Diacetyl production by Propionibacterium shermanii in milk cultures

Propionicin SM1, a bacteriocin from Propionibacterium jensenii DF1: isolation and characterization of the protein and its gene

We purified a bacteriocin from the cell-free supernatant of Propionibacterium jensenii DF1 isolated from Swiss raw milk, and named it propionicin SM1. The heat-stable protein was strongly bactericidal against P. jensenii DSM20274. On the basis of the N-terminal amino acid sequence of the purified protein, a degenerate oligonucleotide probe was designed to locate and clone the corresponding gene of P. jensenii DF1. It hybridized exclusively with the DF1l-resident plasmid pLME106, but not with chromosomal DNA. Sequencing of the 6.9-kb plasmid revealed the targeted amino acid sequence within an open reading frame (ORF4) of 207 amino acids (molecular mass, 22,865 Da). The corresponding gene was named ppnA. It encodes the prepeptide PpnA that is processed to the mature protein (19,942 Da) propionicin SM1. No sequence homology is detectable with known proteins. However, the proposed leader peptide sequence containing 27 amino acids has typical signal peptide features and shows good homology to the leader peptide of Usp45, a protein excreted from Lactococcus lactis (VAN ASSELDONK et al., 1993). Plasmid pLME106 contains at least 9 ORFs, some exhibiting significant homologies to plasmid-encoded functions from other bacteria. The highest identity values were found for ORF1 with the theta replicase (acc. no. U39878) of Brevibacterium linens (58.8%) and ORF6 with the recombinase/invertase (acc. no. AF060871) found in Rhodococcus rhodochrous (46.4%).

Paracrystalline surface layers of dairy propionibacteria

We examined 70 dairy propionibacteria and detected a crystalline surface layer (S-layer) in only 2 organisms (Propionibacterium freudenreichii CNRZ 722 and Propionibacterium jensenii CNRZ 87) by freeze-etching and sodium dodecyl sulfate-polyacrylamide electrophoresis (SDS-PAGE). Both S-layers exhibited oblique (p2) symmetry (a = 9.9 nm; b = 5.4 nm; gamma = 80 degrees) and completely covered the cell surface. Treatment for 15 min at the ambient temperature with 5 M guanidine hydrochloride or acidic conditions (250 mM ammonium acetate, pH 2.7) efficiently extracted the S-layer protein from intact cells of strain CNRZ 722, whereas treatment with 5 M guanidine hydrochloride at 100 degrees C for 15 min was necessary to isolate the S-layer protein of strain CNRZ 87. The precipitates obtained after dialysis of the extracting agents produced no regular patterns. The molecular masses of the two S-layer proteins, as estimated by SDS-PAGE, were 58.5 kDa for the strain CNRZ 722 and 67.3 kDa for the strain CNRZ 87. Mass spectrometry of the isolated S-layer protein of strain CNRZ 722 gave a molecular mass value close to the expected value (56,533 Da). The N-terminal sequences of the two purified S-layer proteins differed, as did their amino acid compositions, except that the same high hydrophobic amino acid content (52%) was observed.

Jenseniin G, a heat-stable bacteriocin produced by Propionibacterium jensenii P126

The genus Propionibacterium includes cutaneous species typically found on human skin and the dairy or classical species (Propionibacterium freudenreichii, P. jensenii, P. thoenii, and P. acidipropionici) used industrially for the production of Swiss cheese and propionic acid. Grinstead (1989, M.S. thesis, Iowa State University, Ames) has previously observed that some dairy propionibacteria inhibit other species in the classical grouping. We further investigated the inhibitor(s) produced by P. jensenii P126 (ATCC 4872). An antagonist(s) from anaerobic agar cultures of P126 strongly inhibited two closely related strains of propionibacteria, P. acidipropionici P5 and P. jensenii P54, and Lactobacillus bulgaricus NCDO 1489, Lactobacillus delbrueckii subsp. lactis ATCC 4797, Lactococcus cremoris NCDO 799, and Lactococcus lactis subsp. lactis C2. The inhibitor, designated jenseniin G, was active at pH 7.0; inactivated by treatment with pronase E, proteinase K, and type 14 protease; insensitive to catalase; and stable to freezing, cold storage (4 degrees C, 3 days), and heat (100 degrees C, 15 min). Classification of the inhibitor as a bacteriocin is supported by its proteinaceous nature and its bactericidal activity against L. delbrueckii subsp. lactis ATCC 4797. The lack of detectable plasmids suggests a chromosomal location for the determinant(s) of jenseniin G.