Production of Natural Esters at the Pre-Industrial Scale by Solid/Gas Biocatalysis

Structure elucidation of the thermal degradation products of the nucleotide cofactors NADH and NADPH by nano-ESI-FTICR-MS and HPLC-MS

Redox cofactors like NADH and NADPH are essential for the catalytic activity of several oxidoreductases. Here, we describe a comparative study of the thermal degradation products of both cofactors in the dry and liquid states. The degradation products were first separated, detected, and quantified by high-performance liquid chromatography (HPLC). Subsequently, selected main fractions were investigated by nanoelectrospray ionization-Fourier transform ion cyclotron resonance mass spectrometry (MS). Additionally, HPLC-MS was used to elucidate the structure of all degradation products. From these data, degradation pathways for both the liquid and the solid states were elucidated. Thermal degradation in water is significantly faster compared to degradation in the solid state. Hydrolysis and oxidative ring opening of the reduced nicotinamide adenine dinucleotide (phosphate) were shown to be the main reaction paths. Surprisingly, no significant differences were observed between the degradation of both cofactors in solution and in the solid state. Our results demonstrate that the stability of both cofactors is not limiting at moderate temperatures if they are used in the dry state (e.g., solid/gas catalysis). Significant degradation of dry cofactors was only observed under conditions, which are usually not appropriate for biocatalysis (>95 °C). Besides, the situation is completely different in solution where degradation is already observed at moderate temperatures.

An Activity, Stability and Selectivity Comparison of Propioin Synthesis by Thiamine Diphosphate-Dependent Enzymes in a Solid/Gas Bioreactor

Enzymatic carboligation in a solid/gas bioreactor represents a new challenge in biotechnology. In this paper, the continuous gas-phase production of propioin from two propanal molecules by using thiamine diphosphate-dependent enzymes was studied. Two enzymes were used, namely benzaldehyde lyase (BAL) from Pseudomonas fluorescens and benzoylformate decarboxylase (BFD) from Pseudomonas putida. The enzymes are homologous and catalyze carboligase and carbolyase reactions in which no external cofactor regeneration is needed. The influence of water and substrate activity on the initial reaction rate and biocatalyst stability was investigated. An increase in water activity raised the initial reaction rates to the maximal values of 250 and 80 U g(-1) for BAL and BFD, respectively. The half-life showed the same trend with maximal values of 50 and 78 min for BAL and BFD, respectively. The increase in the half-life by increasing water activity was unexpected. It was also observed that BFD is more stable than BAL in the presence of the substrate propanal. Both enzymes showed substrate inhibition in the kinetic studies, and BAL was also deactivated during the reaction. Unexpectedly, the stereoselectivity of both enzymes (ee of 19 % for BAL and racemic mixture for BFD) was significantly impaired in the gas phase compared to the liquid phase.

Nonconventional hydrolytic dehalogenation of 1-chlorobutane by dehydrated bacteria in a continuous solid-gas biofilter

Rhodococcus erythropolis NCIMB 13064 and Xanthobacter autotrophicus GJ10 are able to catalyze the conversion of halogenated hydrocarbons to their corresponding alcohols. These strains are attractive biocatalysts for gas phase remediation of polluted gaseous effluents because of their complementary specificity for short or medium and for mono-, di-, or trisubstituted halogenated hydrocarbons (C2-C8 for Rhodococcus erythropolis and C1-C4 for Xanthobacter autotrophicus). After dehydration, these bacteria can catalyze the hydrolytic dehalogenation of 1-chlorobutane in a nonconventional gas phase system under a controlled water thermodynamic activity (a(w)). This process makes it possible to avoid the problems of solubility and bacterial development due to the presence of water in the traditional biofilters. In the aqueous phase, the dehalogenase activity of Rhodococcus erythropolis is less sensitive to thermal denaturation and the apparent Michaelis-Menten constants at 30 degrees C were 0.4 mM and 2.40 micromol min(-1) g(-1) for Km and Vmax, respectively. For Xanthobacter autotrophicus they were 2.8 mM and 0.35 micromol min(-1) g(-1). In the gas phase, the behavior of dehydrated Xanthobacter autotrophicus cells is different from that observed with Rhododcoccus erythropolis cells. The stability of the dehalogenase activity is markedly lower. It is shown that the HCl produced during the reaction is responsible for this low stability. Contrary to Rhodococcus erythropolis cells, disruption of cell walls does not increase the stability of the dehalogenase activity. The activity and stability of lyophilized Xanthobacter autotrophicus GJ10 cells are dependant on various parameters. Optimal dehalogenase activity was determined for water thermodynamic activity (a(w)) of 0.85. A temperature of 30 degrees C offers the best compromise between activity and stability. The pH control before dehydration plays a role in the ionization state of the dehalogenase in the cells. The apparent Michaelis-Menten constants Km and Vmax for the dehydrated Xanthobacter autotrophicus cells were 0.07 (1-chlorobutane thermodynamic activity) and 0.08 micromol min(-1) g(-1) of cells, respectively. A maximal transformation capacity of 1.4 g of 1-chlorobutane per day was finally obtained using 1g of lyophilized Xanthobacter autotrophicus GJ10 cells.

Haloalkane hydrolysis byRhodococcus erythropolis cells: Comparison of conventional aqueous phase dehalogenation and nonconventional gas phase dehalogenation

Biofiltration of air polluted by volatile organic compounds is now recognized by the industrial and research communities as an effective and viable alternative to standard environmental technologies. Whereas many studies have focused on solid/liquid/gas biofilters, there have been fewer reports on waste air treatment using other biological processes, especially in a solid/gas biofilter. In this study, a comparison was made of the hydrolysis of halogenated compounds (such as 1-chlorobutane) by lyophilized Rhodococcus erythropolis cells in a novel solid/gas biofilter and in the aqueous phase. We first determined the culture conditions for the production of R. erythropolis cells with a strong dehalogenase activity. Four different media were studied and the amount of 1-chlorobutane was optimized. Next, we report the possibility to use R. erythropolis cells in a solid/gas biofilter in order to transform halogenated compounds in corresponding alcohols. The effect of experimental parameters (total flow into the biofilter, thermodynamic activity of the substrates, temperature, carbon chain length of halogenated substrates) on the activity and stability of lyophilized cells in the gas phase was determined. A critical water thermodynamic activity (a(w)) of 0.4 is necessary for the enzyme to become active and optimal dehalogenase activity for the lyophilized cells is obtained for an a(w) of 0.9. A temperature of reaction of 40 degrees C represents the best compromise between stability and activity. Activation energy of the reaction was determined and found equal to 59.5 KJ/mol. The pH effect on the dehalogenase activity of R. erythropolis cells was also studied in the gas phase and in the aqueous phase. It was observed that pH 9.0 provided the best activity in both systems. We observed that in the aqueous phase R. erythropolis cells were less sensitive to the variation in pH than R. erythropolis cells in the gas phase. Finally, the addition of volatile Lewis base (triethylamine) in the gaseous phase and the action of the lysozyme in order to permeabilize the cells was found to be highly beneficial to the effectiveness of the biofilter.