Reduced concentrations of limestone and monocalcium phosphate in diets without or with microbial phytase did not influence gastric pH, fecal score, or growth performance, but reduced bone ash and serum albumin in weanling pigs

Digestibility of calcium in calcium-containing ingredients and requirements for digestible calcium by growing pigs

The concentration of Ca in plant feed ingredients is low compared with the requirement for pigs and most Ca in diets for pigs is provided by limestone and Ca phosphate. To determine digestibility values for Ca that are additive in mixed diets, the standardized total tract digestibility (STTD) of Ca needs to be calculated, and the STTD of Ca by growing pigs in most Ca-containing ingredients has been reported. Although Ca is an inexpensive nutrient compared with P and amino acids, excess Ca needs to be avoided because excess dietary Ca results in reduced P digestibility, reduced feed intake, and reduced growth performance of pigs. Recent data indicate that most diets produced for pigs in the United States and Europe contain ~0.20 percentage units more Ca than formulated, which likely is because of the use of limestone as a carrier in feed additives or as a flow agent in other ingredients. An excess of this magnitude without a corresponding excess of P will result in a reduction in daily gain of growing pigs by 50 to 100 g. Greater emphasis, therefore, needs to be placed on determining the concentration of Ca in diets for pigs. Microbial phytase increases the digestibility of both Ca and P and it is, therefore, important that the release of both Ca and P by phytase is considered in diet formulation. However, due to the relationship between Ca and P in postabsorptive metabolism, diets need to be formulated based on a ratio between digestible Ca and digestible P. To maximize average daily gain, this ratio needs to be less than 1.40:1.0 in diets for weanling pigs, and the ratio needs to be reduced as the body weight of pigs increases. In contrast, to maximize bone ash, the digestible Ca to digestible P ratio needs to increase from 1.67:1.0 in 11 to 25 kg pigs to 2.33:1.0 in finishing pigs. Gestating sows have reduced STTD and retention of Ca and P compared with growing pigs and formulation of diets for sows based on digestibility values obtained in growing pigs will result in inaccuracies in the provision of Ca and P. There is, however, a lack of data for the digestibility of Ca and P by gestating and lactating sows, and responses to microbial phytase by sows are not fully understood. There is, therefore, a need for research to generate more data in this area. In the present review, a summary of data for the digestibility of Ca in feed ingredients for pigs and estimates for the requirement for digestible Ca by growing and finishing pigs are provided.

Effect of added calcium carbonate without and with benzoic acid on weanling pig growth performance, fecal dry matter, and blood Ca and P concentrations

The objective of these studies was to determine the effects of increasing levels of calcium carbonate (CaCO₃) with and without benzoic acid on weanling pig growth performance, fecal dry matter (DM), and blood Ca and P concentrations. In experiment 1, 695 pigs (DNA Line 200 × 400, initially 5.9 ± 0.02 kg) were used in a 28 d study. Pigs were weaned at approximately 21 d of age and randomly assigned to pens and then pens were allotted to one of five dietary treatments. Treatment diets were fed from weaning (day 0) to day 14, with a common diet fed from days 14 to 28. Dietary treatments were formulated to provide 0%, 0.45%, 0.90%, 1.35%, and 1.80% added CaCO₃ at the expense of ground corn. From days 0 to 14 (treatment period), average daily gain (ADG) and G:F decreased (linear, P ≤ 0.01) as CaCO₃ increased. From days 14 to 28 (common period) and for the overall experiment (days 0 to 28), there was no evidence of differences in growth performance between treatments. For fecal DM, there was a trend (quadratic, P = 0.091) where pigs fed with the highest CaCO₃ diets had the greatest fecal DM. Experiment 2 used 360 pigs (DNA Line 200 × 400, initially 6.2 ± 0.03 kg) in a 38 d study. Upon arrival to the nursery facility, pigs were randomly assigned to pens and then pens were allotted to one of six dietary treatments. Dietary treatments were fed in three phases with treatment diets fed from days 0 to 10 and days 10 to 24, and a common phase 3 diet fed from days 24 to 38. Dietary treatments were formulated to provide 0.45%, 0.90%, and 1.35% added CaCO₃ with or without 0.5% benzoic acid (VevoVitall, DSM Nutritional Products, Parsippany, NJ) added at the expense of ground corn. There was no evidence (P > 0.05) for any CaCO₃ by benzoic acid interactions. For the experimental period (days 0 to 24), there was a tendency for benzoic acid to increase ADG (P = 0.056), average daily feed intake (ADFI; P = 0.071), and gain-to-feed ratio (G:F; linear, P = 0.014) as CaCO₃ decreased. During the common period (days 24 to 38), pigs previously fed benzoic acid had increased (P = 0.045) ADG and marginally increased (P = 0.091) ADFI. For the overall study, pigs fed benzoic acid had increased ADG (P = 0.011) and ADFI (P = 0.030), marginally increased G:F (P = 0.096) and final body weight (P = 0.059). Serum Ca decreased (linear, P < 0.001) as CaCO₃ decreased in the diet. These data show that decreasing the CaCO₃ content in the nursery diet immediately after weaning may improve ADG and G:F. Dietary addition of benzoic acid may also provide beneficial effects on ADG and ADFI, regardless of dietary Ca level.

