Best Management Practices to Delay the Evolution of Bt Resistance in Lepidopteran Pests Without High Susceptibility to Bt Toxins in North America

Lethal and sublethal effects of cotton expressing single and pyramided proteins of Bacillus thuringiensis (Bt) on Helicoverpa armigera (Lepidoptera: Noctuidae), Spodoptera litura (Lepidoptera: Noctuidae), and Spodoptera frugiperda (Lepidoptera: Noctuidae)

The susceptibility to proteins from Bacillus thuringiensis (Bt) can vary among lepidopteran pest species. While Bollgard 3 cotton (BG3) effectively controls the primary pest Helicoverpa armigera (Hübner) in Australia, its effectiveness against other pests, such as Spodoptera litura (Fabricius) and Spodoptera frugiperda (J. E. Smith), is unknown. This laboratory study assessed the survival and development of H. armigera, S. litura, and S. frugiperda larvae when fed foliage from a non-transgenic cotton variety (CC) and 3 transgenic cotton varieties: Bollgard (BG1) expressing Cry1Ac, Bollgard II (BG2) expressing Cry1Ac and Cry2Ab, and Bollgard 3 (BG3) expressing Cry1Ac, Cry2Ab, and Vip3A. Pyramided Bt cotton had greater negative effects on survival and development of all species compared with CC or BG1. The proportion of H. armigera that eclosed as adults was very low when larvae fed on BG2 or BG3 compared with BG1. Eclosion rates of S. litura and S. frugiperda on BG3 were much lower compared with BG2 and BG1. This study demonstrates that BG3 has greater efficacy against a wider lepidopteran pest complex compared with previous Bt cotton products. Despite efficacy in the laboratory, S. litura larvae are reported to be surviving in BG3 fields, suggesting other factors are influencing field efficacy. As BG3 production expands across tropical northern Australia, preserving the susceptibility of S. litura and S. frugiperda to BG3 proteins is crucial. This study identifies the need for further research on field survival and resistance management strategies for secondary pest species.

Interactive effects between yields of Bt and non-Bt corn and planting dates in the southeastern United States

Transgenic corn (Zea mays L.) expressing insecticidal toxins from Bacillus thuringiensis (Bt) helps to control or suppress injury from a range of target insect pests. This study summarizes the yield benefits of Bt corn from field trials in Georgia, North Carolina, and South Carolina evaluating Bt and non-Bt corn hybrids from 2009 to 2023. For Cry1A.105 + Cry2Ab2 and Cry1Ab + Cry1F Bt corn, the percentage increase in yield between Bt and non-Bt corn hybrids did not vary significantly among years or states. Across years, the percentage increase in yield for both Bt traits relative to non-Bt corn hybrids increased with planting date, indicating that the yield benefit of planting Bt corn was greater later in the growing season. On average, Bt hybrids in both families had a significantly higher yield compared to their non-Bt pairs, with yields declining in later planting dates. Yields declined with increasing kernel injury from Helicoverpa zea (Boddie) and leaf injury from Spodoptera frugiperda (J. E. Smith) in both Bt and non-Bt hybrids. While insect pressure increased in later planted corn trials, identifying causal relationships between increases in insect damage and associated yield losses in corn is challenging given the numerous factors that influence corn yield during the season. In addition to illustrating the highly variable yield benefits of planting Bt corn, our study suggests that yield increases in Bt corn may occur more frequently than previously documented in the southeastern United States.

Clair CR. Sequential evolution of resistance by western corn rootworm to multiple Bacillus thuringiensis traits in transgenic maize

Transgenic crops that produce insecticidal toxins derived from the bacterium Bacillus thuringiensis (Bt) are grown worldwide to manage insect pests. Western corn rootworm is a serious pest of maize in the United States and is managed with Bt maize. In the United States, the commercial cultivation of a Bt crop requires an accompanying resistance-management strategy to delay the evolution of Bt resistance. One of the primary resistance-management strategies consists of non-Bt refuges along with a Bt crop that produces two Bt toxins (i.e., a pyramid) that kill the same pest species. This approach delays resistance because individuals with resistance to one toxin are killed by the second. However, if a pest species is resistant to one toxin in a pyramid, the effectiveness of a pyramid to delay resistance is compromised, potentially leading to the evolution of resistance to both toxins. Here, we apply a meta-analysis to demonstrate the sequential evolution of resistance by western corn rootworm to Bt maize producing Cry3Bb1 followed by resistance to Gpp34/Tpp35Ab1 maize, with resistance to each Bt toxin increasing in a linear manner over time. Additionally, we show that Bt-resistant western corn rootworm imposed substantial feeding injury, in the field, to maize containing a pyramid of Gpp34/Tpp35Ab1 and Cry3Bb1. To minimize the risk of sequential evolution of resistance to multiple transgenic traits, an emphasis should be placed on developing transgenic pyramids not compromised by prior resistance, and in cases where resistance is already present, larger non-Bt refuges and more diversified pest-management approaches should be applied.

