Optimization of carotenoid production by Umbelopsis ramanniana

Umbelopsis ramanniana was investigated to increase carotenoid production. Nine different carbon sources and six different nitrogen sources were evaluated for the maximum carotenoid production. The most effective nitrogen and carbon sources were KNO3 and lactose, respectively. Then, the optimization of medium components for enhancement of carotenoid production by Umbelopsis ramanniana was achieved using Plackett-Burman design. Box-Behnken response surface methodology was applied to further optimize carotenoid and biomass production. Carbon to nitrogen ratio, lactose concentration, and shaking speed were studied as variables in Box-Behnken design. The optimum conditions for carotenoid and biomass production were determined as 32.42 g/L of lactose concentration, 20:1 of carbon to nitrogen ratio, and shaking speed of 130 rpm. The maximum carotenoid and biomass production under optimized conditions were 1141 μg/L (β-carotene-Eq) and 13.14 g/L, respectively. When compared to the control fermentation, carotenoid, and biomass production were increased by about 2 and 1.3 folds, respectively.

Comparative Analysis of Different Isolated Oleaginous Mucoromycota Fungi for Their γ-Linolenic Acid and Carotenoid Production

γ-Linolenic acid (GLA) and carotenoids have attracted much interest due to their nutraceutical and pharmaceutical importance. Mucoromycota, typical oleaginous filamentous fungi, are known for their production of valuable essential fatty acids and carotenoids. In the present study, 81 fungal strains were isolated from different Egyptian localities, out of which 11 Mucoromycota were selected for further GLA and carotenoid investigation. Comparative analysis of total lipids by GC of selected isolates showed that GLA content was the highest in Rhizomucor pusillus AUMC 11616.A, Mucor circinelloides AUMC 6696.A, and M. hiemalis AUMC 6031 that represented 0.213, 0.211, and 0.20% of CDW, respectively. Carotenoid analysis of selected isolates by spectrophotometer demonstrated that the highest yield of total carotenoids (640 μg/g) was exhibited by M. hiemalis AUMC 6031 and M. hiemalis AUMC 6695, and these isolates were found to have a similar carotenoid profile with, β-carotene (65%), zeaxanthin (34%), astaxanthin, and canthaxanthin (5%) of total carotenoids. The total fatty acids of all tested isolates showed moderate antimicrobial activity against Staphylococcus aureus and Salmonella Typhi, and Penicillium chrysogenum. To the best of our knowledge, this is the first report on the highest yield of total lipid accumulation (51.74% CDW) by a new oleaginous fungal isolate R. pusillus AUMC 11616.A. A new scope for a further study on this strain will be established to optimize and improve its total lipids with high GLA production. So, R. pusillus AUMC 11616.A might be a potential candidate for industrial application.

Exploring biostimulation of plant hormones and nitrate supplement to effectively enhance biomass growth and lutein production with thermo-tolerant Desmodesmus sp. F51

In this study, the interactive effect of plant hormone-salicylic acid and succinic acid on biomass growth, lutein content, and productivity of Desmodesmus sp. F51 were investigated. The results demonstrated that the synergistic action of salicylic acid and succinic acid could effectively enhance the assimilation of nitrate and significantly improve lutein production. The maximal lutein content 7.01 mg/g and productivity 5.11 mg/L/d could be obtained with a supplement of 100 µM salicylic acid and 2.5 mM succinic acid in batch culture. Furthermore, operation strategy of nitrate fed-batch coupled with supplementation for succinic acid and salicylic acid resulted in further enhancement of lutein content and productivity by 7.50 mg/g and 5.78 mg/L/d, respectively. The performance is better than most of the previously reported values.