1
|
Adhikari BR, Gordon KC, Das SC. Solid state of inhalable high dose powders. Adv Drug Deliv Rev 2022; 189:114468. [PMID: 35917868 DOI: 10.1016/j.addr.2022.114468] [Citation(s) in RCA: 6] [Impact Index Per Article: 3.0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 05/16/2022] [Revised: 07/14/2022] [Accepted: 07/26/2022] [Indexed: 01/24/2023]
Abstract
High dose inhaled powders have received increased attention for treating lung infections. These powders can be prepared using techniques such as spray drying, spray-freeze drying, crystallization, and milling. The selected preparation technique is known to influence the solid state of the powders, which in turn can potentially modulate aerosolization and aerosolization stability. This review focuses on how and to what extent the change in solid state of high dose powders can influence aerosolization. It also discusses the commonly used solid state characterization techniques and the application of potential strategies to improve the physical and chemical stability of the amorphous powders for high dose delivery.
Collapse
Affiliation(s)
| | - Keith C Gordon
- The Dodd-Walls Centre for Photonic and Quantum Technologies, Department of Chemistry, University of Otago, Dunedin 9016, New Zealand
| | - Shyamal C Das
- School of Pharmacy, University of Otago, Dunedin 9054, New Zealand.
| |
Collapse
|
2
|
An Update on Advancements and Challenges in Inhalational Drug Delivery for Pulmonary Arterial Hypertension. Molecules 2022; 27:molecules27113490. [PMID: 35684428 PMCID: PMC9182169 DOI: 10.3390/molecules27113490] [Citation(s) in RCA: 1] [Impact Index Per Article: 0.5] [Reference Citation Analysis] [Abstract] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 03/12/2022] [Revised: 05/14/2022] [Accepted: 05/17/2022] [Indexed: 12/17/2022] Open
Abstract
A lethal condition at the arterial–alveolar juncture caused the exhaustive remodeling of pulmonary arterioles and persistent vasoconstriction, followed by a cumulative augmentation of resistance at the pulmonary vascular and, consequently, right-heart collapse. The selective dilation of the pulmonary endothelium and remodeled vasculature can be achieved by using targeted drug delivery in PAH. Although 12 therapeutics were approved by the FDA for PAH, because of traditional non-specific targeting, they suffered from inconsistent drug release. Despite available inhalation delivery platforms, drug particle deposition into the microenvironment of the pulmonary vasculature and the consequent efficacy of molecules are influenced by pathophysiological conditions, the characteristics of aerosolized mist, and formulations. Uncertainty exists in peripheral hemodynamics outside the pulmonary vasculature and extra-pulmonary side effects, which may be further exacerbated by underlying disease states. The speedy improvement of arterial pressure is possible via the inhalation route because it has direct access to pulmonary arterioles. Additionally, closed particle deposition and accumulation in diseased tissues benefit the restoration of remolded arterioles by reducing fallacious drug deposition in other organs. This review is designed to decipher the pathological changes that should be taken into account when targeting the underlying pulmonary endothelial vasculature, especially with regard to inhaled particle deposition in the alveolar vasculature and characteristic formulations.
Collapse
|
3
|
Adhikari BR, Sinha S, Gordon KC, Das SC. Amino Acids Improve Aerosolization and Chemical Stability of Potential Inhalable Amorphous Spray-dried Ceftazidime for Pseudomonas aeruginosa Lung Infection. Int J Pharm 2022; 621:121799. [PMID: 35525472 DOI: 10.1016/j.ijpharm.2022.121799] [Citation(s) in RCA: 8] [Impact Index Per Article: 4.0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 01/18/2022] [Revised: 04/26/2022] [Accepted: 04/30/2022] [Indexed: 11/30/2022]
Abstract
Pseudomonas aeruginosa infection is common in cystic fibrosis as well non-cystic fibrosis bronchiectasis. The pathogen presents challenges for treatment due to its adaptive antibiotic-resistance, mainly pertaining to its biofilm-forming ability, as well as limitations associated with conventional drug delivery in achieving desired therapeutic concentration in the infection site. Hence, therapeutic approach has shifted towards the inhalation of antibiotics. Ceftazidime is a potent antibiotic against the pathogen; however, it is currently only available as a parenteral formulation. Here, spray-dryer was employed to generate inhalable high dose ceftazidime microparticles. In addition, the use of amino acids (valine, leucine, methionine, phenylalanine, and tryptophan) to improve aerosolization as well as chemical stability of amorphous ceftazidime was explored. The particles were characterized using X ray diffraction, infrared (IR) spectroscopy, calorimetry, electron microscopy, particle size analyzer, and next generation impactor. The chemical stability at 25 °C/<15% was assessed using chromatography. All co-spray dried formulations were confirmed as monophasic amorphous systems using calorimetry. In addition, principal component analysis of the IR spectra suggested potential interaction between tryptophan and ceftazidime in the co-amorphous matrix. Inclusion of amino acids improved aerosolization and chemical stability in all cases. Increase in surface asperity was clear with the use of amino acids which likely contributed to the improved aerosol performance, and potential interaction between amino acids and ceftazidime was plausibly the reason for improved chemical stability. Leucine offered the best aerosolization enhancement with a fine particle fraction of 78% and tryptophan showed stabilizing superiority by reducing chemical degradation by 51% over 10 weeks in 1:1 molar ratio. The protection against ceftazidime degradation varied with the nature of amino acids. Additionally, there was a linear relationship between degradation protection and molar mass of amino acids or percentage weight of amino acids in the formulations. None of the amino acids were successful in completely inhibiting degradation of ceftazidime in amorphous spray-dried powder to prepare a commercially viable product with desired shelf-life. All the amino acids and ceftazidime were non-toxic to A549 alveolar cell line.