Establishing best practices for insect resistance management: a new paradigm for genetically engineered toxins in cotton expressing Mpp51Aa2

Debate over resistance management tactics for genetically engineered (GE) crops expressing insecticidal toxins is not new. For several decades, researchers, regulators, and agricultural industry scientists have developed strategies to limit the evolution of resistance in populations of lepidopteran and coleopteran pests. A key attribute of many of these events was insecticide resistance management (IRM) strategies designed around a presumed high-dose expression sufficient to kill 99.5% of exposed larvae for some of the main target pests in corn, Zea mays L. and cotton, Gossypium hirsutum L. In contrast, other target pests did not meet this high-dose criterion. Similarly, the recent release of ThryvOn cotton that expresses thysanopteran and hemipteran active Mpp51Aa2.834_16 toxin is not high dose, working on a combination of behavioral and sublethal effects to suppress populations. This unique mode of control has generated considerable uncertainty about what IRM strategies will be most effective to limit field-evolved resistance to this unique spectrum of pests. The goal of this manuscript is to present several knowledge gaps that exist in proposed Mpp51Aa2 IRM plans, focusing on its activity on thrips, Frankliniella spp. Addressing these gaps will be crucial to limit resistance and preserve the benefits that this technology may provide by alleviating reliance on conventional insecticides and seed treatments. Broadly, these considerations will be important for future GE events that are non-high dose but remain valuable components of a more holistic insect management programs that integrate multiple tactics to reduce conventional insecticide use for challenging pests.

Bt Trait Efficacy Against Corn Earworm, Helicoverpa zea, (Lepidoptera: Noctuidae) for Preserving Grain Yield and Reducing Mycotoxin Contamination of Field Corn

The corn earworm, Helicoverpa zea (Boddie), causes persistent ear damage to corn grown in the southeastern United States region. Increased levels of ear damage have been associated with mycotoxin contamination in addition to yield loss. Corn hybrids expressing proteins from the Bacillus thuringiensis (Bt) may provide corn earworm control. A selection of hybrids expressing various Bt traits were evaluated in field experiments across Georgia over two years to assess their efficacy for corn earworm control, grain yield and quality protection, and grain mycotoxin mitigation. Ear damage was significantly reduced only by Bt hybrids expressing the Vip3Aa20 protein. The remaining Bt hybrids expressing Cry proteins provided only marginal control. Ear damage had a variable effect on grain yield and was not correlated with grain aflatoxin contamination. In contrast, grain fumonisin contamination was positively associated with earworm damage. These results indicate Bt hybrids that effectively reduce corn earworm damage may also assist in reducing fumonisin contamination and possibly yield loss.

Longitudinal trials illustrate interactive effects between declining Bt efficacy against Helicoverpa zea (Lepidoptera: Noctuidae) and planting dates of corn

Helicoverpa zea (Boddie) (Lepidoptera: Noctuidae) has evolved resistance to insecticidal toxins from Bacillus thuringiensis (Bt) Berliner (Bacillales: Bacillaceae) expressed in genetically engineered corn, Zea mays L. This study provides an overview of field trials from Georgia, North Carolina, and South Carolina evaluating Bt and non-Bt corn hybrids from 2009 to 2022 to show changes in susceptibility in H. zea to Bt corn. The reduction in kernel injury relative to a non-Bt hybrid averaged across planting dates generally declined over time for Cry1A.105 + Cry2Ab2 corn. In addition, there was a significant interaction with planting date used as a covariate. The reduction in kernel injury remained above 80% and did not vary with planting date from 2009 to 2014, whereas a significant decline with planting date was found in this reduction from 2015 to 2022. For Cry1Ab + Cry1F corn, the reduction in kernel injury relative to a non-Bt hybrid averaged across planting dates did not vary among years. The reduction in kernel injury significantly declined with planting date from 2012 to 2022. Kernel injury as a proxy for H. zea pressure was greater in late-planted trials in non-Bt corn hybrids. Our study showed that Bt hybrids expressing Cry1A.105 + Cry2Ab2 are now less effective in later planted trials in reducing H. zea injury; however, this was not the case during the earlier years of adoption of corn expressing these 2 toxins when resistance alleles were likely less frequent in H. zea populations. The implications for management of H. zea and for insect resistance management are discussed.

