Linkage of in situ ruminal degradation of crude protein with ruminal degradation of amino acids and phytate from different soybean meals in dairy cows

The objectives of this study were to determine the range in ruminal degradability of crude protein (CP) and intestinal digestibility of rumen undegradable protein in commercial soybean meal (SBM) and to investigate the range in in situ ruminal AA and phytate (InsP6) degradation and their relationship to CP degradation. An in situ study was conducted using 3 lactating Jersey cows with permanent rumen cannulas. Seventeen SBM variants from Europe, Brazil, Argentina, North America, and India were tested for ruminal CP and AA degradation, and in vitro intestinal digestibility of rumen undegradable protein. Nine variants were used to investigate the ruminal degradation of InsP6. The estimated rapidly degradable fraction (a) of CP showed an average value of 4.5% (range: 0.0%-9.0%), the slowly degradable fraction (b) averaged 95% (91%-100%), and the potential degradation was complete for all 17 SBM variants. The degradation of fraction b started after a mean lag phase of 1.7 h (1.1-2.0 h) at an average rate (c) of 10% per hour, but with a high range from 4.5% to 14% per hour. Differences in the degradation parameters induced a considerable range in CP effective degradation at a rumen passage rate of 6% per hour (CPED6) from 38% to 67%; hence, the concentration of rumen undegradable protein varied widely from 33% to 62%. The range in AA degradation between the SBM variants was high, with Ser showing the widest range, from 28% to 96%, and similar for the other AA. The regression equations showed close relationships between CP and AA degradation after 16 h of in situ incubation. However, the slopes of the linear regressions were significantly different between AA, suggesting that degradation among individual AA differs upon a change in CP degradation. The concentrations of InsP6 and myo-inositol pentakisphosphate in bag residues in the in situ study decreased constantly with longer ruminal incubation times. The ruminal degradation parameters of InsP6 ranged from 11% to 37% for fraction a, 63% to 89% for fraction b, and from 7.7% to 21% per hour for degradation rate c, with average values of 21%, 79%, and 16% per hour, respectively. The calculated InsP6 effective degradation at a rumen passage rate of 6% per hour (InsP6ED6) varied from 61% to 84% among the SBM variants. Significant correlations were detected between InsP6ED6 and CPED6 and between InsP6ED6 and chemical protein fractions A, B1, B2, B3, and C. Linear regression equations were developed to predict ruminal InsP6 degradation using CPED6 and chemical protein fractions B3 and C chosen by a stepwise selection procedure. We concluded that a high range in CP, AA, and InsP6 degradation exists among commercial SBM, suggesting that general degradability values may not be precise enough for diet formulation for dairy cows. Degradation of CP in SBM may be used to predict rumen degradation of AA and InsP6 using linear regression equations. Degradation of CP and InsP6 could also be predicted from the chemical protein fractions.

Ruminal and post-ruminal phytate degradation of diets containing rapeseed meal or soybean meal

This study aimed to investigate ruminal and post-ruminal degradation of phytic acid (InsP₆) in diets containing either rapeseed meal (RSM) or soybean meal (SBM). In Experiment 1, the effective degradability of crude protein (CPED) and InsP₆ (InsP₆ED) was evaluated by incubating RSM and SBM in situ in three rumen-fistulated lactating Jersey cows for 2, 4, 6, 8, 16, 24, 48 and 72 h, and calculating effective degradability at rumen passage rates of 2% and 5%/h. In Experiment 2, eight wethers were assigned for 8 weeks to two dietary treatments (Diet RSM and Diet SBM) containing 150 g of either meal and 100 g of maize silage per feeding time and had free access to hay and water. Titanium dioxide (TiO₂) was added to the diets for the last 5 days of the study. The wethers were then stunned, exsanguinated and digesta from the reticulo-rumen, omasum, abomasum, jejunum, colon, and rectum were sampled. In Experiment 1, the InsP₆ED of RSM (InsP₆ED₂: 83%; InsP₆ED₅: 64%) decreased almost identically to that of CPED with increasing passage rate (CPED₂: 78%; CPED₅: 63%) and was significantly lower than that of SBM (InsP₆ED₂: 93%; InsP₆ED₅: 85%). In Experiment 2, ruminal InsP₆ disappearance was significantly higher in wethers fed Diet SBM (89%) than in those fed Diet RSM (76%). Total post-ruminal InsP₆ degradation was 6% for Diet RSM and 4% for Diet SBM (p = 0.186). The total tract InsP₆ disappearance was higher in Diet SBM (93%) than in Diet RSM (82%). Considering higher InsP₆ contents in RSM, Diet RSM resulted in significantly higher amounts of ruminally (Diet RSM: 4.5 g/d; Diet SBM: 3.4 g/d) and total tract (Diet RSM: 4.9 g/d; Diet SBM: 3.5 g/d) degraded InsP₆. InsP₅ was quantified in most of the digesta samples after feeding Diet RSM but was not detectable in the majority of digesta samples for Diet SBM. Concentrations of myo-inositol (MI) tended to be higher (p = 0.060) in the blood plasma of wethers fed Diet RSM. The consistency between ruminal InsP₆ disappearance in wethers and in situ calculated InsP₆ED₂, along with the very low extent of post-ruminal InsP₆ degradation, suggests that at a low rumen passage rate, InsP₆-P from the feed becoming available to ruminants is almost entirely from InsP₆ degradation in the rumen.

