Feed premix: a difficult matrix for the accurate determination of trace elements - the outcome of IMEP-114 and IMEP-36

This paper presents the outcome of two proficiency tests (IMEP-114/36) running in parallel, which focused on the determination of total As, Cd, Pb, Hg and Sn in feed premixes. Both exercises aimed to test the performance of laboratories measuring trace elements in feed, in compliance with Directive 2002/32/EC of the European Parliament and of the Council on undesirable substances in animal feed. IMEP-114 was run for the European Union National Reference Laboratories, while IMEP-36 was open to all food control laboratories that wished to participate. In total 80 laboratories from 37 countries registered to both proficiency tests, from which 75 laboratories reported results. The test material used in this exercise was commercially available feed premix, which was processed, bottled, labelled and dispatched to participants. The performance of the participating laboratories was similar in both proficiency tests and was very good in the case of total Cd and less satisfactory for total As and total Pb. For total Sn only one-third of the participants reported results, from which 33% performed satisfactorily. Thirty-four participants reported results for total Hg, although the expert laboratories stated that the mass fraction for that measurand was below the limit of detection of the method used. An evaluation of the reasons that could be at the basis of unsatisfactory results has been carried out and is presented here.

Trace Level Determination of Polyether Ionophores in Feed

A liquid chromatography-mass spectrometric method was developed and validated to determine six polyether ionophores (lasalocid sodium, monensin sodium, salinomycin sodium, narasin, maduramicin ammonium alpha, and semduramicin sodium) in feed samples. The method developed was very straightforward, involving extraction with 84% acetonitrile of the coccidiostats from the feed samples and filtration of the raw extract prior to chromatographic analysis. Method validation included the determination of selectivity, linearity, specificity, repeatability, the limit of detection, limit of quantification, decision limit (CCα), detection capability (CCβ), and recovery. Feed samples from the Finnish national feed control programme and suspected carry-over samples from a feed manufacturer were analysed in parallel with an existing liquid chromatography method coupled with ultraviolet detection. All feed control samples were negative in LC-UV, but with the developed MS method, monensin, salinomycin, and narasin were detected at concentrations of <0.025–0.73 mg/kg, <0.025–0.027 mg/kg, and <0.025–1.6 mg/kg, respectively. In suspected carry-over samples after an output of 2.0 tonnes of unmedicated feed in the pelletizer line, the concentrations of monensin, salinomycin, and narasin varied from undetected to 16 mg/kg. In the mixer line, after 3.2 tonnes of unmedicated feed output, the concentrations of monensin, salinomycin, and narasin varied from undetected to 2.4 mg/kg.