Yield analysis and corn earworm feeding in Bt and non-Bt corn hybrids across diverse locations

Corn, Zea mays L. (Poales: Poaceae), growers in the US Cotton Belt are required to plant 20% of total corn acres to non-Bt hybrids for resistance management (non-Bt refuge). Most growers do not meet this requirement, in part, because they perceive non-Bt hybrids to yield less than Bt hybrids. We planted multiple non-Bt and Bt hybrids from a single company in small-plot replicated trials at a single location from 2019 to 2023, as well as in small-plot replicated trials at multiple locations during 2022 and 2023. In the single location, we measured kernel injury from corn earworm, Helicoverpa zea Boddie (Lepidoptera: Noctuidae), and we recorded yield at all locations. In the single location trial, yields only separated among hybrids in 3 out of 5 years. In the multiple location trial, yields were variable between both years. We found that Bt hybrids tended to yield higher than non-Bt hybrids overall, but this was influenced by the inclusion of non-Bt hybrids that had a lower overall genetic yield potential in the environments we tested them in. In both tests, when hybrids were analyzed during each year, both Bt and non-Bt hybrids were among the statistically highest yielders. Our study demonstrates the importance of comparing multiple Bt and non-Bt hybrids to draw yield comparisons. This highlights the need for corn seed company breeders to put effort into improving yield for non-Bt hybrids. Hopefully this effort will translate into increased planting of non-Bt refuge corn for growers in the US Cotton Belt.

Rapid Adaptation and Interspecific Introgression in the North American Crop Pest Helicoverpa zea

Insect crop pests threaten global food security. This threat is amplified through the spread of nonnative species and through adaptation of native pests to control measures. Adaptations such as pesticide resistance can result from selection on variation within a population, or through gene flow from another population. We investigate these processes in an economically important noctuid crop pest, Helicoverpa zea, which has evolved resistance to a wide range of pesticides. Its sister species Helicoverpa armigera, first detected as an invasive species in Brazil in 2013, introduced the pyrethroid-resistance gene CYP337B3 to South American H. zea via adaptive introgression. To understand whether this could contribute to pesticide resistance in North America, we sequenced 237 H. zea genomes across 10 sample sites. We report H. armigera introgression into the North American H. zea population. Two individuals sampled in Texas in 2019 carry H. armigera haplotypes in a 4 Mbp region containing CYP337B3. Next, we identify signatures of selection in the panmictic population of nonadmixed H. zea, identifying a selective sweep at a second cytochrome P450 gene: CYP333B3. We estimate that its derived allele conferred a ∼5% fitness advantage and show that this estimate explains independently observed rare nonsynonymous CYP333B3 mutations approaching fixation over a ∼20-year period. We also detect putative signatures of selection at a kinesin gene associated with Bt resistance. Overall, we document two mechanisms of rapid adaptation: the introduction of fitness-enhancing alleles through interspecific introgression, and selection on intraspecific variation.

Exposure to Cry1 Toxins Increases Long Flight Tendency in Susceptible but Not in Cry1F-Resistant Female Spodoptera frugiperda (Lepidoptera: Noctuidae)

The fall armyworm (JE Smith) (Spodoptera frugiperda) is a polyphagous pest targeted by selected Cry and Vip3A insecticidal proteins from the bacterium Bacillus thuringiensis (Bt) that are produced in transgenic Bt corn and cotton. Available evidence suggests that sublethal larval exposure to Cry1Ac increases flight activity in adult Spodoptera spp. However, it is not known whether this effect is also observed in survivors from generally lethal exposure to Cry1Ac. Moreover, while multiple cases of field-evolved resistance to Bt proteins have been described in the native range of S. frugiperda, the effect of resistance on flight behavior has not been examined. Long-distance migratory flight capacity of S. frugiperda is of concern given its ongoing global spread and the possibility that migrants may be carrying resistance alleles against pesticides and Bt crops. In this study, we used rotational flight mills to test the effects of generally lethal exposure to Cry1Ac in susceptible and sublethal exposure in Cry1F-resistant S. frugiperda strains. The results detected altered pupal weight after larval feeding on diet containing Cry proteins, which only translated in significantly increased tendency for longer flights in female moths from the susceptible strain. This information has relevant implications when considering current models and assumptions for resistance management of Bt crops.