Collapse
Affiliation(s)
| | - Shubhra Sinha
- School of Pharmacy, University of Otago, Dunedin 9054, New Zealand
| | - Keith C Gordon
- The Dodd-Walls Centre for Photonic and Quantum Technologies, Department of Chemistry, University of Otago, Dunedin 9016, New Zealand
| | - Shyamal C Das
- School of Pharmacy, University of Otago, Dunedin 9054, New Zealand.
| |
Collapse
|
4
|
Alhajj N, O'Reilly NJ, Cathcart H. Developing ciprofloxacin dry powder for inhalation: A story of challenges and rational design in the treatment of cystic fibrosis lung infection. Int J Pharm 2021; 613:121388. [PMID: 34923051 DOI: 10.1016/j.ijpharm.2021.121388] [Citation(s) in RCA: 6] [Impact Index Per Article: 2.0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 10/24/2021] [Revised: 12/08/2021] [Accepted: 12/12/2021] [Indexed: 12/11/2022]
Abstract
Cystic fibrosis (CF) is an inherited multisystem disease affecting the lung which leads to a progressive decline in lung function as a result of malfunctioning mucociliary clearance and subsequent chronic bacterial infections. Pseudomonas aeruginosa is the predominant cause of lung infection in CF patients and is associated with significant morbidity and mortality. Thus, antibiotic therapy remains the cornerstone of the treatment of CF. Pulmonary delivery of antibiotics for lung infections significantly reduces the required dose and the associated systemic side effects while improving therapeutic outcomes. Ciprofloxacin is one of the most widely used antibiotics against P. aeruginosa and the most effective fluoroquinolone. However, in spite of the substantial amount of research aimed at developing ciprofloxacin powder for inhalation, none of these formulations has been commercialized. Here, we present an integrated view of the diverse challenges associated with delivering ciprofloxacin dry particles to the lungs of CF patients and the rationales behind recent formulations of ciprofloxacin dry powder for inhalation. This review will discuss the challenges in developing ciprofloxacin powder for inhalation along with the physiological and pathophysiological challenges such as ciprofloxacin lung permeability, overproduction of viscous mucus and bacterial biofilms. The review will also discuss the current and emerging particle engineering approaches to overcoming these challenges. By doing so, we believe the review will help the reader to understand the current limitations in developing an inhalable ciprofloxacin powder and explore new opportunities of rational design strategies.
Collapse
Affiliation(s)
- Nasser Alhajj
- Pharmaceutical and Molecular Biotechnology Research Centre (PMBRC), Waterford Institute of Technology, Waterford, Ireland.
| | - Niall J O'Reilly
- Pharmaceutical and Molecular Biotechnology Research Centre (PMBRC), Waterford Institute of Technology, Waterford, Ireland; SSPC - The Science Foundation Ireland Research Centre for Pharmaceuticals, Ireland
| | - Helen Cathcart
- Pharmaceutical and Molecular Biotechnology Research Centre (PMBRC), Waterford Institute of Technology, Waterford, Ireland
| |
Collapse
|
5
|
Brunaugh AD, Sharma S, Smyth H. Inhaled fixed-dose combination powders for the treatment of respiratory infections. Expert Opin Drug Deliv 2021; 18:1101-1115. [PMID: 33632051 DOI: 10.1080/17425247.2021.1886074] [Citation(s) in RCA: 7] [Impact Index Per Article: 2.3] [Reference Citation Analysis] [Abstract] [Key Words] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 12/28/2022]
Abstract
INTRODUCTION Respiratory infections are a major cause of morbidity and mortality. As an alternative to systemic drug administration, inhaled drug delivery can produce high drug concentrations in the lung tissue to overcome resistant bacteria. The development of inhaled fixed-dose combination powders (I-FDCs) is promising next step in this field, as it would enable simultaneous drug-drug or drug-adjuvant delivery at the site of infection, thereby promoting synergistic activity and improving patient compliance. AREAS COVERED This review covers the clinical and pharmaceutical rationales for the development of I-FDCs for the treatment of respiratory infections, relevant technologies for particle and powder generation, and obstacles which must be addressed to achieve regulatory approval. EXPERT OPINION I-FDCs have been widely successful in the treatment of asthma and chronic obstructive pulmonary disease; however, application of I-FDCs towards the treatment of respiratory infections carries additional challenges related to the high dose requirements and physicochemical characteristics of anti-infective drugs. At present, co-spray drying is an especially promising approach for the development of composite fixed-dose anti-infective particles for inhalation. Though the majority of fixed-dose research has thus far focused on the combination of multiple antibiotics, future work may shift to the additional inclusion of immunomodulatory agents or repurposed non-antibiotics.
