Biotransformation of soy whey into a novel functional beverage by Cordyceps militaris SN-18

Stabilizing effect of Leuconostoc mesenteroides Lm10 produced dextran in situ on stirred soy yogurt: Structure-function relationship

Stirred soy yogurt as a dairy alternative is widely accepted among consumers, but its poor stability has been an urgent problem. We found that Leuconostoc mesenteroides Lm10 produced dextran reduced water mobility and improved the water holding capacity of stirred soy yogurt, especially with over 4 % sucrose added which could completely prevent whey separation. With the increase of dextran content, the particle size of stirred soy yogurt was significantly decreased, accompanied by the improvement of viscoelastic behaviors and resistance to deformation. Moreover, dextran had a stronger ability to maintain the stability of stirred soy yogurt in comparison with gelatin, xanthan and carrageenan during cold storage. The structure-function attributes of this dextran were also revealed. Dextransucrase Gtf1674 was responsible for synthesizing dextran during soy yogurt fermentation. The produced dextran was mainly composed of α-1,6 glycosidic linkages with a low-branched degree and high molecular weight. After stirring, the dextran entangled with soy protein and formed small aggregates with a dense gel structure and small pores, causing them prone to binding with water and reducing the syneresis. This study suggested the benefits of dextran produced by Leuc. mesenteroides Lm10 in stirred soy yogurt, and facilitated developing the "clean label" plant-derived products.

Exploring the Potential of Aspergillus oryzae for Sustainable Mycoprotein Production Using Okara and Soy Whey as Cost-Effective Substrates

Mycoprotein is an alternative protein produced through fungal fermentation. However, it typically relies on refined glucose syrup derived from starch, which can be costly and unsustainable. This study investigates the potential of soybean processing by-products (okara and soy whey) as alternative substrates for producing mycoprotein using Aspergillus oryzae. A. oryzae was cultured for 7 days at 30 °C in diluted okara (1:50) and soy whey (1:1) with or without agitation (100 rpm). Soy whey produced higher biomass yields (369.2-408.8 mg dry biomass/g dry substrate), but had a lower biomass concentration (0.783-0.867 g dry weight/L). Conversely, okara produced a higher biomass concentration (2.02 g dry weight/L) with a yield of 114.7 mg dry biomass/g dry substrate. However, biomass formation in okara was only observed in static conditions, as agitation caused biomass to entangle with soy pulp, hampering its production. Additionally, okara tended to release protein into the media, while soy whey accumulated protein within the biomass, reaching up to 53% w/w protein content. The results of this study provide a promising approach to addressing both soybean processing waste reduction and food security concerns.

Effect of storage on the physicochemical, rheological, antioxidant activity, and sensory properties of soy whey-fortified pineapple juice beverages

Incorporating soy whey into pineapple juice can enhance nutritional and nutraceutical potential. The present study was conducted to develop soy whey-fortified pineapple juice beverage and impact of ambient storage conditions on physicochemical, antioxidant, rheological, and sensory properties of functional beverage. Increasing the storage period decreased pH from 4.1 to 3.7 for control and 4.0 to 3.8 for soy whey-treated samples. TSS increased from 8.3 to 10.6 on 0th day for control and soy whey-treated beverage samples while on the 30th day, the TSS ranged from 8.9 to 11.1°B. Up to 30% soy whey incorporation, the DPPH, reducing power, and ABTS of beverages increased from 5.58%-57.01%, 56.35%-56.90%, and 4.84%-47.01%, respectively. The flow index (n) of the beverage formulations ranged between 0.4758 and 0.6521, and the yield stress between 0.018 and 0.025 Pa, hence showing Herschel-Bulkley character. With the increase in concentration and storage period, both G' and G″ values decreased considerably (p < .05). The standard plate and yeast and mold count decreased considerably with an increase in soy whey and increased with an increase in storage. The sensory score of the beverages up to 30% soy whey exhibited best sensory score results compared to control and samples with 30% above soy whey content.