Relative activity of 15 bacterial strains against the larvae of Helicoverpa armigera, Spodoptera exigua, and Spodoptera litura (Lepidoptera: Noctuidae)

Crystal toxins produced by different strains of entomopathogenic Bacillus thuringiensis (Bt) have been characterized and widely applied as commercial biological pesticides owing to their excellent insecticidal properties. This study aimed to identify novel bacterial strains effective in controlling Spodoptera exigua Hübner, Helicoverpa armigera Hübner, and Spodoptera litura Fabricius. Fifteen culturable bacterial strains were isolated from 60 dead larvae (H. armigera and S. exigua) collected in the field. The biochemical characteristics and 16S rRNA sequences of these strains indicated that one strain (B7) was Lysinibacillus sp., 12 strains (B1, B3, B4, B5, B6, B8, P2, P3, P4, P5, P6, and DW) were Bt kurstaki, and P2-2 and B2 were Bacillus velezensis subsp. Laboratory bioassays indicated that strains B3, P6, B6, and P4 showed high toxicity to second-instar larvae of S. exigua, with LC50 values of 5.11, 6.74, 205.82, and 595.93 µg/ml, respectively; while the strains P5, B5, B6, and P6, were the most efficient against second-instar larvae of H. armigera with LC50 values of 725.82, 11,022.72, 1,282.90, 2,005.28, respectively, and strains DW, P3, P2, and B4 had high insecticidal activity against second-instar larvae of S. litura with LC50 values of 576.69, 1,660.96, 6,309.42, and 5,486.10 µg/ml, respectively. In conclusion, several Bt kurstaki strains with good toxicity potential were isolated and identified in this study. These strains are expected to be useful for biointensive integrated pest management programs to reduce the use of synthetic insecticides.

Inheritance and fitness cost of laboratory-selected resistance to Vip3Aa in Helicoverpa zea (Lepidoptera: Noctuidae)

The polyphagous pest Helicoverpa zea (Lepidoptera: Noctuidae) has evolved practical resistance to transgenic corn and cotton producing Cry1 and Cry2 crystal proteins from Bacillus thuringiensis (Bt) in several regions of the United States. However, the Bt vegetative insecticidal protein Vip3Aa produced by Bt corn and cotton remains effective against this pest. To advance knowledge of resistance to Vip3Aa, we selected a strain of H. zea for resistance to Vip3Aa in the laboratory. After 28 generations of continuous selection, the resistance ratio was 267 for the selected strain (GA-R3) relative to a strain not selected with Vip3Aa (GA). Resistance was autosomal and almost completely recessive at a concentration killing all individuals from GA. Declines in resistance in heterogeneous strains containing a mixture of susceptible and resistant individuals reared in the absence of Vip3Aa indicate a fitness cost was associated with resistance. Previously reported cases of laboratory-selected resistance to Vip3Aa in lepidopteran pests often show partially or completely recessive resistance at high concentrations and fitness costs. Abundant refuges of non-Bt host plants can maximize the benefits of such costs for sustaining the efficacy of Vip3Aa against target pests.

Extended Sentinel Monitoring of Helicoverpa zea Resistance to Cry and Vip3Aa Toxins in Bt Sweet Corn: Assessing Changes in Phenotypic and Allele Frequencies of Resistance

Transgenic corn and cotton that produce Cry and Vip3Aa toxins derived from Bacillus thuringiensis (Bt) are widely planted in the United States to control lepidopteran pests. The sustainability of these Bt crops is threatened because the corn earworm/bollworm, Helicoverpa zea (Boddie), is evolving a resistance to these toxins. Using Bt sweet corn as a sentinel plant to monitor the evolution of resistance, collaborators established 146 trials in twenty-five states and five Canadian provinces during 2020-2022. The study evaluated overall changes in the phenotypic frequency of resistance (the ratio of larval densities in Bt ears relative to densities in non-Bt ears) in H. zea populations and the range of resistance allele frequencies for Cry1Ab and Vip3Aa. The results revealed a widespread resistance to Cry1Ab, Cry2Ab2, and Cry1A.105 Cry toxins, with higher numbers of larvae surviving in Bt ears than in non-Bt ears at many trial locations. Depending on assumptions about the inheritance of resistance, allele frequencies for Cry1Ab ranged from 0.465 (dominant resistance) to 0.995 (recessive resistance). Although Vip3Aa provided high control efficacy against H. zea, the results show a notable increase in ear damage and a number of surviving older larvae, particularly at southern locations. Assuming recessive resistance, the estimated resistance allele frequencies for Vip3Aa ranged from 0.115 in the Gulf states to 0.032 at more northern locations. These findings indicate that better resistance management practices are urgently needed to sustain efficacy the of corn and cotton that produce Vip3Aa.

