1
|
Oner ME. Effect of ultrasound processing on rheological properties and color of green food products. FOOD SCI TECHNOL INT 2024; 30:495-504. [PMID: 37218297 DOI: 10.1177/10820132231176872] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 05/24/2023]
Abstract
Changes in rheological behavior and physical properties of avocado dressing and green juice samples processed by ultrasound (US) technology (120 µm, 24 kHz, up to 2 min, 20 °C) were investigated. The avocado dressing followed pseudoplastic flow behavior, which had good fit to the power law model, with R2 values >0.9664. The lowest K values 3.5110, 2.4426, and 2.3228 were determined for avocado dressing samples with no treatment at 5 °C, 15 °C, and 25 °C, respectively. At the shear rate of 0.1/s, viscosity of 2 min US-treated avocado dressing increased significantly from 19.1 to 55.5 Pa.s at 5 °C, 13.08 to 36.78 Pa.s at 15 °C, and 14.55 to 26.75 Pa.s at 25 °C. Flow instability occurred in green juice after reaching shear rate of 300/s due to narrow gap in concentric cylinder; however, constant viscosity between 10 and 300/s indicated that the sample was Newtonian. Increasing temperature from 5 °C to 25 °C decreased viscosity of US-treated green juice from 2.55 to 1.50 mPa.s at the shear rate of 100/s. Color of both samples did not change after US processing, but lightness increased in green juice which denoted lighter color compared to the sample without treatment. There was no difference in pH and total soluble solids of samples. Results represent that US technology may be a good alternative in producing green liquid foods with acceptable rheological properties and color.
Collapse
Affiliation(s)
- Manolya Eser Oner
- Department of Food Engineering, Faculty of Engineering, Alanya Alaaddin Keykubat University, Alanya, Antalya, Turkey
| |
Collapse
|
2
|
Nugroho RWN, Tardy BL, Eldin SM, Ilyas RA, Mahardika M, Masruchin N. Controlling the critical parameters of ultrasonication to affect the dispersion state, isolation, and chiral nematic assembly of cellulose nanocrystals. ULTRASONICS SONOCHEMISTRY 2023; 99:106581. [PMID: 37690260 PMCID: PMC10498310 DOI: 10.1016/j.ultsonch.2023.106581] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Subscribe] [Scholar Register] [Received: 05/09/2023] [Revised: 07/09/2023] [Accepted: 08/30/2023] [Indexed: 09/12/2023]
Abstract
Cellulose nanocrystals (CNCs) are typically extracted from plants and present a range of opto-mechanical properties that warrant their use for the fabrication of sustainable materials. While their commercialization is ongoing, their sustainable extraction at large scale is still being optimized. Ultrasonication is a well-established and routinely used technology for (re-) dispersing and/or isolating plant-based CNCs without the need for additional reagents or chemical processes. Several critical ultrasonication parameters, such as time, amplitude, and energy input, play dominant roles in reducing the particle size and altering the morphology of CNCs. Interestingly, this technology can be coupled with other methods to generate moderate and high yields of CNCs. Besides, the ultrasonics treatment also has a significant impact on the dispersion state and the surface chemistry of CNCs. Accordingly, their ability to self-assemble into liquid crystals and subsequent superstructures can, for example, imbue materials with finely tuned structural colors. This article gives an overview of the primary functions arising from the ultrasonication parameters for stabilizing CNCs, producing CNCs in combination with other promising methods, and highlighting examples where the design of photonic materials using nanocrystal-based celluloses is substantially impacted.