Collapse
Affiliation(s)
| | - Shivam Sharma
- Department of Pharmacy & Pharmacology, University of Bath, Bath, UK
| | - Hugh Smyth
- College of Pharmacy, University of Texas at Austin, Austin, USA
| |
Collapse
|
6
|
Synergistic antibacterial effect of inhaled aztreonam and tobramycin fixed dose combination to combat multidrug-resistant Gram-negative bacteria. Int J Pharm 2020; 590:119877. [PMID: 32927003 DOI: 10.1016/j.ijpharm.2020.119877] [Citation(s) in RCA: 6] [Impact Index Per Article: 1.5] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 06/17/2020] [Revised: 08/22/2020] [Accepted: 09/08/2020] [Indexed: 11/23/2022]
Abstract
The limited therapeutic option for respiratory infections caused by multi-drug resistant microbial pathogens is a major global health threat. Topical delivery of antibacterial combinations to the lung could dramatically enhance antibacterial activities and provide a means to overcome bacterial resistance development. The aim of the study was to investigate the potential of new inhalable dry powder combinations consisting of a fixed dose of aztreonam (Azt) and tobramycin (Tob) using a spray drying process, against antibiotic resistant Gram-negative respiratory pathogens. The interactions of Azt with Tob on resistant Pseudomonas aeruginosa, Klebsiella pneumoniae and Acinetobacter baumannii were determined by calculating factional inhibitory concentration indices (FICI). A fixed concentration ratio of Azt and Tob that exhibited a synergistic antimicrobial effect was selected and formulated into inhalable dry powders by co-spray drying with and without L-leucine. The obtained dry powders were characterized with respect to the morphology, particle size distribution, solid state, moisture sorption behaviour, and in vitro dissolution. Storage stability, aerosol performance, and in vitro antibacterial activity were also evaluated. Inhalable dry powders consisting of Azt, Tob and L-leucine could be readily obtained via the spray drying process with a fine particle fraction of above 40% as determined using a next generation impactor. The co-spray drying process resulted in amorphous Azt/Tob dry powders with or without the addition of L-leucine as indicated by X-ray powder diffraction. The dissolution rates of the co-spray dried Azt/Tob dry powders were decreased, and the storage stability was improved with an increase in the proportion of L-leucine in the formulations. The inclusion of L-leucine did not affect the minimum inhibitory concentration and the co-spray dried powders reserved the synergistic antibacterial effects and exhibited enhanced antibacterial activities as compared to the individual antibiotic used alone on multidrug-resistant (Azt and Tob resistant) P. aeruginosa 25756 and A. baumannii K31. This study demonstrates that inhalable Azt/Tob dry powders using L-leucine as a moisture protector as well as a dispersing agent can be readily prepared by the spray drying process. This new inhalable fixed dose combinational dry powders may represent an alternative treatment against multidrug-resistant Gram-negative respiratory pathogens.
Collapse
|
7
|
Ubale RV, Shastri PN, Oettinger C, D’Souza MJ. Pulmonary Administration of Microparticulate Antisense Oligonucleotide (ASO) for the Treatment of Lung Inflammation. AAPS PharmSciTech 2018; 19:1908-1919. [PMID: 29663290 DOI: 10.1208/s12249-018-1002-7] [Citation(s) in RCA: 3] [Impact Index Per Article: 0.5] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 09/12/2017] [Accepted: 03/19/2018] [Indexed: 01/01/2023] Open
Abstract
Targeted delivery to the lung for controlling lung inflammation is an area that we have explored in this study. The purpose was to use microparticles containing an antisense oligonucleotide (ASO) to NF-κB to inhibit the production of proinflammatory cytokines. Microparticles were prepared using the B-290 Buchi Spray Dryer using albumin as the microparticle matrix. Physicochemical characterization of the microparticles showed the size ranged from 2 to 5 μm, the charge was - 38.4 mV, and they had a sustained release profile over 72 h. Uptake of FITC-labeled ASO-loaded microparticles versus FITC-labeled ASO solution by RAW264.7 murine macrophage cells was 5-10-fold higher. After pulmonary delivery of microparticles to Sprague-Dawley rats, the microparticles were uniformly distributed throughout the lung and were retained in the lungs until 48 h. Serum cytokine (TNF-α and IL-1β) levels of rats after induction of lung inflammation by lipopolysaccharide were measured until 72 h. Animals receiving ASO-loaded microparticles were successful in significantly controlling lung inflammation during this period as compared to animals receiving no treatment. This study was successful in proving that microparticulate ASO therapy was capable of controlling lung inflammation.
