Effects of lubrication on air-sealing performance of a pediatric cuffed tracheal tube

[Inhalation anesthesia in the cat: Development of cuff pressure when using nitrous oxide]

OBJECTIVE

During inhalation anesthesia with nitrous oxide in oxygen the pressure in the cuff of the endotracheal tube may increase due to diffusion of nitrous oxide into the cuff. The aim of the study was to investigate the development of cuff pressure during nitrous oxide anesthesia under clinical conditions in feline patients and to identify possible influencing factors such as tube size and gas flow rate.

MATERIAL AND METHODS

The prospective study included cats scheduled for inhalation anesthesia with nitrous oxide for a minimum duration of 60 minutes at the Department for Small Animals of the University of Leipzig. Cuff pressure was adjusted with a cuff manometer and its development was recorded.

RESULTS

In total, the cuff pressure values of 24 cats were recorded. Animals were allocated into groups by tube size (ID 4.0 mm and ID 4.5 mm) and by fresh gas flow rate: low flow rate (0.6 l/min) and high flow rate (3 l/min). During anesthesia, cuff pressure increased over time, with statistical significance occurring from 45 minutes onwards in comparison to the initial cuff pressure (p=0.005). After 60 minutes, there was a mean cuff pressure increase of 3 cmH2O. Despite this moderate mean increase, highly variable pressure values up to 48 cmH2O in individual animals were recorded. No cat reached the termination criterion of 60 cmH2O cuff pressure. Effects of tube size (p=0.63) and flow rate (p=0.334) on the cuff pressure were not evident.

CONCLUSION

After a period of 45 minutes of nitrous oxide administration, a significant increase in cuff pressure occurs in the cat. However, tube size and total gas flow rate do not seem to influence the cuff pressure development.

CLINICAL RELEVANCE

When using nitrous oxide during inhalation anesthesia, regular cuff pressure evaluation and correction are necessary and hence recommended in feline patients. As individual pressure changes may be highly variable, no fixed recommendations for optimal management are possible.

The Changes of Endotracheal Tube Cuff Pressure during Manual and Intermittent Controlling in Intensive Care Units

BACKGROUND

Usually, the endotracheal tube cuff pressure is controlled by cuff pressure monitoring. However, the intermittent pilot-manometer connection and disconnection may cause a change in the adjusted pressure. This study aimed to investigate changes in the endotracheal tube cuff pressure using both manual and intermittent controls.

MATERIALS AND METHODS

A semi-experimental within-subject design was conducted. Fifty-nine intubated patients in the Mazandaran Intensive Care Units (ICUs) participated through convenience sampling in 2018. In the control condition, first, the cuff pressure was adjusted in 25 cm H2O then it was measured without manometer-pilot disconnection at 1 and 5 min intervals. In the intervention condition, cuff pressure was immediately adjusted in 25 cm H2O then it was measured with manometer-pilot disconnection in the 1st and 5th minutes. Data analysis was performed using Independent t-test, Chi-square test, and Phi coefficient.

RESULTS

The mean and Standard Deviation (SD) change of cuff pressure after 1 minute, from 25 cm H2O, in the intervention condition was 20.22 (3.53) cm H2O. The mean (SD) of this change in the control condition was 25.22 (3.39) cm H2O. This difference was significant (t 116 = 7.83, p < 0.001, d = 1.44). The mean (SD) change of cuff pressure after 5 minutes, from 25 cm H2O, in the intervention condition was 19.11 (2.98) cm H2O. The mean (SD) of this change in the control condition was 25.47 (4.53) cm H2O. This difference was significant (t 116 = 9.24, p < 0.001, d = 1.70).

CONCLUSIONS

The tracheal tube cuff pressure has been significantly reduced during manual intermittent measuring. Therefore, it is suggested that continuous cuff pressure monitoring and regulation should be used.

K-Y™ jelly inhibits increase in endotracheal tube cuff pressure during nitrous oxide exposure in vitro

BACKGROUND

The increase in endotracheal tube cuff pressure due to nitrous oxide diffusion is a well-known risk during general anesthesia using nitrous oxide. We hypothesized that lubricating endotracheal tube cuffs with K-Y™ Jelly might inhibit the increase in cuff pressure that occurs during exposure to nitrous oxide.

METHODS

We used two types of endotracheal tube cuffs: one made from ultrathin polyurethane (PU) and another made from conventional polyvinyl chloride (PVC). Using a pediatric trachea model, which consisted of an acrylic cylinder with an internal diameter of 12 mm, we measured changes in the cuff pressure during nitrous oxide exposure in size 5.0-mm internal diameter endotracheal tubes with each type of cuff, with and without lubrication with K-Y™ Jelly.

RESULTS

During nitrous oxide exposure, the increase in cuff pressure was significantly lower in the lubricated cuffs than in the non-lubricated cuffs in both types of cuffs (PVC, P < 0.0001; PU, P < 0.0001). However, the cuff compliance in the trachea model was unaffected by lubrication in both types of cuffs.

CONCLUSIONS

Lubrication of endotracheal tube cuffs with K-Y™ Jelly may effectively delay the increase in cuff pressure that occurs during general anesthesia using nitrous oxide.