Effect of phosphoric acid as a catalyst on the hydrothermal pretreatment and acidogenic fermentation of food waste

Enhancement of volatile fatty acids to extremely high content in fermentation of food waste: Optimization of conditions, microbial functional genes, and mechanisms

The engineering application of volatile fatty acids (VFA) production from food waste (FW) can significantly enhance resource utilization. Enhancing VFA production is crucial for advancing this engineering application. This study presented a economically-feasible method to achieve high VFA production from FW: Conducting fermentation at pH 9 and 37 ℃ with addition of 20 % anaerobic sludge significantly increased the conversion of FW to VFAs (80.56 g COD/L, accounting for 87.37 % of the soluble chemical oxygen demand), while also increasing the content of NH4+-N (2658.15 mg/L). Macrotranscriptomic sequencing showed that Anaerosalibacter, Amphibacillus, Wansuia, Clostridiisalibacter, unclassified Tissierellia, Massilibacterium, unclassified Bacteroidales, and Tissierellia were the key active microorganisms for VFA production. The expression abundance of functional enzymes and genes related to VFA production pathways increased during the fermentation. This study significantly advanced the practical application of VFA production from FW, offering both theoretical insights and bacterial resources.

Enhanced lactic acid production from household food waste under hyperthermophilic conditions: Mechanisms and regulation

An annual production of about 500 million tons of household food waste (HFW) has been documented, resulting in significant implications for human health and the environment in the absence of appropriate treatment. The anaerobic fermentation of HFW in an open system offers the potential to recover high value-added products, lactic acid (LA), thereby simultaneously addressing waste treatment and enhancing resource recovery efficiency. Most of LA fermentation studies have been conducted under mesophilic and thermophilic conditions, with limited research on the production of LA through anaerobic fermentation under hyperthermophilic conditions. This study aimed to produce LA through anaerobic fermentation from HFW under hyperthermophilic conditions (70 ± 1 °C), while varying pH values (5.0 ± 0.1, 7.0 ± 0.1, and 9.0 ± 0.1), and compare the results with LA production under mesophilic (35 ± 1 °C) and thermophilic (52 ± 1 °C) conditions. The findings of this study indicated that the combination of hyperthermophilic conditions and a neutral pH (pH7_70) yielded the highest concentration of LA, measuring at 17.75 ± 1.51 g/L. The mechanism underlying the high yield of LA at 70 °C was elucidated through the combined analysis of organics dissolution, enzymes activities, and 16S rRNA microbiome sequencing.

Hydrothermal carbonization of food waste for sustainable biofuel production: Advancements, challenges, and future prospects

With the improvement of living standards, food waste (FW) has become one of the most important organic solid wastes worldwide. Owing to the high moisture content of FW, hydrothermal carbonization (HTC) technology that can directly utilize the moisture in FW as the reaction medium, is widely used. Under mild reaction conditions and short treatment cycle, this technology can effectively and stably convert high-moisture FW into environmentally friendly hydrochar fuel. In view of the importance of this topic, this study comprehensively reviews the research progress of HTC of FW for biofuel synthesis, and critically summarizes the process parameters, carbonization mechanism, and clean applications. Physicochemical properties and micromorphological evolution of hydrochar, hydrothermal chemical reactions of each model component, and potential risks of hydrochar as a fuel are highlighted. Furthermore, carbonization mechanism of the HTC treatment process of FW and the granulation mechanism of hydrochar are systematically reviewed. Finally, potential risks and knowledge gaps in the synthesis of hydrochar from FW are presented and new coupling technologies are pointed out, highlighting the challenges and prospects of this study.