Collapse
|
8
|
Wenzler E, Fraidenburg DR, Scardina T, Danziger LH. Inhaled Antibiotics for Gram-Negative Respiratory Infections. Clin Microbiol Rev 2016; 29:581-632. [PMID: 27226088 PMCID: PMC4978611 DOI: 10.1128/cmr.00101-15] [Citation(s) in RCA: 75] [Impact Index Per Article: 9.4] [Reference Citation Analysis] [Abstract] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/20/2022] Open
Abstract
Gram-negative organisms comprise a large portion of the pathogens responsible for lower respiratory tract infections, especially those that are nosocomially acquired, and the rate of antibiotic resistance among these organisms continues to rise. Systemically administered antibiotics used to treat these infections often have poor penetration into the lung parenchyma and narrow therapeutic windows between efficacy and toxicity. The use of inhaled antibiotics allows for maximization of target site concentrations and optimization of pharmacokinetic/pharmacodynamic indices while minimizing systemic exposure and toxicity. This review is a comprehensive discussion of formulation and drug delivery aspects, in vitro and microbiological considerations, pharmacokinetics, and clinical outcomes with inhaled antibiotics as they apply to disease states other than cystic fibrosis. In reviewing the literature surrounding the use of inhaled antibiotics, we also highlight the complexities related to this route of administration and the shortcomings in the available evidence. The lack of novel anti-Gram-negative antibiotics in the developmental pipeline will encourage the innovative use of our existing agents, and the inhaled route is one that deserves to be further studied and adopted in the clinical arena.
Collapse
Affiliation(s)
- Eric Wenzler
- University of Illinois at Chicago, College of Pharmacy, Chicago, Illinois, USA
| | - Dustin R Fraidenburg
- Department of Medicine, Division of Pulmonary, Critical Care, Sleep and Allergy Medicine, University of Illinois at Chicago, Chicago, Illinois, USA
| | - Tonya Scardina
- Loyola University Medical Center, Chicago, Illinois, USA
| | - Larry H Danziger
- University of Illinois at Chicago, College of Pharmacy, Chicago, Illinois, USA University of Illinois at Chicago, College of Medicine, Chicago, Illinois, USA
| |
Collapse
|
9
|
Stockmann C, Roberts JK, Yellepeddi VK, Sherwin CMT. Clinical pharmacokinetics of inhaled antimicrobials. Clin Pharmacokinet 2016; 54:473-92. [PMID: 25735634 DOI: 10.1007/s40262-015-0250-x] [Citation(s) in RCA: 13] [Impact Index Per Article: 1.6] [Reference Citation Analysis] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/29/2022]
Abstract
Administration of inhaled antimicrobials affords the ability to achieve targeted drug delivery into the respiratory tract, rapid entry into the systemic circulation, high bioavailability and minimal metabolism. These unique pharmacokinetic characteristics make inhaled antimicrobial delivery attractive for the treatment of many pulmonary diseases. This review examines recent pharmacokinetic trials with inhaled antibacterials, antivirals and antifungals, with an emphasis on the clinical implications of these studies. The majority of these studies revealed evidence of high antimicrobial concentrations in the airway with limited systemic exposure, thereby reducing the risk of toxicity. Sputum pharmacokinetics varied widely, which makes it challenging to interpret the result of sputum pharmacokinetic studies. Many no vel inhaled antimicrobial therapies are currently under investigation that will require detailed pharmacokinetic studies, including combination inhaled antimicrobial therapies, inhaled nanoparticle formulations of several antibacterials, inhaled non-antimicrobial adjuvants, inhaled antiviral recombinant protein therapies and semi-synthetic inhaled antifungal agents. Additionally, the development of new inhaled delivery devices, particularly for mechanically ventilated patients, will result in a pressing need for additional pharmacokinetic studies to identify optimal dosing regimens.
Collapse
Affiliation(s)
- Chris Stockmann
- Division of Clinical Pharmacology, Department of Paediatrics, University of Utah School of Medicine, 295 Chipeta Way, Salt Lake City, UT, 84108, USA
| | | | | | | |
Collapse
|
10
|
Zhou QT, Leung SSY, Tang P, Parumasivam T, Loh ZH, Chan HK. Inhaled formulations and pulmonary drug delivery systems for respiratory infections. Adv Drug Deliv Rev 2015; 85:83-99. [PMID: 25451137 DOI: 10.1016/j.addr.2014.10.022] [Citation(s) in RCA: 157] [Impact Index Per Article: 17.4] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 08/27/2014] [Revised: 10/15/2014] [Accepted: 10/18/2014] [Indexed: 11/16/2022]
Abstract
Respiratory infections represent a major global health problem. They are often treated by parenteral administrations of antimicrobials. Unfortunately, systemic therapies of high-dose antimicrobials can lead to severe adverse effects and this calls for a need to develop inhaled formulations that enable targeted drug delivery to the airways with minimal systemic drug exposure. Recent technological advances facilitate the development of inhaled anti-microbial therapies. The newer mesh nebulisers have achieved minimal drug residue, higher aerosolisation efficiencies and rapid administration compared to traditional jet nebulisers. Novel particle engineering and intelligent device design also make dry powder inhalers appealing for the delivery of high-dose antibiotics. In view of the fact that no new antibiotic entities against multi-drug resistant bacteria have come close to commercialisation, advanced formulation strategies are in high demand for combating respiratory 'super bugs'.
