Inactivation of pathogens in single units of therapeutic fresh plasma by irradiation with ultraviolet light

Cryopreservation of apheresis platelets treated with riboflavin and UV light

BACKGROUND

Pathogen reduction technology (PRT) is increasingly used in the preparation of platelets for therapeutic transfusion. As the Czech Republic considers PRT, we asked what effects PRT may have on the recovery and function of platelets after cryopreservation (CP), which we use in both military and civilian blood settings.

STUDY DESIGN AND METHODS

16 Group O apheresis platelets units were treated with PRT (Mirasol, Terumo BCT, USA) before freezing; 15 similarly collected units were frozen without PRT as controls. All units were processed with 5-6% DMSO, frozen at - 80 °C, stored > 14 days, and reconstituted in thawed AB plasma. After reconstitution, all units were assessed for: platelet count, mean platelet volume (MPV), platelet recovery, thromboelastography, thrombin generation time, endogenous thrombin potential (ETP), glucose, lactate, pH, pO2, pCO2, HCO3, CD41, CD42b, CD62, Annexin V, CCL5, CD62P, and aggregates > 2 mm and selected units for Kunicki score.

RESULTS

PRT treated platelet units had lower platelet number (247 vs 278 ×10⁹/U), reduced thromboelastographic MA (38 vs 62 mm) and demonstrated aggregates compared to untreated platelets. Plasma coagulation functions were largely unchanged.

CONCLUSIONS

Samples from PRT units showed reduced platelet number, reduced function greater than the reduced number would cause, and aggregates. While the platelet numbers are sufficient to meet the European standard, marked platelets activation with weak clot strength suggest reduced effectiveness.

Prediction of Photolysis Kinetics of Viral Genomes under UV254 Irradiation to Estimate Virus Infectivity Loss

UV₂₅₄ irradiation disinfection is a commonly used method to inactivate pathogenic viruses in water and wastewater treatment. Model prediction method can serve as a pre-screening tool to quickly estimate the effectiveness of UV₂₅₄ irradiation on emerging or unculturable viruses. In this study, an improved prediction model was applied to estimate UV₂₅₄ photolysis kinetics of viral genomes (k_{pred, genome}) based on the genome sequences and their photoreactivity and to correlate with the experimental virus infectivity loss kinetics (k_{exp, infectivity}). The UV₂₅₄ inactivation data of 102 viruses (including 2 dsRNA, 65 ssRNA, 33 dsDNA and 2 ssDNA viruses) were collected from the published experimental data with k_{exp, infectivity} ranging from 0.016 to 3.49 cm² mJ^-1. The model had fairly good performance in predicting the virus susceptibility to UV₂₅₄ irradiation except dsRNA viruses (Pearson's correlation coefficient = 0.64) and 70% of k_{pred, genome} fell in the range of 1/2 to 2 times of k_{exp, infectivity}. The positive deviation of the model often occurred for photoresistant viruses with low k_{exp, infectivity} less than 0.20 cm² mJ^-1 (e.g., Adenovirus, Papovaviridae and Retroviridae). We also applied this model to predict the UV₂₅₄ inactivation rate of SARS-CoV-2 (k_{pred, genome} = 3.168 cm² mJ^-1) and a UV dose of 3 mJ cm^-2 seemed to be able to achieve a 2-log removal by conservative calculation using 1/2k_{pred, genome} value. This prediction method can be used as a prescreening tool to assess the effectiveness of UV₂₅₄ irradiation for emerging/unculturable viruses in water or wastewater treatment.

Spectrum of virucidal activity from ultraviolet to infrared radiation

The COVID-19 pandemic has sparked a demand for safe and highly effective decontamination techniques for both personal protective equipment (PPE) and hospital and operating rooms. The gradual lifting of lockdown restrictions warrants the expansion of these measures into the outpatient arena. Ultraviolet C (UVC) radiation has well-known germicidal properties and is among the most frequently reported decontamination techniques used today. However, there is evidence that wavelengths beyond the traditional 254 nm UVC - namely far UVC (222 nm), ultraviolet B, ultraviolet A, visible light, and infrared radiation - have germicidal properties as well. This review will cover current literature regarding the germicidal effects of wavelengths ranging from UVC through the infrared waveband with an emphasis on their activity against viruses, and their potential applicability in the healthcare setting for general decontamination during an infectious outbreak.

The effectiveness of riboflavin photochemical-mediated virus inactivation and changes in protein retention in fresh-frozen plasma treated using a flow-based treatment device

BACKGROUND

A flow-based treatment device using riboflavin and ultraviolet (UV) light was developed to inactivate viruses in fresh-frozen plasma (FFP). The objective of this study was to evaluate the in vitro effectiveness of virus inactivation and changes in protein quality in FFP treated with this device.

STUDY DESIGN AND METHODS

FFP-contaminating viruses were treated with riboflavin and UV light using a one-pass linear flow device. The infectivity of viruses was measured using established biologic assays. Real-time polymerase chain reaction (PCR) was performed to detect damage to viral nucleotides after treatment. Treated plasma was analyzed using standard coagulation assays.

RESULTS

FFP treated at the UV dose of 3.6 J/cm(2) (J) exhibited a mean reduction of virus titer of more than 4 logs. The effectiveness increased significantly at higher doses. Real-time PCR showed that the cycle threshold values for both complete inactivation and virus recultivation were higher than that of the untreated sample. At doses of 3.6, 5.4, and 7.2 J, the protein recovery rates were 60.2 ± 8.6, 46.6 ± 9.4, and 28.0 ± 1.0% for fibrinogen; 67.0 ± 3.1, 57.3 ± 8.0, and 49.2 ± 3.8% for Factor VIII; 93.6 ± 2.8, 89.6 ± 6.1, and 86.5 ± 5.3% for antithrombin-III; and 72.1 ± 5.6, 59.8 ± 14.2, and 49.2 ± 8.4% for Protein C, respectively.

