Preparation of 177Lu-PSMA-617 in Hospital Radiopharmacy: Convenient Formulation of a Clinical Dose Using a Single-Vial Freeze-Dried PSMA-617 Kit Developed In-House

Evaluation of acute intravenous toxicity of HEPES: Is Good's buffer good and safe enough for clinical utilization in nuclear medicine?

OBJECTIVE

Good's buffer or HEPES has advantages over other buffers commonly used in radiopharmaceutical preparation as it exhibits significantly lower complexation tendency with metal ions. However, use of HEPES buffer for radiolabeling reactions, meant for clinical applications, has been underrated due to the non-availability of sufficient toxicity data. The objective of the present study is to find the evidences towards safety of intravenous administration of HEPES through systemic toxicological studies in small animal model to support its safe application for clinical exploitation.

EXPERIMENTAL

A pilot study was performed to investigate the lethal dose of HEPES in female Sprague Dawley rats by administering seven different doses of HEPES solution (150 to 2000 mg/kg), through intravenous pathway. Similarly, for determining maximum tolerated dose (MTD), gradually increasing doses of HEPES (50 to 950 mg/kg) were administered in the same species via similar pathway. Various hematological and clinical pathological investigations were carried out in order to find out the safe administration dose of HEPES in rats.

RESULTS

No mortality was observed up to 2000 mg/kg doses of HEPES. The doses beyond 300 mg/kg resulted few temporary adverse effects, though these were found to disappear within 4-5 days of dosing.

CONCLUSION

The amount of HEPES to be administered during clinical intervention is usually much lower (typically 1-2.5 mg per kg of body weight of healthy adult) than the MTD determined in rat model during present report. Hence, the utilization of this buffer for preparation of radiolabeled drugs for human investigation may be safe. However, further detailed investigations may be warranted for supporting the candidature of Good's buffer for regular clinical exploitation.

Radiolysis-Associated Decrease in Radiochemical Purity of 177Lu-Radiopharmaceuticals and Comparison of the Effectiveness of Selected Quenchers against This Process

The radiolytic degradation of vector molecules is a major factor affecting the shelf life of therapeutic radiopharmaceuticals. The development of time-stable dosage forms of radiopharmaceuticals is the key to their successful implementation in clinical practice. Using [¹⁷⁷Lu]Lu-PSMA-617 molecule as an example, the time dependence of the change in radiochemical purity (RCP, %) under radiolysis conditions was studied. The dependence of [¹⁷⁷Lu]Lu-PSMA-617 radiolysis on parameters such as time, radionuclide activity, buffer agent concentration, precursor amount, and preparation volume was evaluated. It was shown that the absorbed dose was the dominant factor influencing the RCP. The RCP value is inversely proportional to the absorbed dose in the [¹⁷⁷Lu]Lu-PSMA-617 preparation and has an exponential dependence. The lutetium-177 dose factor ψ (Gy·mL·MBq^-1) and PSMA-617 concentration-dependent dose constant κ (Gy^-1) were evaluated for absorbed dose estimation via computer modeling, chemical dosimetry, and radiochemical purity monitoring under various conditions. The further refinement and application of the dependencies found can be useful for predicting the RCP value at the stage of optimizing the composition of the finished dosage form of therapeutic radiopharmaceuticals. The influence of the buffer agent (sodium acetate) concentration on [¹⁷⁷Lu]Lu-PSMA-617 radiolytic degradation was shown and should be considered both when developing a dosage form, and when comparing the results of independent studies. The effectiveness of the addition of various stabilizing agents, such as DMSA, cysteine, gentisic acid, vanillin, methionine, adenine, dobesilic acid, thymine, uracil, nicotinamide, meglumine, and mannitol, in suppressing the effects of radiolysis was evaluated.