The effect of anaerobic co-fermentation on acidification performance of food waste and cardboard waste

The fermentation system with high solid materials for food waste (FW) is uneven in nutrition and easy to produce volatile acid accumulation, which causes the reaction system to acidify and affects the normal operation of fermentation. This study evaluated the effect of the co-substrate percentages (FW:CB = 9:1, FW:CB = 8:2, FW:CB = 7:3) and the initial total solid contents (12%, 15%, 18%) on the co-fermentation acidification performance of FW and cardboard waste (CB). The maximum methane production was obtained when mono-fermenting FW had high solids contents (1.4 L/kg). The methane production increased and then decreased with the increasing percentages of CB. Under the conditions of FW:CB = 8:2, the maximum methane production could reach 3.4 L/kg. The lower methane production (1.8 - 2.5 L/kg) with high percentages of CB (FW:CB = 7:3) was translated into higher yields of caproic acid (up to 26%), which indicated that lower percentages of CB had a stabilization effect due to the higher buffering capacities in co-fermentation. As a result, this study demonstrated new possibilities for using CB percentages to control the production of high added-value biogas in dry co-fermentation of FW.

Food waste treating by biochar-assisted high-solid anaerobic digestion coupled with steam gasification: Enhanced bioenergy generation and porous biochar production

A food waste treating system was proposed in this study by combining biochar-assisted high-solid anaerobic digestion and subsequent steam gasification of the digestate. The effect of solid level, biochar dosage in anaerobic digestion on the properties of biogas, syngas, and final biochar products were investigated. Results showed that at a high total solid level and biochar dosage of 25 g/L and 50 g/L, the accumulative methane yield reached 110.3 mL CH₄/g VS and 126.7 mL CH₄/g VS, respectively. From steam gasification of different digestates under 850 °C for 15 min, a maximum of 34.92 mmol/g for the hydrogen yield and 11.44 MJ/m³ for the higher heating value could be obtained for the syngas. Furthermore, the by-product produced from steam gasification was a nutrient-enriched porous biochar, which was suitable to be used as compost. This study demonstrated a pathway for food waste treating to produce methane-enriched biogas, hydrogen-enriched syngas, and nutrient-enriched biochar.

Microbial biodiesel production from industrial organic wastes by oleaginous microorganisms: Current status and prospects

This review aims to encourage the technical development of microbial biodiesel production from industrial-organic-wastes-derived volatile fatty acids (VFAs). To this end, this article summarizes the current status of several key technical steps during microbial biodiesel production, including (1) acidogenic fermentation of bio-wastes for VFA collection, (2) lipid accumulation in oleaginous microorganisms, (3) microbial lipid extraction, (4) transesterification of microbial lipids into crude biodiesel, and (5) crude biodiesel purification. The emerging membrane-based bioprocesses such as electrodialysis, forward osmosis and membrane distillation, are promising approaches as they could help tackle technical challenges related to the separation and recovery of VFAs from the fermentation broth. The genetic engineering and metabolic engineering approaches could be applied to design microbial species with higher lipid productivity and rapid growth rate for enhanced fatty acids synthesis. The enhanced in situ transesterification technologies aided by microwave, ultrasound and supercritical solvents are also recommended for future research. Technical limitations and cost-effectiveness of microbial biodiesel production from bio-wastes are also discussed, in regard to its potential industrial development. Based on the overview on microbial biodiesel technologies, an integrated biodiesel production line incorporating all the critical technical steps is proposed for unified management and continuous optimization for highly efficient biodiesel production.

Swine manure valorization for phosphorus and nitrogen recovery by catalytic-thermal hydrolysis and struvite crystallization

Phosphorus (P) and nitrogen (N) recovery from swine manure has attracted considerable interest for biomass valorization. In this study, a catalytic-thermal hydrolysis (TH) process combined with struvite crystallization was investigated to promote P and N conversion from swine manure. Its potential as a phosphate-based fertilizer was investigated. Two periods for P solubilization and transformation were observed, i.e., an initial increase with reaction time followed by a decrease as treatment continued. Nitrogen conversion efficiency increased with increasing temperature and time. Treatment of swine manure by catalytic-TH with HCl + H₂O₂ showed the best performance for P and N solubilization and transformation. With a Mg²⁺/PO₄^3- molar ratio of 2.49 and a pH of 9.11, the struvite crystallization efficiency from the supernatant after catalytic-TH with HCl + H₂O₂ reached 99.2%. Hydroculture bioassay showed that struvite had a positive effect on the early growth of wheat. The P concentrations in both root and shoot tissues for struvite treatment were more than two times higher than that of soluble P. These encouraging results warrant further studies on the conversion of biowaste given that recycling nutrients sources may outperform traditional synthetic fertilizers.

