Phenolic extract of Eugenia uniflora L. and furanone reduce biofilm formation by Serratia liquefaciens and increase its susceptibility to antimicrobials

Efficacy of organic peroxyacids for eliminating biofilm preformed by microorganisms isolated from dairy processing plants

The aim of this study was to evaluate the ability of microorganisms isolated from the dairy industry to form biofilms and to investigate the efficacity of organic peroxyacids (peracetic, perpropionic and perlactic acids and BioDestroy®) to eradicate those biofilms. Eighteen microorganisms were isolated from Quebec dairy processing plants that have issues associated with biofilm formation and were presumptively identified by MALDI-TOF mass spectrometry. The single-species biofilm-producing ability of the isolates was then evaluated using 96-well microplates. Eight out of eighteen (8/18) of these isolates were identified as moderate or strong biofilm producers, and ten out of eighteen (10/18) resulted as negative or weak biofilm producers. The efficacy of above-mentioned disinfectants was tested on the stronger biofilm producing bacteria using the MBEC (Minimum Biofilm Eradication Concentration) assay. After 5 min, all the disinfectants tested successfully eradicated both the single and mixed biofilms when applied following the recommended concentration. However, the efficacy of organic peroxyacids was significantly variable at lower concentrations. For example, 25 ppm of BioDestroy® were sufficient to eradicate all the biofilms, except for Pseudomonas azotoformans PFl1A. Unfortunately, microscopic observations highlighted those dead cells were still attached to the surfaces. In conclusion, our results suggest that some microorganisms found in dairy plants can produce tenacious biofilms that are, however, still susceptible to disinfectants, including organic peroxyacids. Further studies would be needed in order to confirm these observations using a dynamic method to mimic in vivo conditions. IMPORTANCE Biofilm forming microorganisms are a major issue in the food industry, including dairy industry, because of their negative impact on products quality. Biofilms are difficult to remove by clean-in-place (CIP) procedures commonly used in processing plants and may be less sensitive to sanitizers. Therefore, it is important to identify these microorganisms, in order to develop biofilm control strategies. The results gathered in the present study could contribute to this aim, even though it was carried out using only static methods.

Molecular Characterization and Biofilm Formation Study of Contaminant Bacteria Isolated from Domiaty and Hungarian Cheeses in Jeddah City

The aim was to study the microbiological quality of Domiaty and Hungarian cheeses, molecular identification and biofilm formation of some selected contaminant bacteria. Samples were collected from two M and P big markets in Jeddah City through the period from February to October 2018, nine visits for two types of natural cheese. Results showed that the total bacterial counts (CFU/ml) from Domiaty cheese from two markets (M and P) were 0.1 x 105, 8 x 105 and 1 x 10 5 CFU/ml respectively (3 visits of M market) and 4 x 106, 0.4 x 106, 6.5 x 103, 1 x 103, 0.1 x 103 and 0.1 x 103 CFU/ml respectively (six samples from 6 visits from P market). Results showed that the total bacterial counts (CFU/ml) from Hungarian cheese were 1.5 x 10 5, 1x 10 4, 11 x 10 4 and 4 x10 6 CFU/ml respectively from (4 visits of M market) and 0.18 x 104, 3 x 106, 22 x 106, 6 x 106 and 5 x 104 CFU/ml respectively (5 visits from P market).Different bacterial isolates from cheese were identified by morphology and biochemical test. Bacterial isolates from cheeses were identified by VITEK MS as follow: Serratia liquefaciens (D6-1, D6-2, D14-1, D13-1 and D13-2), and Pseudomonas fluorescens (D14-2) were isolated from Domiaty cheese while Enterococcus faecium (H11-2), Serratia liquefaciens (H15-1) and Streptococcus thermophilus (H14-1) were isolated from Hungarian cheese. Some selected bacterial isolates were identified by 16S rRNA. Isolates were belong to MK757978 (Raoultilla terrigena (D15-1)), MK757979 (Bacillus cereus (D16-1)), MK757980 (Enterococcus faecalis (H10-2)), MK757982 (Enterococcus fiscalism (H11-1)), MK757981 (Serratia liquefactions (H13-1)), MK757984 (Anoxybacillus flavithermus (H17-1). All bacterial isolates have been tested for the formation of biofilm using a Tissue Culture Plate (TCP). Results revealed 12.5% and 46.15% of high biofilm formation respectively for bacterial isolates of Domiaty and Hungarian cheeses.