Quality of final rinse water used in washer-disinfectors for endoscopes

German guidelines for reprocessing endoscopes and endoscopic accessories: guideline compliance in Frankfurt/Main, Germany

Guidelines for reprocessing flexible endoscopes have been published in many countries. The present survey investigated compliance with German guidelines in all hospitals and private practices in Frankfurt/Main, Germany. In 2003, all endoscopic units in Frankfurt/Main [15 hospitals and 23 private practices (10 large practices performing >1,000 endoscopies/year and 13 small practices performing <1,000 endoscopies/year)] were visited by members of the Public Health Service and assessed using a checklist based on the recommendations of the German guidelines. In 2004, a re-evaluation took place, either by analysing the written reports of the institutions or by visiting them again. Meanwhile, one hospital had closed and three small practices had ceased performing endoscopy, so the re-evaluation encompassed 14 hospitals and 20 private practices. In 2003, hospital compliance with the guidelines was satisfactory but many problems were identified in private practices. Between 2003 and 2004, great improvements were made. By the end of 2004, 90% of private practices had adequate storage facilities for reprocessed endoscopes, and were performing reprocessing of bottles and tubes for air-/water-channel flushing correctly (2003: adequate storage 52%; correct reprocessing 74%). Sterilization of endoscopic accessories was satisfactory, and routine testing of endoscopes after reprocessing was performed in all private practices at the end of 2004 (2003: sterilization of accessories 57%; microbiological control tests 56%). In 2003, although hospital compliance with the guidelines was satisfactory, mandatory improvements were required in private practices, notably in smaller units. Infection control advice and the control of public health regulations resulted in the correction of most processing faults between 2003 and 2004.

Reprocessing endoscopes: United States perspective

Endoscopes are used frequently for the diagnosis and therapy of medical disorders. For example, greater than 10000000 gastrointestinal endoscopic procedures are performed each year in the United States. Failure to employ appropriate cleaning and disinfection/sterilization of endoscopes has been responsible for multiple nosocomial outbreaks and serious, sometimes life-threatening, infections. Flexible endoscopes, by virtue of the site of use, have a high bioburden of microorganisms after use. The bioburden found on flexible gastrointestinal endoscopes following use has ranged from 10(5) to 10(10)CFU/ml, with the highest levels being found in the suction channels. Cleaning dramatically reduces the bioburden on endoscopes. Several investigators have shown a mean log(10) reduction factor of 4 (99.99%) in the microbial contaminants with cleaning alone. Cleaning should be done promptly following each use of an endoscope to prevent drying of secretions, allow removal of organic material, and decrease the number of microbial pathogens. Because the endoscope comes into intimate contact with mucous membranes, high-level disinfection is the reprocessing standard after each patient use. High-level disinfection refers to the use of a disinfectant (e.g., FDA-cleared chemical sterilant or high-level disinfectant) that inactivates all microorganisms (i.e., bacteria, viruses, fungi, mycobacteria) but not high levels of bacterial spores. The disinfection process requires immersion of the endoscope in the high-level disinfectant and ensuring all channels are perfused for the approved contact time (e.g., for ortho-phthaladehyde this is 12 min in the US). Following disinfection, the endoscope and channels are rinsed with sterile water, filtered water, or tapwater. The channels are then flushed with alcohol and dried using forced air. The endoscope should be stored in a manner that prevents recontamination. A protocol that describes the meticulous manual cleaning process, the appropriate training and evaluation of the reprocessing personnel, and a quality assurance program for endoscopes should be adopted and enforced by each unit performing endoscopic reprocessing.