Collapse
Affiliation(s)
- Qi Tony Zhou
- Advanced Drug Delivery Group, Faculty of Pharmacy, The University of Sydney, Sydney, NSW 2006, Australia
| | - Sharon Shui Yee Leung
- Advanced Drug Delivery Group, Faculty of Pharmacy, The University of Sydney, Sydney, NSW 2006, Australia
| | - Patricia Tang
- Advanced Drug Delivery Group, Faculty of Pharmacy, The University of Sydney, Sydney, NSW 2006, Australia
| | - Thaigarajan Parumasivam
- Advanced Drug Delivery Group, Faculty of Pharmacy, The University of Sydney, Sydney, NSW 2006, Australia
| | - Zhi Hui Loh
- GEA-NUS Pharmaceutical Processing Research Laboratory, Department of Pharmacy, National University of Singapore, 18 Science Drive 4, Singapore 117543, Singapore
| | - Hak-Kim Chan
- Advanced Drug Delivery Group, Faculty of Pharmacy, The University of Sydney, Sydney, NSW 2006, Australia.
| |
Collapse
|
11
|
Chan JGY, Wong J, Zhou QT, Leung SSY, Chan HK. Advances in device and formulation technologies for pulmonary drug delivery. AAPS PharmSciTech 2014; 15:882-97. [PMID: 24728868 DOI: 10.1208/s12249-014-0114-y] [Citation(s) in RCA: 50] [Impact Index Per Article: 5.0] [Reference Citation Analysis] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 01/14/2014] [Accepted: 03/13/2014] [Indexed: 12/31/2022] Open
Abstract
Inhaled pharmaceuticals are formulated and delivered differently according to the therapeutic indication. However, specific device-formulation coupling is often fickle, and new medications or indications also demand new strategies. The discontinuation of chlorofluorocarbon propellants has seen replacement of older metered dose inhalers with dry powder inhaler formulations. High-dose dry powder inhalers are increasingly seen as an alternative dosage form for nebulised medications. In other cases, new medications have completely bypassed conventional inhalers and been formulated for use with unique inhalers such as the Staccato® device. Among these different devices, integration of software and electronic assistance has become a shared trend. This review covers recent device and formulation advances that are forming the current landscape of inhaled therapeutics.
Collapse
|
12
|
Sosnik A, Carcaboso AM. Nanomedicines in the future of pediatric therapy. Adv Drug Deliv Rev 2014; 73:140-61. [PMID: 24819219 DOI: 10.1016/j.addr.2014.05.004] [Citation(s) in RCA: 39] [Impact Index Per Article: 3.9] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 06/29/2013] [Revised: 04/16/2014] [Accepted: 05/01/2014] [Indexed: 01/02/2023]
Abstract
Nanotechnology has become a key tool to overcome the main (bio)pharmaceutical drawbacks of drugs and to enable their passive or active targeting to specific cells and tissues. Pediatric therapies usually rely on the previous clinical experience in adults. However, there exists scientific evidence that drug pharmacokinetics and pharmacodynamics in children differ from those in adults. For example, the interaction of specific drugs with their target receptors undergoes changes over the maturation of the different organs and systems. A similar phenomenon is observed for toxicity and adverse effects. Thus, it is clear that the treatment of disease in children cannot be simplified to the direct adjustment of the dose to the body weight/surface. In this context, the implementation of innovative technologies (e.g., nanotechnology) in the pediatric population becomes extremely challenging. The present article overviews the different attempts to use nanotechnology to treat diseases in the pediatric population. Due to the relevance, though limited available literature on the matter, we initially describe from preliminary in vitro studies to preclinical and clinical trials aiming to treat pediatric infectious diseases and pediatric solid tumors by means of nanotechnology. Then, the perspectives of pediatric nanomedicine are discussed.
Collapse
Affiliation(s)
- Alejandro Sosnik
- Department of Materials Science and Engineering, Technion-Israel Institute of Technology, Technion City, Haifa 32000, Israel.