Management of Insect Pests with Bt Crops in the United States

Genetically engineered corn and cotton that produce insecticidal toxins derived from the bacterium Bacillus thuringiensis (Bt) have been used to manage insect pests in the United States and elsewhere. In some cases, this has led to regional suppression of pest populations and pest eradication within the United States, and these outcomes were associated with reductions in conventional insecticides and increased profits for farmers. In other instances, pests evolved resistance to multiple Bt traits, compromising the capacity of Bt crops to manage pests and leading to increased feeding injury to crops in the field. Several aspects of pest biology and pest-crop interactions were associated with cases where pests remained susceptible versus instances where pests evolved resistance. The viability of future transgenic traits can be improved by learning from these past outcomes. In particular, efforts should be made to delay resistance by increasing the prevalence of refuges and using integrated pest management.

High-Dose Assessment of Transgenic Insect-Resistant Maize Events against Major Lepidopteran Pests in China

Lepidopteran pests present a key problem for maize production in China. In order to develop a new strategy for the pest control, the Chinese government has issued safety certificates for insect-resistant transgenic maize, but whether these transformation events can achieve high dose levels to major target pests is still unclear. In this paper, the transformation events of DBN9936 (Bt-Cry1Ab), DBN9936 × DBN9501 (Bt-Cry1Ab + Vip3A), Ruifeng 125 (Bt-Cry1Ab/Cry2Aj), and MIR162 (Bt-Vip3A) were planted in the Huang-huai-hai summer corn region of China to evaluate the lethal effects on major lepidopteran pests, Spodoptera frugiperda, Helicoverpa armigera, Ostrinia furnacalis, Conogethes punctiferalis, Mythimna separata, Leucania loreyi, and Athetis lepigone, using an artificial diet containing lyophilized Bt maize tissue at a concentration representing a 25-fold dilution of tissue. The results showed that the corrected mortalities of DBN9936 (Bt-Cry1Ab), DBN9936 × DBN9501 (Bt-Cry1Ab + Vip3A), Ruifeng 125 (Bt-Cry1Ab/Cry2Aj), and MIR162 (Bt-Vip3A) to the seven pests were in the ranges 53.80~100%, 62.98~100%, 57.09~100%, and 41.02~100%, respectively. In summary, the events of DBN9936, DBN9936 × DBN9501, and MIR162 reached high dose levels to S. frugiperda. DBN9936 × DBN9501 only at the R1 stage reached a high dose level to H. armigera. DBN9936, DBN9936 × DBN9501, and Ruifeng 125, at most growth stages, reached high dose levels to O. furnacalis, and these three events at some stages also reached high dose levels to A. lepigone. Ruifeng 125 presented a high dose level only to C. punctiferalis. However, no transformations reached high dose levels to either M. separata or L. loreyi. This study provides a support for the breeding of high-dose varieties to different target pests, the combined application of multiple genes and the commercial regional planting of insect-resistant transgenic maize in China.

Novel genetic basis of resistance to Bt toxin Cry1Ac in Helicoverpa zea

Crops genetically engineered to produce insecticidal proteins from the bacterium Bacillus thuringiensis have advanced pest management, but their benefits are diminished when pests evolve resistance. Elucidating the genetic basis of pest resistance to Bacillus thuringiensis toxins can improve resistance monitoring, resistance management, and the design of new insecticides. Here, we investigated the genetic basis of resistance to Bacillus thuringiensis toxin Cry1Ac in the lepidopteran Helicoverpa zea, one of the most damaging crop pests in the United States. To facilitate this research, we built the first chromosome-level genome assembly for this species, which has 31 chromosomes containing 375 Mb and 15,482 predicted proteins. Using a genome-wide association study, fine-scale mapping, and RNA-seq, we identified a 250-kb quantitative trait locus on chromosome 13 that was strongly associated with resistance in a strain of Helicoverpa zea that had been selected for resistance in the field and lab. The mutation in this quantitative trait locus contributed to but was not sufficient for resistance, which implies alleles in more than one gene contributed to resistance. This quantitative trait locus contains no genes with a previously reported role in resistance or susceptibility to Bacillus thuringiensis toxins. However, in resistant insects, this quantitative trait locus has a premature stop codon in a kinesin gene, which is a primary candidate as a mutation contributing to resistance. We found no changes in gene sequence or expression consistently associated with resistance for 11 genes previously implicated in lepidopteran resistance to Cry1Ac. Thus, the results reveal a novel and polygenic basis of resistance.