Evaluation of Polyvinyl Alcohol Hydrogel as Sustained-Release Vehicle for Transdermal Sytem of Bunitrolol-HCL

Design and optimization of process parameters of polyvinyl alcohol-graft-lactic acid films for transdermal drug delivery

The objective was to apply a simplex lattice design to determine the properties of polyvinyl alcohol-graft-lactic acid (PVA-g-LA) with different values for two independent variables: curing time (X1) and LA ratio (X2). Each independent variable was varied among three levels: -1, 0, and +1. Three coded levels were 120 min, 150 min, and 180 min for X1 and 2.5 g, 5 g, and 7.5 g for X2. Dependent variables of swelling behavior in various swelling media and thermal analysis parameters were monitored. The optimal formulation was selected based on the desirability value. The prediction was accurate, showing a low value of percent error. The morphology of the selected formulation with the highest desirability value showed a compact and dense film. Propranolol hydrochloride used as a model drug, was loaded into PVA-g-LA film. The propranolol hydrochloride content was 4.19 ± 1.05 mg/cm2. The cumulative release and permeation of drug were 61.94 ± 8.03% and 59.96 ± 6.61%, respectively. Thus, response surface methodology can be used as a tool to predict or optimize the process parameters for PVA-g-LA transdermal films in an accurate manner. PVA-g-LA could control the release and permeation of drug from the film layer.

Influence of Transcutol CG on the skin accumulation and transdermal permeation of ultraviolet absorbers

The objective of this study was to determine the influence of Transcutol CG concentration on the transdermal permeation and skin accumulation of two ultraviolet (UV) absorbers, 2-hydroxy-4-methoxybenzophenone (oxybenzone) and 2-octyl-4-methoxycinnamate (cinnamate). The concentration of the UV absorber was held constant at 6% (w/w) for all vehicle systems while the concentration of Transcutol CG was varied from 0 to 50% (w/w). Data showed that both UV absorbers exhibited increases in skin accumulation with increasing concentrations of Transcutol CG. Skin accumulation of oxybenzone was significantly (P<0.05) greater than that of cinnamate for all formulations investigated. Oxybenzone skin accumulation ranged from 22.9+/-2.8 microg/mg (0% Transcutol CG) to 80.8+/-27.2 microg/mg (50% Transcutol CG). Cinnamate skin accumulation ranged from 9.0+/-0.9 microg/mg to 39.8+/-12.2 microg/mg at 0 and 50% Transcutol CG, respectively. No significant differences were found in the transdermal permeation of oxybenzone or cinnamate for any of the formulations tested. The results of this study demonstrate that the inclusion of Transcutol CG in sunscreen formulations increases the skin accumulation of the UV absorbers oxybenzone and cinnamate without a concomitant increase in transdermal permeation.

Enhancing effects of unsaturated fatty acids with various structures on the permeation of indomethacin through rat skin

Effects of straight-chain, cis-type, unsaturated fatty acids with various structures (alkyl chain lengths, numbers of double bonds, position of double bonds, and cis- and trans-positional isomers) on the skin permeation of indomethacin were examined by using rat skins in-vitro. Furthermore, the disordering degrees of the intercellular lipid domain in the stratum corneum, which were treated with preparations of unsaturated fatty acids, were measured by the Fourier transform infrared (FT-IR) method using excised rabbit ear skins. Unsaturated fatty acids enhanced the permeation of indomethacin through rat skins. These permeation-enhancing effects by unsaturated fatty acids were affected by changes of their alkyl chain length from C14 to C22. The lag-times on the permeation of indomethacin were shortened by unsaturated fatty acids in the following order: C20 = C18 = C22 < C16 < C14. These fluxes were increased by unsaturated fatty acids in the following order: C20 > C22 = C18 = C16 > C14. Therefore, gondoic acid (cis-11-eicosenoic acid; C20H38O2) mostly enhanced the skin permeation of indomethacin. However, the enhancing effects of unsaturated fatty acids (C18 chain) were not affected by their differences of position and numbers of double bonds. These permeation-enhancing effects which were evaluated by flux were related to the degrees of wave-number shift in the frequency of the antisymmetric CH bond stretching absorbance (near 2920 cm-1) on FT-IR spectra of the fatty acid-treated stratum corneum. Therefore, the perturbation increase of lipid domain in the stratum corneum by these fatty acids probably was the cause of the enhancing effects of permeation of indomethacin.