A highly purified antithrombin III concentrate prepared from human plasma fraction IV-1 by affinity chromatography

We describe an improved method for large-scale purification of antithrombin III (AT-III) from human plasma involving heparin affinity chromatography of redissolved fraction IV-1 paste, viral inactivation by heating, followed by a second heparin affinity column. The characteristics of a new heparin affinity resin and the ability to extrapolate process behavior from small-scale (20 ml) to large-scale (40 liter) columns are described. This supports the use of the small-scale column for process optimization and validation studies in compliance with current regulatory requirements for biological products. The process has been characterized by analytical techniques including sodium dodecyl sulfate (SDS), reducing SDS, and nondenaturing polyacrylamide gel electrophoresis; laser desorption time-of-flight mass spectroscopy, and electrospray mass spectroscopy. These results demonstrate that greater than 95% of the protein in the final products is AT-III, which is greater than 95% active as defined by thrombin inhibition.

Sensitivity of the fibrinogen clotting time: an in vitro test of potential thrombogenicity

The fibrinogen clotting time (FCT) is a measure of thrombin activity, and is used to evaluate the potential thrombogenicity of prothrombin complex concentrates (PCC). We have defined end points for clot formation in this test which allow the measurement in PCC of thrombin concentrations as low as 0.001 IU/ml. The FCT of thrombin and PCC samples which did not contain antithrombin III (ATIII) were the same when measured at 20 degrees C or 37 degrees C. In the presence of ATIII (0.05 or 0.25 IU/ml), samples of PCC which were known to contain thrombin showed shorter FCT at 20 degrees C than at 37 degrees C. Inclusion of both ATIII (0.25 IU/ml) and heparin (4 IU/ml) in PCC ensured the complete inactivation of endogenous thrombin.

Properties of a highly purified human plasma factor IX:c therapeutic concentrate prepared by conventional chromatography

We have characterized a highly purified (HP) factor IX concentrate intended for therapy of hemophilia B. The product has been prepared from pooled human plasma using a large-scale procedure combining three conventional chromatographic steps based on DEAE ion exchange and affinity on immobilized heparin. The specific activity of the product was 119 +/- 10 IU factor IX:c/mg protein (n = 15), corresponding to a purification factor of about 9,000. The concentrate was free of the vitamin K-dependent clotting factors II, VII and X and of proteins C and S. Most of the contaminants found in factor IX complex concentrate (PCC) were absent in this new product. High-molecular-weight kininogen, factors VIII, XI, XII or prekallikrein were not detected. There were no activated factors, such as factors IXa, and Xa, no thrombin and no phospholipids. Only two contaminants could be detected: C4 and inter-alpha-trypsin inhibitor (about 0.8 and 1.2 mg/1,000 IU factor IX:c, respectively). The purity of the product, as compared to PCC, was confirmed by sodium dodecylsulfate polyacrylamide gel electrophoresis, cellulose acetate electrophoresis, Grabar-Williams immunoelectrophoresis, and bidimensional immunoelectrophoresis. Thrombogenicity tests in rabbits revealed that the HP factor IX tested had a lower thrombogenic power than the PCC tested. The concentrate has been subjected to a 0.3% tri(n-butyl) phosphate-1% Tween 80 treatment for 6h at 25 degrees C during its production to reduce or eliminate the risk of transmission of plasma-borne lipid-enveloped viruses. These conditions inactivated more than 3.8 log10 of vesicular stomatitis virus and more than 4.3 log10 of sindbis virus within 1 and 2 h of treatment, respectively.(ABSTRACT TRUNCATED AT 250 WORDS)