- Heilongjiang Province Key Laboratory of Cold Region Wetland Ecology and Environment Research, School of Geography and Tourism, Harbin University, 109 Zhongxing Road, Harbin 150086, China
| | - Tiane Wang
- Heilongjiang Province Key Laboratory of Cold Region Wetland Ecology and Environment Research, School of Geography and Tourism, Harbin University, 109 Zhongxing Road, Harbin 150086, China
| |
Collapse
|
5
|
Lin LY, Zheng JA, Huang SC, Hung GY, Horng JL. Ammonia exposure impairs lateral-line hair cells and mechanotransduction in zebrafish embryos. CHEMOSPHERE 2020; 257:127170. [PMID: 32497837 DOI: 10.1016/j.chemosphere.2020.127170] [Citation(s) in RCA: 14] [Impact Index Per Article: 3.5] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 03/17/2020] [Revised: 05/18/2020] [Accepted: 05/20/2020] [Indexed: 06/11/2023]
Abstract
Ammonia (including NH3 and NH4+) is a major pollutant of freshwater environments. However, the toxic effects of ammonia on the early stages of fish are not fully understood, and little is known about the effects on the sensory system. In this study, we hypothesized that ammonia exposure can cause adverse effects on embryonic development and impair the lateral line system of fish. Zebrafish embryos were exposed to high-ammonia water (10, 15, 20, 25, and 30 mM NH4Cl; pH 7.0) for 96 h (0-96 h post-fertilization). The body length, heart rate, and otic vesicle size had significantly decreased with ≥15 mM NH4Cl, while the number and function of lateral-line hair cells had decreased with ≥10 mM NH4Cl. The mechanoelectrical transduction (MET) channel-mediated Ca2+ influx was measured with a scanning ion-selective microelectrode technique to reveal the function of hair cells. We found that NH4+ (≥5 mM NH4Cl) entered hair cells and suppressed the Ca2+ influx of hair cells. Neomycin and La3+ (MET channel blockers) suppressed NH4+ influx, suggesting that NH4+ enters hair cells via MET channels in hair bundles. In conclusion, this study showed that ammonia exposure (≥10 mM NH4Cl) can cause adverse effects in zebrafish embryos, and lateral-line hair cells are sensitive to ammonia exposure.
Collapse
Affiliation(s)
- Li-Yih Lin
- Department of Life Science, School of Life Science, National Taiwan Normal University, Taipei, 11677, Taiwan
| | - Jie-An Zheng
- Department of Life Science, School of Life Science, National Taiwan Normal University, Taipei, 11677, Taiwan
| | - Shun-Chih Huang
- Department of Life Science, School of Life Science, National Taiwan Normal University, Taipei, 11677, Taiwan
| | - Giun-Yi Hung
- Division of Pediatric Hematology and Oncology, Department of Pediatrics, Taipei Veterans General Hospital, Taipei, 11217, Taiwan; Department of Pediatrics, Faculty of Medicine, School of Medicine, National Yang-Ming University, Taipei, 11221, Taiwan
| | - Jiun-Lin Horng
- Department of Anatomy and Cell Biology, School of Medicine, College of Medicine, Taipei Medical University, Taipei, 11031, Taiwan.
| |
Collapse
|