Treatment of wastewater from red and tropical fruit wine production by zeolite anaerobic fluidized bed reactor

Resource recovery from sugarcane vinasse by anaerobic digestion - A review

The increase in biofuel production by 2030, driven by the targets set at the 21st United Nations Framework Convention on Climate Change (COP21), will promote an increase in ethanol production, and consequently more vinasse generation. Sugarcane vinasse, despite having a high polluting potential due to its high concentration of organic matter and nutrients, has the potential to produce value-added resources such as volatile fatty acids (VFA), biohydrogen (bioH₂) and biomethane (bioCH₄) from anaerobic digestion. The objective of this paper is to present a critical review on the vinasse treatment by anaerobic digestion focusing on the final products. Effects of operational parameters on production and recovery of these resources, such as pH, temperature, retention time and type of inoculum were addressed. Given the importance of treating sugarcane vinasse due to its complex composition and high volume generated in the ethanol production process, this is the first review that evaluates the production of VFAs, bioH₂ and bioCH₄ in the treatment of this organic residue. Also, the challenges of the simultaneous production of VFA, bioH₂ and bioCH₄ and resources recovery in the wastewater streams generated in flex-fuel plants, using sugarcane and corn as raw material in ethanol production, are presented. The installation of flex-fuel plants was briefly discussed, with the main impacts on the treatment process of these effluents either jointly or simultaneously, depending on the harvest season.

Evaluation of natural zeolite as microorganism support medium in nitrifying batch reactors: influence of zeolite particle size

An evaluation of natural zeolite as a microorganism carrier in nitrifying reactors operated in batch mode was carried out. Specifically, the influence of zeolite particle sizes of 0.5, 1.0 and 2.0 mm in diameter on microorganism adherence to zeolite, ammonium adsorption capacity and the identification of microbial populations were assessed. The greatest amount of total biomass adhered was observed for a zeolite particle size of 1 mm (0.289 g) which was achieved on the 12th day of operation. The highest ammonium adsorption capacity was observed for a zeolite particle size of 0.5 mm, which was 64% and 31% higher than that observed for particle sizes of 1.0 and 2.0 mm, respectively. The maximum de-sorption values were also found for a zeolite particle size of 0.5 mm, although when equilibrium was reached the ammonium concentrations were similar to those observed for a zeolite particle size of 1.0 mm. It was also found that the experimental data on ammonium adsorption fitted very well to the Freundlich isotherm for the three particle sizes studied. Finally, the nitrifying reactors showed similar microbial populations independently of the particle size used as microorganism carrier. The dominant bacterial community was Gammaproteobacteria making up 80% of the total population found. Betaproteobacteria were also identified and made up 12% approx. of the total population. Ammonium Oxidant Betaproteobacteria and Nitrobacter were also detected.

The impact of ammonia nitrogen concentration and zeolite addition on the specific methanogenic activity of granular and flocculent anaerobic sludges

This work presents the effect of ammonia nitrogen concentration and zeolite addition on the specific methanogenic activity (SMA) of different anaerobic sludges with various physical structures (granular and flocculent), operating in batch conditions. Piggery, malting production and urban sludges derived from full-scale anaerobic reactors were tested in the experiment as the source of inoculum in batch digesters. It was found that piggery sludge was the most affected by the increase of ammonia nitrogen concentration while malting producing and municipal sludges were less affected. In general, the addition of zeolite at doses in the range of 0.01-0.1 g/g VSS reduced the inhibitory effect of N-NH(4)(+) for piggery sludge (P.S.). For this sludge, the propionic:acetic ratio increased when the concentration of N-NH(4)(+) increased, indicating that methanogenesis was affected. Finally, a study of the microbial population involved in this study for P.S. by using 16S rRNA based molecular techniques revealed a presence of microorganisms following the order: Methanococcaceae > Methanosarcina > Methanosaeta.