Collapse
Affiliation(s)
- Robertus Wahyu N Nugroho
- Research Center for Biomass and Bioproducts, National Research and Innovation Agency (BRIN), Cibinong 16911, Indonesia; Collaborative Research Center for Nanocellulose between BRIN and Andalas University, Padang 25163, Indonesia.
| | - Blaise L Tardy
- Khalifa University, Department of Chemical Engineering, Abu Dhabi, United Arab Emirates; Research and Innovation Center on CO(2) and Hydrogen, Khalifa University, Abu Dhabi, United Arab Emirates.
| | - Sayed M Eldin
- Center of Research, Faculty of Engineering, Future University in Egypt, New Cairo 11835, Egypt.
| | - R A Ilyas
- Department of Chemical Engineering, Faculty of Chemical and Energy Engineering, Universiti Teknologi Malaysia (UTM), Johor 81310, Malaysia; Center for Advanced Composite Materials, Universiti Teknologi Malaysia (UTM), Johor 81310, Malaysia; Institute of Tropical Forestry and Forest Products, Universiti Putra Malaysia (UPM), Serdang 43400, Malaysia; Center of Excellence for Biomass Utilization, Universiti Malaysia Perlis, Arau 02600, Malaysia.
| | - Melbi Mahardika
- Research Center for Biomass and Bioproducts, National Research and Innovation Agency (BRIN), Cibinong 16911, Indonesia; Collaborative Research Center for Nanocellulose between BRIN and Andalas University, Padang 25163, Indonesia
| | - Nanang Masruchin
- Research Center for Biomass and Bioproducts, National Research and Innovation Agency (BRIN), Cibinong 16911, Indonesia; Collaborative Research Center for Nanocellulose between BRIN and Andalas University, Padang 25163, Indonesia
| |
Collapse
|
3
|
Manyatsi TS, Mousavi Khaneghah A, Gavahian M. The effects of ultrasound on probiotic functionality: an updated review. Crit Rev Food Sci Nutr 2023:1-18. [PMID: 37565473 DOI: 10.1080/10408398.2023.2242490] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 08/12/2023]
Abstract
The effects of ultrasound (US) on probiotics, as health-promoting microbes, have attracted the attention of researchers in fermentation and healthy food production. This paper aims to review recent advances in the application of the US for enhancing probiotic cells' activity, elaborate on the mechanisms involved, explain how probiotic-related industries can benefit from this emerging food processing technology, and discuss the perspective of this innovative approach. Data showed that US could enhance fermentation, which is increasingly used to enrich agri-food products with probiotics. Among the probiotics, recent studies focused on Lactiplantibacillus plantarum, Lactobacillus brevis, Lactococcus lactis, Lactobacillus casei, Leuconostoc mesenteroides, Bifidobacteria. These bacteria proliferated in the log phase when treated with US at relatively low-intensities. Also, this non-thermal technology increased extracellular enzymes, mainly β-galactosidase, and effectively extracted antioxidants and bioactive compounds such as phenolics, flavonoids, and anthocyanins. Accordingly, better functional and physicochemical properties of prebiotic-based foods (e.g., fermented dairy products) can be expected after ultrasonication at appropriate conditions. Besides, the US improved fermentation efficiency by reducing the production time, making probiotics more viable with lower lactose content, more oligosaccharide, and reduced unpleasant taste. Also, US can enhance the rheological characteristics of probiotic-based food by altering the acidity. Optimizing US settings is suggested to preserve probiotics viability to achieve high-quality food production and contribute to food nutrition improvement and sustainable food manufacturing.