| | - Angel M Carcaboso
- Preclinical Therapeutics and Drug Delivery Research Program, Department of Oncology, Hospital Sant Joan de Déu Barcelona, Esplugues de Llobregat, Barcelona 08950, Spain
| |
Collapse
|
13
|
Kirkby S, Novak K, McCoy K. Update on antibiotics for infection control in cystic fibrosis. Expert Rev Anti Infect Ther 2014; 7:967-80. [DOI: 10.1586/eri.09.82] [Citation(s) in RCA: 12] [Impact Index Per Article: 1.2] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 12/23/2022]
|
14
|
Hoppentocht M, Hagedoorn P, Frijlink H, de Boer A. Developments and strategies for inhaled antibiotic drugs in tuberculosis therapy: A critical evaluation. Eur J Pharm Biopharm 2014; 86:23-30. [DOI: 10.1016/j.ejpb.2013.10.019] [Citation(s) in RCA: 42] [Impact Index Per Article: 4.2] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 05/23/2013] [Revised: 10/21/2013] [Accepted: 10/28/2013] [Indexed: 01/17/2023]
|
15
|
Gaspar MC, Couet W, Olivier JC, Pais AACC, Sousa JJS. Pseudomonas aeruginosa infection in cystic fibrosis lung disease and new perspectives of treatment: a review. Eur J Clin Microbiol Infect Dis 2013; 32:1231-52. [DOI: 10.1007/s10096-013-1876-y] [Citation(s) in RCA: 70] [Impact Index Per Article: 6.4] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 01/15/2013] [Accepted: 04/01/2013] [Indexed: 12/20/2022]
|
16
|
Lee SH, Teo J, Heng D, Ng WK, Chan HK, Tan RB. Synergistic combination dry powders for inhaled antimicrobial therapy: Formulation, characterization and in vitro evaluation. Eur J Pharm Biopharm 2013; 83:275-84. [DOI: 10.1016/j.ejpb.2012.09.002] [Citation(s) in RCA: 28] [Impact Index Per Article: 2.5] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 06/21/2012] [Revised: 08/27/2012] [Accepted: 09/05/2012] [Indexed: 11/28/2022]
|
17
|
Sagiri SS, Sethy J, Pal K, Banerjee I, Pramanik K, Maiti TK. Encapsulation of vegetable organogels for controlled delivery applications. Des Monomers Polym 2012. [DOI: 10.1080/15685551.2012.747154] [Citation(s) in RCA: 22] [Impact Index Per Article: 1.8] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 10/27/2022] Open
Affiliation(s)
- Sai Sateesh Sagiri
- a Soft Materials & Medical Instrumentation Laboratory, Department of Biotechnology & Medical Engineering , National Institute of Technology , Rourkela-769008, Odisha , India
| | - Jyotirmoy Sethy
- a Soft Materials & Medical Instrumentation Laboratory, Department of Biotechnology & Medical Engineering , National Institute of Technology , Rourkela-769008, Odisha , India
| | - Kunal Pal
- a Soft Materials & Medical Instrumentation Laboratory, Department of Biotechnology & Medical Engineering , National Institute of Technology , Rourkela-769008, Odisha , India
| | - Indranil Banerjee
- b Tissue Engineering Group, Department of Biotechnology & Medical Engineering , National Institute of Technology , Rourkela-769008, Odisha , India
| | - Krishna Pramanik
- b Tissue Engineering Group, Department of Biotechnology & Medical Engineering , National Institute of Technology , Rourkela-769008, Odisha , India
| | - Tapas K. Maiti
- c Department of Biotechnology , Indian Institute of Technology , WB-721302, Kharagpur , India
| |
Collapse
|
18
|
Lactose characteristics and the generation of the aerosol. Adv Drug Deliv Rev 2012; 64:233-56. [PMID: 21616107 DOI: 10.1016/j.addr.2011.05.003] [Citation(s) in RCA: 148] [Impact Index Per Article: 12.3] [Reference Citation Analysis] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 11/23/2010] [Revised: 04/27/2011] [Accepted: 05/06/2011] [Indexed: 11/23/2022]
Abstract
The delivery efficiency of dry-powder products for inhalation is dependent upon the drug formulation, the inhaler device, and the inhalation technique. Dry powder formulations are generally produced by mixing the micronised drug particles with larger carrier particles. These carrier particles are commonly lactose. The aerosol performance of a powder is highly dependent on the lactose characteristics, such as particle size distribution and shape and surface properties. Because lactose is the main component in these formulations, its selection is a crucial determinant of drug deposition into the lung, as interparticle forces may be affected by the carrier-particle properties. Therefore, the purpose of this article is to review the various grades of lactose, their production, and the methods of their characterisation. The origin of their adhesive and cohesive forces and their influence on aerosol generation are described, and the impact of the physicochemical properties of lactose on carrier-drug dispersion is discussed in detail.
