Optimization of microwave-assisted extraction and supercritical fluid extraction of carbamate pesticides in soil by experimental design methodology

Orthogonal array design (OAD) was applied for the first time to optimize microwave-assisted extraction (MAE) and supercritical fluid extraction (SFE) conditions for the analysis of four carbamates (propoxur, propham, methiocarb, chlorpropham) from soil. The theory and methodology of a new OA16 (4(4)) matrix derived from a OA16 (2(15)) matrix were developed during the MAE optimization. An analysis of variance technique was employed as the data analysis strategy in this study. Determinations of analytes were completed using high-performance liquid chromatography (HPLC) with UV detection. Four carbamates were successfully extracted from soil with recoveries ranging from 85 to 105% with good reproducibility (approximately 4.9% RSD) under the optimum MAE conditions: 30 ml methanol, 80 degrees C extraction temperature, and 6-min microwave heating. An OA8 (2(7)) matrix was employed for the SFE optimization. The average recoveries and RSD of the analytes from spiked soil by SFE were 92 and 5.5%, respectively except for propham (66.3+/-7.9%), under the following conditions: heating for 30 min at 60 degrees C under supercritical CO2 at 300 kg/cm2 modified with 10% (v/v) methanol. The composition of the supercritical fluid was demonstrated to be a crucial factor in the extraction. The addition of a small volume (10%) of methanol to CO2 greatly enhanced the recoveries of carbamates. A comparison of MAE with SFE was also conducted. The results indicated that >85% average recoveries were obtained by both optimized extraction techniques, and slightly higher recoveries of three carbamates (propoxur, propham and methiocarb) were achieved using MAE. SFE showed slightly higher recovery for chlorpropham (93 vs. 87% for MAE). The effects of time-aged soil on the extraction of analytes were examined and the results obtained by both methods were also compared.

Multiresidue analysis of carbamate pesticides in soil by sonication-assisted extraction in small columns and liquid chromatography

A rapid multiresidue method has been developed for the analysis of carbamate insecticides (oxamyl, methomyl, propoxur, carbofuran, carbaryl and methiocarb) in soil. The method is based on the sonication-assisted extraction of soil samples placed in small columns using a low volume of methanol. Residue levels in soil were determined by reversed-phase high-performance liquid chromatography with fluorescence detection after post-column derivatisation. The separation of carbamates is performed on a C8 column with water-methanol as mobile phase. Recovery studies were carried out at 0.5, 0.1 and 0.01 microg/g fortification levels and average recoveries obtained for carbamates ranged from 82 to 99% with relative standard deviations between 0.4 and 10%. The effect of residue residence time and soil moisture content on the insecticide recovery was also studied. The method is linear over the range assayed, from 0.1 to 1 microg/ml. The detection limit for the carbamates varied from 1.6 to 3.7 microg/kg and the quantification limit obtained was 10 microg/kg. The emission and excitation allowed the confirmation of residues at levels around 0.1 microg/g.

Supercritical fluid extraction for the analysis of pesticide residues in miscellaneous samples

Supercritical fluid extraction (SFE) procedures for pesticide residue analysis are reviewed and discussed. A variety of applications were classified, on matrices such as fruits, vegetables, soils, biological tissues, and other materials. Emphasis is placed on analysis of samples with a high water content containing polar pesticides, with particular attention paid to the multiresidue analyses.