Influence of lamb rennet paste on the lipolytic and sensory profile of Murcia al Vino cheese

Influence of the Breed of Sheep on the Characteristics of Zamorano Cheese

This work aimed to study the effects of using ewe’s milk from Churra, Assaf, or both breeds on the physicochemical and sensory characteristics of Zamorano cheese at the end of ripening. Zamorano cheese is a hard variety with protected designation of origin (PDO) produced in the province of Zamora (Spain) with raw or pasteurized ewe’s milk. Five batches of Zamorano cheese were produced with pasteurized ewe’s milk. One batch was elaborated using milk from the Churra breed, the other using milk from the Assaf breed, and the remaining three employed milk mixtures of Churra and Assaf breeds in the proportions 75:25, 50:50 and, 25:75, respectively. Cheeses made with a higher proportion of Churra milk showed a predominance of hydrophilic peptides, while hydrophobic peptides predominated in cheeses with a greater percentage of milk from the Assaf breed. The largest content of most free amino acids was found in cheeses produced with the highest percentage of Churra milk. These cheeses presented the highest values for fat acidity index and free fatty acids content and showed greater elasticity and adhesiveness, as well as lower granularity and hardness. In the sensory evaluation, aftertaste and persistence were higher in these cheeses, being scored with the best overall values.

Quality Characteristics and Consumer Acceptance of High-Moisture Mozzarella Obtained from Heat-Treated Goat Milk

High-moisture mozzarella is a pasta filata cheese manufactured from cow or buffalo milk that has spread all over the world. Its manufacturing from the milk of small ruminants (goat and sheep) has been recently proposed to innovate this ailing sector. Previously, a protocol was reported for making goat mozzarella from unpasteurized milk but, according to legislation, the microbiological safety of raw milk fresh cheeses is not guaranteed. In the present research, two new protocols were tested for producing mozzarella from pasteurized milk prepared by two different low-temperature long-time treatments (67 °C or 63 °C × 30 min). The obtained cheeses were subjected to physical–chemical and microbiological analyses and to consumer testing. The results showed that the heat treatments caused longer coagulation times than those reported in the literature, despite pre-acidification (at pH 5.93 or 6.35) having been performed to counterbalance the expected worsening of the coagulation aptitude. The obtained products showed differences in the chemical composition, texture, proteolysis, and lipolysis. Both pasteurization and pre-acidification played a role in determining these variations. Consumer testing indicated that mozzarella obtained from milk heated at the lower temperature and coagulated at a higher pH reached a good level of appreciation (62%).

Influence of vegetable coagulant and ripening time on the lipolytic and sensory profile of cheeses made with raw goat milk from Canary breeds

Free fatty acids and sensory profiles were obtained for cheeses made with raw goat milk and vegetable coagulant, derived from the cardoon flower ( Cynara cardunculus), at different ripening times (7 and 20 days). A solid–liquid phase extraction method followed by solid-phase extraction and gas chromatography was used. Profiles were also obtained with cheeses made with commercial coagulant, traditional kid rennet paste, and mixture coagulant (vegetable coagulant-kid rennet). The use of vegetable coagulant and vegetable coagulant-kid rennet is common in traditional Protected Designation of Origin cheeses such as “ Queso Flor de Guía” and “ Queso Media Flor de Guía” (Spain). Contents of short-chain free fatty acids (7.5–22.5 mmol·kg−1), medium-chain free fatty acids (0.4–3.7 mmol·kg−1), and long-chain free fatty acids (0.2–2.1 mmol·kg−1) varied depending on the coagulant type and the ripening time. Vegetable coagulant cheeses present odour intensity and flavour intensity much higher than commercial coagulant cheeses in the sensory analysis for cheeses obtained with seven days of ripening, but the values decrease when increasing the ripening time. Multivariate analysis allowed us to differentiate cheese samples according to the ripening time when using lipolytic profile and according to the coagulant type using the sensory profile.

Short communication: Sensory profile of raw goat milk cheeses made with artisan kid rennet pastes from commercial-weight animals: alternative to farmhouse goat cheeses

The loss of traditional kid rennet pastes in the Canary Islands (Spain), as in many other regions, is most likely due to the custom of using abomasa from very young animals killed below desirable commercial weight. In addition, the reasonable price of commercial rennets (CR) has resulted in the loss of typical sensory characteristics for most farmhouse raw goat milk cheeses, placing them at a disadvantage when local and international markets are full of different cheeses, often with aggressive marketing strategies. This paper analyzes the sensory characteristics of raw goat milk cheeses made with rennet pastes prepared from commercial kid abomasa in 2 ways: dried while full of ingested milk [full, commercial, artisan kid rennet (FCKR)], or dried after being emptied of ingested milk and refilled with raw goat milk [empty, commercial, artisan kid rennet (ECKR)]. This latter practice allows the use of empty abomasa, or abomasa with grass, soil, and so on. Sensory profiles of cheeses made with FCKR and ECKR rennets were compared with those made with CR by an expert panel (n=7). The FCKR and ECKR cheeses had similar sensory profiles. Although scores for FCKR cheeses were somewhat higher than for ECKR cheeses, they were in the range found for traditional cheeses made with rennet prepared with abomasa from very young animals. The sensory profile of CR cheeses was very different. Almost 90% of consumer panelists (n=90) preferred cheeses made with the experimental rennet pastes. These results demonstrate the possibility to prepare artisan rennet pastes from commercial-weight kids in an easy way for farmhouse cheese makers using local resources that would otherwise be destroyed in abattoirs.

Effect of feeding goats with distilled and non-distilled thyme leaves (Thymus zygis subp. gracilis) on milk and cheese properties

The aim of this study was to evaluate the effect of feeding goats with distilled and non-distilled thyme leaves (Thymus zygis subsp. gracilis) on the physicochemical composition and technological properties of pasteurised goat milk, and on the physicochemical composition, phenolic content, oxidative stability, microbiology, sensory and texture profile of Murcia al Vino goat cheese. One group of goats was fed the basal diet (control), the second and third groups were fed with different levels of distilled (10 and 20%) or non-distilled (3·75 and 7·5%) thyme leaves. Goat milk physicochemical composition was significantly affected by the substitution of 7·5% of basal goat diet with non-distilled thyme leaves (increase in fat, protein, dry matter and PUFA content), while goat milk clotting time was increased significantly by the introduction of 20% distilled thyme leaves, which reduces its technological suitability. Microbiology, sensory and texture profiles were not affected by the introduction of distilled thyme leaves. The introduction of distilled and non-distilled thyme leaves as an alternative feed to diet can lead to an inhibition of lipids oxidation. The introduction of distilled and non-distilled thyme leaves into goat's diet can be successfully adopted as a strategy to reduce feeding costs and to take advantage of the waste from the production of essential oils, minimising waste removing costs and the environmental impact.