Nutritional and Functional Roles of Phytase and Xylanase Enhancing the Intestinal Health and Growth of Nursery Pigs and Broiler Chickens

This review paper discussed the nutritional and functional roles of phytase and xylanase enhancing the intestinal and growth of nursery pigs and broiler chickens. There are different feed enzymes that are currently supplemented to feeds for nursery pigs and broiler chickens. Phytase and xylanase have been extensively studied showing consistent results especially related to enhancement of nutrient digestibility and growth performance of nursery pigs and broiler chickens. Findings from recent studies raise the hypothesis that phytase and xylanase could play functional roles beyond increasing nutrient digestibility, but also enhancing the intestinal health and positively modulating the intestinal microbiota of nursery pigs and broiler chickens. In conclusion, the supplementation of phytase and xylanase for nursery pigs and broiler chickens reaffirmed the benefits related to enhancement of nutrient digestibility and growth performance, whilst also playing functional roles benefiting the intestinal microbiota and reducing the intestinal oxidative damages. As a result, it could contribute to a reduction in the feed costs by allowing the use of a wider range of feedstuffs without compromising the optimal performance of the animals, as well as the environmental concerns associated with a poor hydrolysis of antinutritional factors present in the diets for swine and poultry.

Invited review: strategic adoption of antibiotic-free pork production: the importance of a holistic approach

The discovery of the use of antibiotics to enhance growth in the 1950s proved to be one of the most dramatic and influential in the history of animal agriculture. Antibiotics have served animal agriculture, as well as human and animal medicine, well for more than seven decades, but emerging from this tremendous success has been the phenomenon of antimicrobial resistance. Consequently, human medicine and animal agriculture are being called upon, through legislation and/or marketplace demands, to reduce or eliminate antibiotics as growth promotants and even as therapeutics. As explained in this review, adoption of antibiotic-free (ABF) pork production would represent a sea change. By identifying key areas requiring attention, the clear message of this review is that success with ABF production, also referred to as "no antibiotics ever," demands a multifaceted and multidisciplinary approach. Too frequently, the topic has been approached in a piecemeal fashion by considering only one aspect of production, such as the use of certain feed additives or the adjustment in health management. Based on the literature and on practical experience, a more holistic approach is essential. It will require the modification of diet formulations to not only provide essential nutrients and energy, but to also maximize the effectiveness of normal immunological and physiological capabilities that support good health. It must also include the selection of effective non-antibiotic feed additives along with functional ingredients that have been shown to improve the utility and architecture of the gastrointestinal tract, to improve the microbiome, and to support the immune system. This holistic approach will require refining animal management strategies, including selection for more robust genetics, greater focus on care during the particularly sensitive perinatal and post-weaning periods, and practices that minimize social and environmental stressors. A clear strategy is needed to reduce pathogen load in the barn, such as greater emphasis on hygiene and biosecurity, adoption of a strategic vaccine program and the universal adoption of all-in-all-out housing. Of course, overall health management of the herd, as well as the details of animal flows, cannot be ignored. These management areas will support the basic biology of the pig in avoiding or, where necessary, overcoming pathogen challenges without the need for antibiotics, or at least with reduced usage.