Collapse
Affiliation(s)
- Thabani Sydney Manyatsi
- Department of Tropical Agriculture and International Cooperation, National Pingtung University of Science and Technology, Pingtung, Taiwan, ROC
| | - Amin Mousavi Khaneghah
- Department of Fruit and Vegetable Product Technology, Prof. Wacław Dąbrowski Institute of Agricultural and Food Biotechnology - State Research Institute, Warsaw, Poland
| | - Mohsen Gavahian
- Department of Food Science, National Pingtung University of Science and Technology, Pingtung, Taiwan, ROC
| |
Collapse
|
4
|
Kilic-Akyilmaz M, Kurt C, Uzunoglu T, Turkmen F, Gunes G, Erem E. Comparison of high intensity ultrasound and heat treatment for extending shelf life of a fermented milk beverage. Int Dairy J 2023. [DOI: 10.1016/j.idairyj.2023.105617] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 02/22/2023]
|
5
|
Machado MAM, Castro VS, Monteiro MLG, Bernardo YADA, Figueiredo EEDS, Conte‐Junior CA. Effect of
UVC‐LED
and ultrasound alone and combined on heat‐resistant
Escherichia coli
isolated from pasteurised milk. INT J DAIRY TECHNOL 2022. [DOI: 10.1111/1471-0307.12925] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 12/24/2022]
Affiliation(s)
- Maxsueli Aparecida Moura Machado
- Postgraduate Program in Food Science (PPGCAL) Chemistry Institute, Federal University of Rio de Janeiro (UFRJ) Rio de Janeiro 21941‐909 RJ Brazil
- Center for Food Analysis (NAL), Technological Development Support Laboratory (LADETEC) Federal University of Rio de Janeiro (UFRJ), Cidade Universitaria Rio de Janeiro 21941‐598 RJ Brazil
- Department of Biochemistry, Laboratory of Advanced Analysis in Biochemistry and Molecular Biology (LAABBM) Federal University of Rio de Janeiro (UFRJ), Cidade Universitaria Rio de Janeiro 21941‐909 RJ Brazil
| | - Vinicius Silva Castro
- University of Lethbridge, 4401 University Drive Lethbridge Lethbridge Alberta T1K 3M4 Canada
| | - Maria Lúcia Guerra Monteiro
- Center for Food Analysis (NAL), Technological Development Support Laboratory (LADETEC) Federal University of Rio de Janeiro (UFRJ), Cidade Universitaria Rio de Janeiro 21941‐598 RJ Brazil
- Department of Biochemistry, Laboratory of Advanced Analysis in Biochemistry and Molecular Biology (LAABBM) Federal University of Rio de Janeiro (UFRJ), Cidade Universitaria Rio de Janeiro 21941‐909 RJ Brazil
- Postgraduate Program in Veterinary Hygiene (PPGHV), Faculty of Veterinary Medicine Fluminense Federal University (UFF) Niterói 24230‐340 RJ Brazil
| | - Yago Alves de Aguiar Bernardo
- Center for Food Analysis (NAL), Technological Development Support Laboratory (LADETEC) Federal University of Rio de Janeiro (UFRJ), Cidade Universitaria Rio de Janeiro 21941‐598 RJ Brazil
- Department of Biochemistry, Laboratory of Advanced Analysis in Biochemistry and Molecular Biology (LAABBM) Federal University of Rio de Janeiro (UFRJ), Cidade Universitaria Rio de Janeiro 21941‐909 RJ Brazil
- Postgraduate Program in Veterinary Hygiene (PPGHV), Faculty of Veterinary Medicine Fluminense Federal University (UFF) Niterói 24230‐340 RJ Brazil
| | | | - Carlos Adam Conte‐Junior
- Postgraduate Program in Food Science (PPGCAL) Chemistry Institute, Federal University of Rio de Janeiro (UFRJ) Rio de Janeiro 21941‐909 RJ Brazil
- Center for Food Analysis (NAL), Technological Development Support Laboratory (LADETEC) Federal University of Rio de Janeiro (UFRJ), Cidade Universitaria Rio de Janeiro 21941‐598 RJ Brazil
- Department of Biochemistry, Laboratory of Advanced Analysis in Biochemistry and Molecular Biology (LAABBM) Federal University of Rio de Janeiro (UFRJ), Cidade Universitaria Rio de Janeiro 21941‐909 RJ Brazil
- Postgraduate Program in Veterinary Hygiene (PPGHV), Faculty of Veterinary Medicine Fluminense Federal University (UFF) Niterói 24230‐340 RJ Brazil
| |
Collapse
|
6
|
Silva M, Kadam MR, Munasinghe D, Shanmugam A, Chandrapala J. Encapsulation of Nutraceuticals in Yoghurt and Beverage Products Using the Ultrasound and High-Pressure Processing Technologies. Foods 2022; 11:2999. [PMID: 36230075 PMCID: PMC9564056 DOI: 10.3390/foods11192999] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 08/16/2022] [Revised: 09/09/2022] [Accepted: 09/19/2022] [Indexed: 11/17/2022] Open
Abstract
Dairy and beverage products are considered highly nutritious. The increase demand for added nutritional benefits within the food systems consumed by the consumers paves the pathway towards fortifying nutraceuticals into these products. However, nutraceuticals are highly unstable towards harsh processing conditions. In addition, the safety of dairy and beverage products plays a very important role. Therefore, various heat treatments are in practice. As the heat-treated dairy and beverage products tends to illustrate several alterations in their organoleptic characteristics and nutritional properties, the demand for alternative non-thermal processing technologies has increased extensively within the food industry. Ultrasound and high-pressure processing technologies are desirable for this purpose as well as a safe and non-destructive technology towards encapsulation of nutraceuticals into food systems. There are benefits in implementing these two technologies in the production of dairy and beverage products with encapsulants, such as manufacturing high-quality products with improved nutritional value while simultaneously enhancing the sensory characteristics such as flavour, taste, texture, and colour and attaining the microbial quality. The primary objective of this review is to provide detailed information on the encapsulation of nutraceuticals and mechanisms involved with using US and HPP technologies on producing encapsulated yoghurt and beverage products.