CONCLUSION

The effectiveness of virus inactivation was enhanced, but total activity of plasma factors was reduced, in a UV dose-dependent manner.

Update on the use of pathogen-reduced human plasma and platelet concentrates

The use of pathogen reduction technologies (PRTs) for labile blood components is slowly but steadily increasing. While pathogen-reduced plasma is already used routinely, efficacy and safety concerns impede the widespread use of pathogen-reduced platelets. The supportive and often prophylactic nature of blood component therapy in a variety of clinical situations complicates the clinical evaluation of these novel blood products. However, an increasing body of evidence on the clinical efficacy, safety, cost-benefit ratio and development of novel technologies suggests that pathogen reduction has entered a stage of maturity that could further increase the safety margin in haemotherapy. This review summarizes the clinical evidence on PRTs for plasma and platelet products that are currently licensed or under development.

Laser-induced inactivation of Plasmodium falciparum

Background

Haemozoin crystals, produced by Plasmodium during its intra-erythrocytic asexual reproduction cycle, can generate UV light via the laser-induced, non-linear optical process of third harmonic generation (THG). In the current study the feasibility of using haemozoin, constitutively stored in the parasite’s food vacuole, to kill the parasite by irradiation with a near IR laser was evaluated.

Methods

Cultured Plasmodium parasites at different stages of development were irradiated with a pulsed NIR laser and the viability of parasites at each stage was evaluated from their corresponding growth curves using the continuous culture method. Additional testing for germicidal effects of haemozoin and NIR laser was performed by adding synthetic haemozoin crystals to Escherichia coli in suspension. Cell suspensions were then irradiated with the laser and small aliquots taken and spread on agar plates containing selective agents to determine cell viability (CFU).

Results

Parasites in the late-trophozoites form as well as trophozoites in early-stage of DNA synthesis were found to be the most sensitive to the treatment with ~4-log reduction in viability after six passes through the laser beam; followed by parasites in ring phase (~2-log reduction). A ~1-log reduction in E. coli viability was obtained following a 60 min irradiation regimen of the bacteria in the presence of 1 μM synthetic haemozoin and a ~2-log reduction in the presence of 10 μM haemozoin. Minimal (≤15%) cell kill was observed in the presence of 10 μM haemin.

Conclusions

Laser-induced third-harmonic generation by haemozoin can be used to inactivate Plasmodium. This result may have clinical implications for treating severe malaria symptoms by irradiating the patient’s blood through the skin or through dialysis tubing with a NIR laser.

Evaluation of the tolerability and immunogenicity of ultraviolet C-irradiated autologous platelets in a dog model

BACKGROUND

The THERAFLEX ultraviolet (UV) platelets (PLTs) pathogen reduction system for PLT concentrates (PCs) operates using ultraviolet C (UVC) light at a wavelength of 254 nm. UVC treatment can potentially alter proteins, which may affect drug tolerance in humans and influence the immunogenicity of blood products. This preclinical study in beagle dogs was designed to evaluate the safety pharmacology of UVC-irradiated PCs after intravenous administration and to determine whether they are capable of eliciting humoral responses to PLTs and plasma proteins.

STUDY DESIGN AND METHODS

Six beagle dogs each were transfused once every other week for 10 weeks with UVC-irradiated or nonirradiated PCs. All PCs were autologous canine single-donor products prepared from whole blood. Safety pharmacology variables were regularly assessed. The impact of UVC irradiation on PLT and plasma proteomes was analyzed by one- and two-dimensional gel electrophoresis. Serum samples were tested for UVC-induced antibodies by Western blot and flow cytometry.

RESULTS

Dogs transfused with UVC-irradiated PCs showed no signs of local or systemic intolerance. Few but significant changes in PLT protein integrity were observed after UVC irradiation. Even after repeated administration of UVC-irradiated PCs, no antibodies against UVC-exposed plasma or PLT proteins were detected.

CONCLUSIONS

Repeated transfusions of autologous UVC-treated PCs were well tolerated in all dogs studied. UVC irradiation did not cause significant plasma or PLT protein modifications capable of inducing specific antibody responses in the dogs. High-resolution proteomics combined with antibody analysis introduces a comprehensive and sensitive method for screening of protein modifications and antibodies specific for pathogen reduction treatment.

UVC Irradiation for Pathogen Reduction of Platelet Concentrates and Plasma

Besides the current efforts devoted to microbial risk reduction, pathogen inactivation technologies promise reduction of the residual risk of known and emerging infectious agents. A novel pathogen reduction process for platelets, the THERAFLEX UV-Platelets system, has been developed and is under clinical evaluation for its efficacy and safety. In addition, proof of principle has been shown for UVC treatment of plasma units. The pathogen reduction process is based on application of UVC light of a specific wavelength (254 nm) combined with intense agitation of the blood units to ensure a uniform treatment of all blood compartments. Due to the different absorption characteristics of nucleic acids and proteins, UVC irradiation mainly affects the nucleic acid of pathogens and leukocytes while proteins are largely preserved. UVC treatment significantly reduces the infectivity of platelet units contaminated by disease-causing viruses and bacteria. In addition, it inactivates residual white blood cells in the blood components while preserving platelet function and coagulation factors. Since no photoactive compound needs to be added to the blood units, photoreagent-related adverse events are excluded. Because of its simple and rapid procedure without the need to change the established blood component preparation procedures, UVC-based pathogen inactivation could easily be implemented in existing blood banking procedures.