Increased microbial phytase increased phytate destruction, plasma inositol, and feed efficiency of weanling pigs, but reduced dietary calcium and phosphorus did not affect gastric pH or fecal score and reduced growth performance and bone ash

An experiment was conducted to test two hypotheses: 1) reducing dietary Ca and P reduces gastric pH and diarrhea in weanling pigs; 2) negative effects of low Ca and P on pig growth performance may be overcome if phytase is added to the diets. A total of 320 weanling pigs (6.35 ± 0.87 kg) were allotted to eight corn-soybean meal-based diets in a randomized complete block design with five pigs per pen. Two phase 1 (days 1 to 14) control diets containing 100 or 50% of total Ca and digestible P relative to the requirement, and six diets in which 500, 2,000, or 16,000 units of phytase/kg feed (FTU) were added to each control diet were formulated. Phytase was assumed to release 0.16% total Ca and 0.11% digestible P. Common diets were fed in phases 2 (days 15 to 27) and 3 (days 28 to 42). Growth performance data were recorded within each phase. Data for fecal scores and gastrointestinal pH were recorded for phase 1. Colon content (day 14), the right femur (days 14 and 42), and blood samples (days -1, 14, 27, and 42) were collected from one pig per pen. In phase 1, reducing Ca and P did not reduce gastric pH or fecal score, but pigs fed the 50% diets had reduced (P < 0.05) average daily gain (ADG) and average daily feed intake (ADFI) compared with pigs fed the 100% diets. In both 50% and 100% diets, phytase above 500 FTU increased (P < 0.05) gain:feed ratio (G:F) and tended (P < 0.10) to reduce gastric pH of pigs. From days 1 to 42, pigs fed the 50% diets tended (P < 0.10) to have reduced ADG and ADFI compared with pigs fed the 100% diets, but among the 100% diets, pigs tended (P < 0.10) to have a linear increase in G:F as phytase level increased. Pigs fed the 50% diets had reduced (P < 0.05) concentrations of inositol phosphate esters (IP) in the colon and reduced bone ash (days 14 and 42) compared with pigs fed the 100% diets. Phytase did not affect bone ash or most blood metabolites. Concentrations of IP in the colon decreased, whereas plasma inositol increased (d 14; P < 0.05) in pigs fed diets with phytase (≥ 500 FTU). In pigs fed the 100% diets, IP in the colon linearly decreased (P < 0.05), but plasma inositol linearly increased (P < 0.05) with increasing levels of phytase. In conclusion, reducing Ca and P in diets for weanling pigs did not influence gastric pH or fecal score, but compromised growth performance and bone ash. However, regardless of dietary Ca and P, high doses of phytase increased phytate degradation and inositol absorption, which consequently increased G:F of pigs.

Toward Precise Nutrient Value of Feed in Growing Pigs: Effect of Meal Size, Frequency and Dietary Fibre on Nutrient Utilisation

Simple Summary

Feed costs are the most important in swine production. Precise determination of nutritional values of pig diets can help reducing feed costs by reducing security margins for nutrients and therefore provide a more sustainable swine production. In commercial farms, pigs have free access to feed and eat with no limitation according to their natural behaviour. In contrast, during digestibility trials, pigs are restricted in their daily intake of feed, which is distributed in a limited number of meals. The number of meals per day and the amount of feed consumed daily can affect the digestibility of the nutrients, the transit time and the metabolism. To reduce feed costs, by-products are frequently added to diets. Most by-products are rich in dietary fibre, which are known to have negative effects on digestibility. Enzymes can be supplemented in the diet to counteract the negative aspects of dietary fibre, but their efficiency can vary depending on the number of meals per day and the amount of feed consumed daily.

Abstract

Nutritional values of ingredients have been and still are the subject of many studies to reduce security margins of nutrients when formulating diets to reduce feed cost. In most studies, pigs are fed a limited amount of feed in a limited number of meals that do not represent how pigs are fed in commercial farm conditions. With free access to feed, pigs follow their intrinsic feeding behaviour. Feed intake is regulated by satiety and satiation signals. Reducing the feed intake level or feeding frequency can affect digestibility and transit time and induce metabolic changes. To reduce feed costs, alternative ingredients that are frequently rich in dietary fibre are added to diets. Fibre acts on the digestion process and transit time by decreasing energy density and causing viscosity. Various analyses of fibre can be realised, and the measured fibre fraction can vary. Exogenous enzymes can be added to counteract the effect of fibre, but digestive tract conditions, influenced by meal size and frequency, can affect the efficiency of supplemented enzymes. In conclusion, the frequency and size of the meals can affect the digestibility of nutrients by modulating gastrointestinal tract conditions (pH and transit time), metabolites (glucose and short-chain fatty acids) and hormones (glucagon-like peptide 1 and peptide tyrosine tyrosine).