Influence of carbon dioxide stunning procedure on quality of turkey meat

Head-Only Stunning of Turkeys Part 2: Subjective and Objective Assessment of the Application of AC and DC Waveforms

Simple Summary

In this study, we investigated various types of application of head-only electrical stunning to turkeys, in order to improve the effectiveness of the stunning process. We used recordings of physical responses and of electroencephalograms (EEGs) to assess effectivity of stunning and various waveforms: alternating current (AC) and pulsed direct currents (DC). Depending on the waveforms, voltages between 125 and 250 V produced an effective stun in turkeys in this study.

Abstract

Electrical stunning is likely to remain an important stunning method for turkeys at slaughter. The purpose of this study is to understand the application of various waveforms of alternating current (AC) and pulsed direct currents (DC), head-only, to turkeys and to improve the effectiveness of handheld stunning of turkeys. We evaluated the effectiveness of stunning by documenting physical responses and recording electroencephalograms (EEGs). For the assessment of physical responses, the stunning voltage was varied depending on the proportion of animals effectively stunned at a certain voltage level. If all turkeys in a group of 10 were stunned, the voltage was decreased, and the next group was stunned. This was repeated until not all turkeys showed signs of being effectively stunned. The experiment was then repeated at the voltage level just above the one that showed incomplete effective stunning. The effects of the stunning on the EEG recording was assessed in 16 turkeys to measure the occurrence of epileptiform EEGs, in 14 turkeys to assess epileptiform EEGs after neck-cut (bleeding), and in 14 turkeys to assess the effect of increased voltage and reduced frequency on epileptiform EEGs. Assessing EEGs in a laboratory setting contributes considerably to the understanding of electrical stunning procedures. Voltages between 125 and 250 V, depending on the waveform assessed, were effective in producing an effective stun in turkeys in this study.

Head-Only Stunning of Turkeys Part 1: The Minimum Voltage Necessary to Break Down the Inherent High Resistance

Simple Summary

Pre-slaughter stunning is required for the humane slaughter of turkeys. For the head-only electrical stunning to be effective, the impedance (resistance) in the tissue of the head of the animal between the two electrodes must be overcome by the level of the voltage used. We have assessed the most appropriate voltage to effectively overcome the impedance and provide an effective stun, and that is also safe for the operator to use. Sinusoidal AC at 150 V and 50 Hz was considered to fulfil those requirements and was used for further testing.

Abstract

Pre-slaughter stunning is required for humane slaughter. For turkeys, head-only electrical stunning is most often used by small scale producers. To ensure immediate and effective stunning, the impedance (resistance) of the tissue of the head of the animal situated between the two electrodes needs to be overcome swiftly. The impedance is a function of the voltage and decreases non-linearly with increasing voltage. In this paper, we describe a method to assess the minimum voltage needed at which the impedance no longer decreases, that is likely to produce an effective stun. For ethical reasons, gas stunned, electrically naïve turkeys were used to measure impedance at various levels of voltage and current. Several combinations of voltage and frequency, alternate current (AC), direct current (DC) and pulsed DC, were identified that would be sufficient to achieve the maximum decrease in the impedance, and therefore would allow the highest current and the most effective stun. A minimum, expressed as Root Mean Squared voltage, of 150 V and 50 Hz. would be required in AC, 175 V in pulsed DC at 30% cycle (150 at 50% cycle), and 225 V if voltage spikes of very short duration were used. Sinusoidal AC applied at 150 V, 50 Hz was selected for further testing.

Effects of Two CO2 Stunning Methods on the Efficacy of Stunning and Blood Stress Indicators of Turkeys under Commercial Processing Conditions

The effect of CO₂ gas-stunning methods (G1: 30% CO2 15 sec, 55% CO₂ 40 sec, 70% CO₂ 45 sec; G2: 30% CO₂ 15 sec, 80% CO₂ 85 sec) on the efficacy of stunning, blood stress indicators and meat quality of turkeys were assessed. A total of 375 turkeys (125 heavy males, 125 light males, and 125 light females) were used. After stunning, clinical parameters (posture-loss, wing-flapping, breathing, response to toe-pinching, eye movements, and palpebral, corneal and pupillary reflexes) and glucose, lactate and cortisol levels were assessed. The G2 method showed a higher percentage of correctly stunned birds (81.3 vs. 70.7%) and lower cortisol levels (0.44 vs. 1.22 g/dL). The weight and sex had a significant influence on the behavioral and physiological responses after stunning. The G2 method was found to be acceptable for animal welfare during stunning, based on both the percentage of animals correctly stunned and dead (92% to 100%) and the blood cortisol level after stunning.