Collapse
Affiliation(s)
- Mayumi Silva
- School of Science, RMIT University, Bundoora, VIC 3083, Australia
- Department of Biosystems Technology, Faculty of Technology, University of Sri Jayewardenepura, Pitipana 10206, Sri Lanka
| | - Mayur Raghunath Kadam
- Food Processing Business Incubation Centre, National Institute of Food Technology, Entrepreneurship and Management, Thanjavur 613005, India
| | - Dilusha Munasinghe
- Department of Food Science and Technology, Faculty of Applied Sciences, University of Sri Jayewardenepura, Nugegoda 10250, Sri Lanka
| | - Akalya Shanmugam
- Food Processing Business Incubation Centre, National Institute of Food Technology, Entrepreneurship and Management, Thanjavur 613005, India
- Centre for Excellence in Non-Thermal Processing, National Institute of Food Technology, Entrepreneurship and Management, Thanjavur 613005, India
| | | |
Collapse
|
7
|
Wang W, Wang M, Xu C, Liu Z, Gu L, Ma J, Jiang L, Jiang Z, Hou J. Effects of Soybean Oil Body as a Milk Fat Substitute on Ice Cream: Physicochemical, Sensory and Digestive Properties. Foods 2022; 11:foods11101504. [PMID: 35627074 PMCID: PMC9141774 DOI: 10.3390/foods11101504] [Citation(s) in RCA: 12] [Impact Index Per Article: 6.0] [Reference Citation Analysis] [Abstract] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 04/28/2022] [Revised: 05/20/2022] [Accepted: 05/20/2022] [Indexed: 11/25/2022] Open
Abstract
Soybean oil body (SOB) has potential as a milk fat substitute due to its ideal emulsification, stability and potential biological activity. In this study, SOB was used as a milk fat substitute to prepare ice cream, expecting to reduce the content of saturated fatty acid and improve the quality defects of ice cream products caused by the poor stability of milk fat at low temperatures. This study investigated the effect of SOB as a milk fat substitute (the substitution amount was 10–50%) on ice cream through apparent viscosity, particle size, overrun, melting, texture, sensory and digestive properties. The results show SOB substitution for milk fat significantly increased the apparent viscosity and droplet uniformity and decreased the particle size of the ice cream mixes, indicating that there were lots of intermolecular interactions to improve ice cream stability. In addition, ice cream with 30% to 50% SOB substitution had better melting properties and texture characteristics. The ice cream with 40% SOB substitution had the highest overall acceptability. Furthermore, SOB substitution for milk fat increased unsaturated fatty acid content in ice cream and fatty acid release during digestion, which had potential health benefits for consumers. Therefore, SOB as a milk fat substitute may be an effective way to improve the nutritional value and quality characteristics of dairy products.