Enrichment of Trypsin Inhibitor from Soybean Whey Wastewater Using Different Precipitating Agents and Analysis of Their Properties

Recovering valuable active substances from the by-products of agricultural processing is a crucial concern for scientific researchers. This paper focuses on the enrichment of soybean trypsin inhibitor (STI) from soybean whey wastewater using either ammonium sulfate salting or ethanol precipitation, and discusses their physicochemical properties. The results show that at a 60% ethanol content, the yield of STI was 3.983 mg/mL, whereas the yield was 3.833 mg/mL at 60% ammonium sulfate saturation. The inhibitory activity of STI obtained by ammonium sulfate salting out (A-STI) was higher than that obtained by ethanol precipitation (E-STI). A-STI exhibited better solubility than E-STI at specific temperatures and pH levels, as confirmed by turbidity and surface hydrophobicity measurements. Thermal characterization revealed that both A-STI and E-STI showed thermal transition temperatures above 90 °C. Scanning electron microscopy demonstrated that A-STI had a smooth surface with fewer pores, while E-STI had a rough surface with more pores. In conclusion, there was no significant difference in the yield of A-STI and E-STI (p < 0.05); however, the physicochemical properties of A-STI were superior to those of E-STI, making it more suitable for further processing and utilization. This study provides a theoretical reference for the enrichment of STI from soybean whey wastewater.

Engineering Escherichia coli for cost-effective production of medium-chain fatty acids from soy whey using an optimized galactose-based autoinduction system

Medium-chain fatty acids (MCFAs) are essential chemical feedstocks. Microbial production of MCFAs offers an attractive alternative to conventional methods, but the costly media and external inducers limit its practical application. To address this issue and make MCFA production more cost-effective, an E.coli platform was developed using soy whey as a medium and galactose as an autoinducer. We first designed an efficient, stringent, homogeneous, and robust galactose-based autoinduction system for the expression of pathway enzymes by rationally engineering the promoter of the galactose-proton symporter (GalP). Subsequently, the intracellular acetyl-CoA availability and NADH regeneration were enhanced to improve the reversal of the β-oxidation cycle. The resulting strain yielded 8.20 g/L and 16.42 g/L MCFA in pH-controlled batch fermentation and fed-batch fermentation with glucose added using soy whey as medium, respectively. This study provided a cost-effective and promising platform for MCFA production, as well as future strain development for other value-added chemicals production.

Tofu by-product soy whey substitutes urea: Reduced ammonia volatilization, enhanced soil fertility and improved fruit quality in cherry tomato production

Soy whey is an abundant, nutrient-rich and safe wastewater produced in tofu processing, so it is necessary to valorize it instead of discarding it as sewage. Whether soy whey can be used as a fertilizer substitute for agricultural production is unclear. In this study, the effects of soy whey serving as a nitrogen source to substitute urea on soil NH₃ volatilization, dissolved organic matter (DOM) components and cherry tomato qualities were investigated by soil column experiment. Results showed that the soil NH₄⁺-N concentrations and pH values of the 50% soy whey fertilizer combined with 50% urea (50%-SW) and 100% soy whey fertilizer (100%-SW) treatments were lower than those of 100% urea treatment (CKU). Compared with CKU, 50%-SW and 100%-SW treatments increased the abundance of ammonia oxidizing bacteria (AOB) by 6.52-100.89%, protease activity by 66.22-83.78%, the contents of total organic carbon (TOC) by 16.97-35.64%, humification index (HIX) of soil DOM by 13.57-17.99%, and average weight per fruit of cherry tomato by 13.46-18.56%, respectively. Moreover, soy whey as liquid organic fertilizer reduced the soil NH₃ volatilization by 18.65-25.27% and the fertilization cost by 25.94-51.87% compared with CKU. This study provides a promising option with economic and environmental benefits for soy whey utilization and cherry tomato production, which contributes to the win-win effectiveness of sustainable production for both the soy products industry and agriculture.