Collapse
|
19
|
Sosnik A, Seremeta KP, Imperiale JC, Chiappetta DA. Novel formulation and drug delivery strategies for the treatment of pediatric poverty-related diseases. Expert Opin Drug Deliv 2012; 9:303-23. [PMID: 22257003 DOI: 10.1517/17425247.2012.655268] [Citation(s) in RCA: 35] [Impact Index Per Article: 2.9] [Reference Citation Analysis] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 01/04/2023]
Abstract
INTRODUCTION Due to a lack of approved drugs and formulations, children represent the most vulnerable patients. Magistral, unlicensed formulations obtained by the manipulation of solid forms should undergo clinical evaluation to ensure bioequivalence. The development of new pediatric medicines is complex and faces technological, economic and ethical challenges. This phenomenon has contributed to the emergence of an adult-children gap. To improve the situation, the World Health Organization launched the global campaign 'Make medicines child size' and a number of international initiatives have been established. The situation is more critical in the case of poverty-related diseases (PRDs) that mainly affect poor countries. AREAS COVERED This review critically discusses different strategies to develop pediatric formulations and drug delivery systems (DDS) in PRDs and their potential implementation in the current market. Readers will gain an updated perspective on the development of pediatric medicines for the treatment of PRDs and the proximate challenges and opportunities faced to ensure an effective pharmacotherapy. EXPERT OPINION There is an urgent need for the development of innovative, scalable and cost-viable formulations to ensure pediatric patients have access to appropriate medications for PRDs. The guidelines of the International Conference on Harmonisation constitute a very good orientation tool, as they emphasize physiological and developmental aspects that need to be considered in pediatric research. It is important to consider cultural, economic and ethical aspects that make developing nations facing PRDs different from the developed world. Thus, the best strategy would probably be to conceive and engage similar initiatives in the developing world, to address unattended therapeutic niches.
Collapse
Affiliation(s)
- Alejandro Sosnik
- University of Buenos Aires, Faculty of Pharmacy and Biochemistry, Department of Pharmaceutical Technology, The Group of Biomaterials and Nanotechnology for Improved Medicines, 956 Junín St., Buenos Aires CP1113, Argentina.
| | | | | | | |
Collapse
|
20
|
Ibrahim BM, Tsifansky MD, Yang Y, Yeo Y. Challenges and advances in the development of inhalable drug formulations for cystic fibrosis lung disease. Expert Opin Drug Deliv 2011; 8:451-66. [PMID: 21375469 DOI: 10.1517/17425247.2011.561310] [Citation(s) in RCA: 24] [Impact Index Per Article: 1.8] [Reference Citation Analysis] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/05/2022]
Abstract
INTRODUCTION Cystic fibrosis (CF) is a multisystem genetic disorder, which usually results in significant respiratory dysfunction. At present there is no cure for CF, but advances in pharmacotherapy have gradually increased the life expectancy of CF patients. As many drugs used in the therapy of CF are delivered by inhalation, the demand for effective and convenient inhalational CF drug formulations will grow as CF patients live longer. Knowledge of the current limitations in inhalational CF drug delivery is critical in identifying new opportunities and designing rational delivery strategies. AREAS COVERED This review discusses current and emerging therapeutic agents for CF therapy, selected physiological challenges to effective inhalational medication delivery, and various approaches to overcoming these challenges. The reader will find an integrated view of the known inhalational drug delivery challenges and the rationales for recent investigational inhalational drug formulations. EXPERT OPINION An ideal drug/gene delivery system to CF airways should overcome the tenacious sputum, which presents physical, chemical and biological barriers to effective transport of therapeutic agents to the targets and various cellular challenges.
Collapse
Affiliation(s)
- Basma M Ibrahim
- Department of Industrial and Physical Pharmacy, College of Pharmacy, Purdue University, 575 Stadium Mall Drive, West Lafayette, IN 47907, USA
| | | | | | | |
Collapse
|
21
|
Weers JG, Bell J, Chan HK, Cipolla D, Dunbar C, Hickey AJ, Smith IJ. Pulmonary Formulations: What Remains to be Done? J Aerosol Med Pulm Drug Deliv 2010; 23 Suppl 2:S5-23. [DOI: 10.1089/jamp.2010.0838] [Citation(s) in RCA: 88] [Impact Index Per Article: 6.3] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 12/29/2022] Open
Affiliation(s)
| | - John Bell
- Woodbank, Loughborough, Leichestershire, United Kingdom
| | - Hak-Kim Chan
- Faculty of Pharmacy, University of Sydney, Sydney, NWS, Australia
| | | | - Craig Dunbar
- Vertex Pharmaceuticals, Cambridge, Massachusetts
| | - Anthony J. Hickey
- School of Pharmacy, University of North Carolina, Chapel Hill, North Carolina
| | | |
Collapse
|
22
|
Abstract
With more antibiotic resistance and emerging pathogens in cystic fibrosis (CF) patients, the need for new strategies in the lifelong treatment of pulmonary infection has increased. Most of the focus is on chronic infection with Pseudomonas aeruginosa, which is still thought to be the main pathogen leading to advanced CF lung disease. Other bacterial species are also recognized in the pathogenesis of CF lung disease, even though their definitive role is not well established yet. Clearly, expansion of treatment options is urgently needed. This article focuses on recent developments in the field of new antimicrobial strategies for CF. It is clear that studies on new classes of antibiotics or antimicrobial-like drugs are scarce, and that most studies involve new (inhalation) formulations, new routes of delivery, or analogs of existing classes of antibiotics. Studies of new antibiotic-like drugs are, in most cases, in preclinical phases of development and only a few of these agents may reach the market. Importantly, new inhaled antibiotics, e.g. aztreonam, levofloxacin, and fosfomycin, and new, more efficient delivery systems such as dry powder inhalation and liposomes for current antibiotics are in the clinical phase of development. These developments will be of great importance in improving effective treatment and reducing the treatment burden for CF patients in the near future.