Value Proposition of Untapped Wet Wastes: Carboxylic Acid Production through Anaerobic Digestion

Although traditional anaerobic digestion (AD) process to produce methane-rich biogas from wet waste is deep-rooted, high carbon footprint and its low value as compared with other renewable sources demand advanced strategies to avoid its production. An emerging conversion pathway to arrest methanogenesis for producing value-added fuels and chemicals instead of biogas is sought as a sustainable alternative. This research provides a comprehensive analysis on current technology development, process challenges, applications, and economics for producing high-value short-chain carboxylic acids from AD of wet wastes. We show that (1) the theoretical energy yields of acids equal or exceed biogas, and (2) the cost of these acids is competitive with those produced from chemical markets, making this economically viable for mass production. With global abundance of wet waste feedstocks, this process of short-chain acid production provides a promising alternative to conventional biogas production technology, while achieving waste management and carbon mitigation goals.

Phosphorus recovered from digestate by hydrothermal processes with struvite crystallization and its potential as a fertilizer

Phosphorus (P) recovery from digestate has attracted considerable interest. In this study, hydrothermal processes in combination with struvite crystallization were performed to promote P solubilization and capture from digestate; its potential as a phosphate-based fertilizer was also investigated. Hydrothermal treatment with HCl and H₂O₂ showed good results for the solubilization of organic and slightly soluble P, and achieved the lowest input energy need (768 kWhkg^-1_P). Struvite crystallization reached 99.3% (Mg²⁺:PO₄^3-1.84:1, pH 9.98). X-ray diffractometry and energy dispersive X-ray spectrometer mapping demonstrated the main precipitate component was struvite. For the fertilization of maize, P utilization from struvite was 19.0%. Light microscope analysis revealed that appropriate amounts of struvite may have an influence on the growth of the primary root. Overall, 16.6% of total P was recovered after P was solubilized, captured and made available.

Plasma metabolomics profiles in rats with acute traumatic brain injury

Traumatic brain injury (TBI) is a major cause of mortality and disability worldwide. We validated the utility of plasma metabolomics analysis in the clinical diagnosis of acute TBI in a rat model of controlled cortical impact (CCI) using gas chromatography/mass spectrometry (GC/MS). Thirty Sprague-Dawley rats were randomly divided into two groups of 15 rats each: the CCI group and sham group. Blood samples were obtained from the rats within the first 24 h after TBI injury. GC/MS measurements were performed to evaluate the profile of acute TBI-induced metabolic changes, resulting in the identification of 45 metabolites in plasma. Principal component analysis, partial least squares-discriminant analysis, orthogonal partial least square discriminant analysis using hierarchical clustering and univariate/multivariate analyses revealed clear differences in the plasma metabolome between the acute CCI group and the sham group. CCI induced distinctive changes in metabolites including linoleic acid metabolism, amino acid metabolism, galactose metabolism, and arachidonic acid metabolism. Specifically, the acute CCI group exhibited significant alterations in proline, phosphoric acid, β-hydroxybutyric acid, galactose, creatinine, L-valine, linoleic acid and arachidonic acid. A receiver operating characteristic curve analysis showed that the above 8 metabolites in plasma could be used as the potential biomarkers for the diagnosis of acute TBI. Furthermore, this study is the first time to identify the galactose as a biomarker candidate for acute TBI. This comprehensive metabolic analysis complements target screening for potential diagnostic biomarkers of acute TBI and enhances predictive value for the therapeutic intervention of acute TBI.