Variations in the blood concentration of 1,1,2-trichloroethane by percutaneous absorption and other routes of administration in the guinea pig

Dermal uptake of 18 dilute aqueous chemicals: in vivo disappearance-method measures greatly exceed in vitro-based predictions

Average rates of total dermal uptake (Kup ) from short-term (e.g., bathing) contact with dilute aqueous organic chemicals (DAOCs) are typically estimated from steady-state in vitro diffusion-cell measures of chemical permeability (Kp ) through skin into receptor solution. Widely used ("PCR-vitro") methods estimate Kup by applying diffusion theory to increase Kp predictions made by a physico-chemical regression (PCR) model that was fit to a large set of Kp measures. Here, Kup predictions for 18 DAOCs made by three PCR-vitro models (EPA, NIOSH, and MH) were compared to previous in vivo measures obtained by methods unlikely to underestimate Kup . A new PCR model fit to all 18 measures is accurate to within approximately threefold (r = 0.91, p < 10(-5) ), but the PCR-vitro predictions (r > 0.63) all tend to underestimate the Kup measures by mean factors (UF, and p value for testing UF = 1) of 10 (EPA, p < 10(-6) ), 11 (NIOSH, p < 10(-8) ), and 6.2 (MH, p = 0.018). For all three PCR-vitro models, log(UF) correlates negatively with molecular weight (r(2) = 0.31 to 0.84, p = 0.017 to < 10(-6) ) but not with log(vapor pressure) as an additional predictor (p > 0.05), so vapor pressure appears not to explain the significant in vivo/PCR-vitro discrepancy. Until this discrepancy is explained, careful in vivo measures of Kup should be obtained for more chemicals, the expanded in vivo database should be compared to in vitro-based predictions, and in vivo data should be considered in assessing aqueous dermal exposure and its uncertainty.

Percutaneous absorption of 4 organic solvents in the guinea pig (II). Effect of surfactants

Percutaneous absorption of 4 organic solvents (1,1,1-trichloroethane, 1,1,2-trichloroethane, toluene and butanol) from various colloidal preparations in a surfactant-water-organic solvent system was studied in vivo in guinea pigs. The preparations examined were binary solutions of organic solvents and surfactants, o/w emulsions and microemulsions. Phase diagram, birefringence microscopy and droplet size distribution analysis were used for characterization of the preparations. It was found that skin absorption of the solvents depends on the type of surfactant, type of preparation and also on phase equilibria in the systems studied. The presence of nonionic surfactants in the solvents and in a microemulsion with butanol caused skin absorption to decrease. A reduced uptake of solvents from o/w emulsions was observed. The absorption of butanol from a microemulsion with anionic surfactant was greater than from the pure solvent.

Liquid crystals as a potential ointment vehicle

A lecithin-water lyotropic liquid crystal was used as an ointment vehicle for a hydrocortisone formulation. The hydrocortisone was soluble in the liquid crystalline phase up to 5% by weight. The diffusion coefficient determined for the hydrocortisone in the liquid crystalline phase was 5.5 X 10(-9) cm X s-1, which is four magnitudes higher than the corresponding value for skin.