Collapse
Affiliation(s)
- Mireille van Westreenen
- Department of Medical Microbiology & Infectious Diseases, Erasmus MC, University Medical Centre Rotterdam, Rotterdam, the Netherlands.
| | | |
Collapse
|
23
|
Le J, Ashley ED, Neuhauser MM, Brown J, Gentry C, Klepser ME, Marr AM, Schiller D, Schwiesow JN, Tice S, VandenBussche HL, Wood GC. Consensus Summary of Aerosolized Antimicrobial Agents: Application of Guideline Criteria. Pharmacotherapy 2010; 30:562-84. [DOI: 10.1592/phco.30.6.562] [Citation(s) in RCA: 63] [Impact Index Per Article: 4.5] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/23/2022]
|
24
|
Yang Y, Tsifansky MD, Wu CJ, Yang HI, Schmidt G, Yeo Y. Inhalable Antibiotic Delivery Using a Dry Powder Co-delivering Recombinant Deoxyribonuclease and Ciprofloxacin for Treatment of Cystic Fibrosis. Pharm Res 2009; 27:151-60. [DOI: 10.1007/s11095-009-9991-2] [Citation(s) in RCA: 39] [Impact Index Per Article: 2.6] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 06/26/2009] [Accepted: 09/29/2009] [Indexed: 12/23/2022]
|
25
|
Ibrahim BM, Jun SW, Lee MY, Kang SH, Yeo Y. Development of inhalable dry powder formulation of basic fibroblast growth factor. Int J Pharm 2009; 385:66-72. [PMID: 19853028 DOI: 10.1016/j.ijpharm.2009.10.029] [Citation(s) in RCA: 16] [Impact Index Per Article: 1.1] [Reference Citation Analysis] [Abstract] [Journal Information] [Subscribe] [Scholar Register] [Received: 07/27/2009] [Revised: 10/04/2009] [Accepted: 10/12/2009] [Indexed: 10/20/2022]
Abstract
Basic fibroblast growth factor (bFGF) is a promising agent for therapy of asthma or chronic obstructive pulmonary disease. We aim to develop an inhalable powder formulation of bFGF, which may provide a safe, effective, and convenient way of delivering bFGF to the disease-ridden lungs. Development of a bFGF dry powder formulation is constrained by the poor stability of bFGF and the uncertainty in compatibility of the protein with carrier excipients. With these constraints in mind, we prepared dry powders containing bFGF in combinations of albumin, phospholipid, lactose, and/or leucine, by spray drying, and evaluated the aerodynamic properties of the powders and the stability of bFGF loaded in the powders. While an ethanolic solution of phospholipid, albumin, and lactose produced dispersible powder, bFGF was unstable in ethanol. The stability of bFGF was preserved when spray-dried with lactose in an aqueous solution. Leucine was required to obtain dry powder with good dispersibility; however, increase in the leucine content more than 50% (w/w) negatively influenced the bFGF stability with no additional benefit to the aerodynamic properties of the powders. Dry powders containing 20% (w/w) leucine provided desirable aerodynamic properties (fine particle fraction of 25.2+/-5.4% and mass median aerodynamic diameter of 4.7+/-0.9 microm) and 98.1+/-7% recovery of bioactive bFGF. This result warrants further investigation of the biological activity of the inhaled bFGF in a disease model.
Collapse
Affiliation(s)
- Basma M Ibrahim
- Department of Industrial and Physical Pharmacy, Purdue University, 575 Stadium Mall Drive, West Lafayette, IN 47907, United States
| | | | | | | | | |
Collapse
|
26
|
Traini D, Young PM. Delivery of antibiotics to the respiratory tract: an update. Expert Opin Drug Deliv 2009; 6:897-905. [PMID: 19637984 DOI: 10.1517/17425240903110710] [Citation(s) in RCA: 68] [Impact Index Per Article: 4.5] [Reference Citation Analysis] [Abstract] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/05/2022]
Abstract
The use of inhaled medications for the treatment of pulmonary diseases has become an increasingly popular drug delivery route over the past few decades. This delivery route allows for a drug to be delivered directly to the site of the disease, with a lower dose than more conventional oral or intravenous delivery methods, with reduced systemic absorption and consequently reduced risk of adverse effects. For asthma this delivery route has become the 'golden standard' of therapy. It is not unexpected therefore, that there has been great interest in the prospect of using inhaled antibiotics for the treatment of both chronic and recurrent respiratory infections. Since the early 1980s, several investigations have demonstrated that antibiotics could be delivered safely by means of inhalation, using nebulisers as their delivery systems. Lately, antibiotics delivery via inhalation have seen a 'revival' in interest and most of these studies have focused on delivering antibiotics to the lungs by means of a dry powder format. This review focuses on recent advances in antibiotic inhalation therapy.
Collapse
Affiliation(s)
- Daniela Traini
- University of Sydney, Faculty of Pharmacy (A15), Advanced Drug Delivery Group, NSW, Australia.
| | | |
Collapse
|