Collapse
Affiliation(s)
| | | | | | | | | | | | | | | | - Juncai Hou
- Correspondence: ; Tel.: +86-451-55190710
| |
Collapse
|
8
|
Advances and innovations associated with the use of acoustic energy in food processing: An updated review. INNOV FOOD SCI EMERG 2021. [DOI: 10.1016/j.ifset.2021.102863] [Citation(s) in RCA: 4] [Impact Index Per Article: 1.3] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 12/17/2022]
|
9
|
Amador-Espejo GG, Ruiz-Lopez II, Gibbens-Bandala PJ, Delgado-Macuil RJ, Ruiz-Espinosa H. Thermosonicated whey protein concentrate blends on quality attributes of reduced fat Panela cheese. ULTRASONICS SONOCHEMISTRY 2021; 76:105621. [PMID: 34144445 PMCID: PMC8217677 DOI: 10.1016/j.ultsonch.2021.105621] [Citation(s) in RCA: 1] [Impact Index Per Article: 0.3] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Download PDF] [Figures] [Subscribe] [Scholar Register] [Received: 03/30/2021] [Revised: 06/01/2021] [Accepted: 06/03/2021] [Indexed: 06/12/2023]
Abstract
Aiming at producing a reduced fat cheese (RFC) as an alternative to full-fat Panela cheese, a highly consumed fresh Mexican dairy product, thermosonication (TS) processes (24 kHz, 400 W nominal power, 2, 4 and 6 min; 50, 55 and 60 °C) were evaluated to treat WPC (80% protein) blended with reduced-fat milk (1 and 2% fat), which were later LTLT pasteurized. TS blends were compared in terms of their technological properties (water holding capacity-WPC, gel firmness- GF, color, pH and titratable acidity) with those of a regular full fat (3%) LTLT pasteurized milk used as a control. Afterwards, a regression analysis was carried out with the obtained data in order to select the most appropriate conditions for cheesemaking purposes (similar GF, higher WHC with respect to the control), minimize both fat content and TS treatment duration to minimize energy expenses. According to these restrictions, the selected conditions were 1.5% fat milk-WPC blend, TS treated at 60 °C for 120 s; 1% fat milk-WPC blend, TS treated at 50 °C for 120 s and 1% fat milk-WPC blend, 50 °C for 144 s, which allowed preparing low fat cheeses (LFCs). These TS treatments were applied in a larger scale to elaborate Panela-type LFCs comparing different technological properties (cheese yield, syneresis, water content, texture profile analysis, color and titratable acidity) with those of a full fat variety, at day 1 and during 14 days of refrigerated storage. Results showed similar texture profiles of LFC cheeses and full fat milk cheeses throughout their storage period with significant changes in composition parameters (higher moisture, protein and salt contents, with low fat percentages), syneresis, selected color parameters (hue, b*), with no observed changes in cheese yield, TA and pH during cheese storage. These promising results are encouraging to develop LFCs with no physicochemical or technological defects using novel processing techniques that may help reducing calorie consumption without compromising sensory acceptability.
Collapse
Affiliation(s)
- Genaro G Amador-Espejo
- CONACYT-Centro de Investigación en Biotecnología Aplicada, Instituto Politécnico Nacional, Ex-Hacienda San Juan Molino, Carretera Estatal Tecuexcomac-Tepetitla Km 1.5, Tlaxcala 90700, Mexico
| | - Irving I Ruiz-Lopez
- Facultad de Ingeniería Química, Benemérita Universidad Autónoma de Puebla, Av. San Claudio y 18 Sur, Ciudad Universitaria, Puebla 72570, Mexico
| | - Paola J Gibbens-Bandala
- Facultad de Ingeniería Química, Benemérita Universidad Autónoma de Puebla, Av. San Claudio y 18 Sur, Ciudad Universitaria, Puebla 72570, Mexico
| | - Raúl J Delgado-Macuil
- Centro de Investigación en Biotecnología Aplicada, Instituto Politécnico Nacional, Ex-Hacienda San Juan Molino, Carretera Estatal Tecuexcomac-Tepetitla Km 1.5, Tlaxcala 9070, Mexico
| | - Hector Ruiz-Espinosa
- Facultad de Ingeniería Química, Benemérita Universidad Autónoma de Puebla, Av. San Claudio y 18 Sur, Ciudad Universitaria, Puebla 72570, Mexico.
| |
Collapse
|