In vitro and in vivo evaluation of a novel nonscrotal matrix-type transdermal delivery system of testosterone

Transdermal sampling of vitamin D3 and 25-hydroxyvitamin D3

AIM

Transdermal analysis is proposed for vitamin D₃ and its hydroxylated metabolite to overcome problems associated with blood analysis.

METHODS

Vitamin D₃ was extracted directly from skin with solid patches and liquid phases. Deuterium-labeled vitamin D₃ was added to the extraction solutions to compensate for variability and accurately determine the rate of transdermal transfer. Of the different extraction solvents tested, 50:50 octanol:isopropanol showed the best results, with an accuracy of 115% and reproducibility better than 30%.

CONCLUSION

The research shows that transdermal route can be used for analysis of vitamin D₃ in porcine skin. When microneedles are used, accurate measurements were obtained in 1 h. With intact skin, the highest accuracy was obtained when extraction was done for 2 h.

Synergic enhancing-effect of DEET and dodecylamine on the skin permeation of testosterone from a matrix-type transdermal delivery system

The synergic in vitro skin permeation enhancing-effect of N,N-diethyl-m-toluamide (DEET) and dodecylamine was investigated in order to develop a novel non-scrotal matrix-type transdermal delivery system of testosterone (TS). When DEET was loaded in DuroTak 87-2510 together with 2% TS and 3% dodecylamine, the in vitro rat skin permeation rate of TS synergistically increased as DEET concentration increased up to 0.5%. No further increase in permeation was observed thereafter and a plateau was observed up to 3.8% DEET. Moreover, compared to 0.5% DEET concentration, the addition of 3.8% of DEET in combination with 3% dodecylamine and 6% TS further increased the permeation rate of TS, and the maximum permeation rate of 11.21 microg/cm(2)/h was achieved. The in vitro skin permeation rates of TS from a transdermal delivery system of DuroTak 87-2510 containing 6% TS, 3% dodecyamine, and 3.8% DEET were in the following order: hairless mouse skin > rat skin > human cadaver skin. Assuming that a system with a surface area of 60 cm(2) is applied, the human cadaver skin permeation rate of 5.74 microg/cm(2)/h achieved in this study can be interpreted as being equivalent to delivering approximately 8. 27 mg of TS per day. Considering that the commercially available product (Testoderm TTS) for non-scrotal skin of the same surface area is designed to administer 5 mg of TS per day, the new formulation could maintain therapeutic plasma concentration of TS at a smaller surface area of 40 cm(2).