In situ ruminal disappearance of crude protein and phytate from differently processed rapeseed meals in dairy cows

BACKGROUND

The influence of different processing conditions of rapeseed meal on ruminal degradation of crude protein and phytate in dairy cows was investigated. Following oil extraction from the rapeseed, five residence times in the desolventizer/toaster were chosen to remove the solvent from the meal. Rapeseed cake and rapeseed meals were incubated in situ in the rumen of three fistulated dairy cows to determine ruminal degradation parameters.

RESULTS

With increasing residence time in the desolventizer/toaster the ruminal degradation of crude protein decreased significantly for every treatment step. Ruminal phytate degradation and crude protein degradation were affected almost identically.

CONCLUSION

The processing conditions of rapeseed meal have a major impact on the ruminal degradation of crude protein and phytate, indicating a potential conflict of interest regarding the production process. Large amounts of undegradable rumen protein are often intended for high-yielding dairy cows whereas a high level of ruminal degradation is preferred for phytate to increase absorption of phosphorus in the small intestine. © 2021 The Authors. Journal of The Science of Food and Agriculture published by John Wiley & Sons Ltd on behalf of Society of Chemical Industry.

Holstein dairy cows with high phosphorus utilization efficiency fed a low phosphorous diet secreted less phosphorus with urine but more with milk and feces

The environmental pollution of phosphorus (P) from livestock farming is becoming increasingly problematic especially with regard to dwindling global P resources. Thus, a more sustainable handling of P resources, including improvements in P use efficiency and a reduction of P loss from farm animals, is necessary. Dairy cows may differ in milk P yield and P use efficiency despite receiving the same feed ration. The objective of this study was to elucidate inter-individual differences in P and closely linked nitrogen (N) excretions and the expression of P transport proteins in dairy cows with low and high P utilization efficiency. Twenty multiparous, late lactating German Holstein dairy cows were retrospectively assigned to either a high (HPeff; n = 10) or low (LPeff; n = 10) P utilization efficiency group. Cows were fed a diet low in P and crude protein (CP) content. During a 4-day balance study, feed intake, urine and fecal excretions, and milk yield were recorded to determine total P and N content in subsamples. Mammary gland, kidney and jejunal mucosa were sampled to analyze mRNA expressions of P transporters by real-time-PCR. A high milk P yield in HPeff cows strongly correlated with milk protein and milk N yield. HPeff cows excreted less urinary P, had a higher renal P reabsorption rate, and a higher renal sodium-P cotransporter 2 expression than LPeff cows. As HPeff cows channeled more P into milk, they mobilized more P from body reserves as indicated by their more negative P-balance. In addition, HPeff cows had higher fecal P excretion relative to ingested P, resulting in a lower apparent P digestibility. In conclusion, when fed a low P diet, HPeff cows channeled more endogenous P into milk and feces, which in the long-term, likely has adverse effects on animal health and the environment.

Determination of in situ ruminal degradation of phytate phosphorus from single and compound feeds in dairy cows using chemical analysis and near-infrared spectroscopy

The ruminal degradation of P bound in phytate (InsP₆) can vary between feeds, but data on ruminal degradation of InsP₆ from different feedstuffs for cattle are rare. One objective of this study was to increase the data base on ruminal effective degradation of InsP₆ (InsP₆ED) and to assess if InsP₆ED of compound feeds (CF) can be calculated from comprising single feeds. As a second objective, use of near-infrared spectroscopy (NIRS) to predict InsP₆ concentrations was tested. Nine single feeds (maize, wheat, barley, faba beans, soybeans, soybean meal (SBM), rapeseed meal (RSM), sunflower meal (SFM), dried distillers’ grains with solubles (DDGS)) and two CF (CF1/CF2), consisting of different amounts of the examined single feeds, were incubated for 2, 4, 8, 16, 24, 48 and 72 h in the rumen of three ruminally fistulated Jersey cows. Samples of CF were examined before (CF1/CF2 Mash) and after pelleting (CF1/CF2 Pellet), and InsP₆ED was calculated for all feeds at two passage rates (InsP₆ED₅: k = 5%/h; InsP₆ED₈: k = 8%/h). For CF1 and CF2, InsP₆ED was also calculated from values of the respective single feeds. Near-infrared spectra were recorded in duplicate and used to establish calibrations to predict InsP₆ concentration. Besides a global calibration, also local calibrations were evaluated by separating samples into different data sets based on their origin. The InsP₆ED₈ was highest for faba beans (91%), followed by maize (90%), DDGS (89%), soybeans (85%), wheat (76%) and barley (74%). Lower values were determined for oilseed meals (48% RSM, 65% SFM, 66% SBM). Calculating InsP₆ED of CF from values of single feeds underestimated observed values up to 11 percentage points. The NIRS calibrations in general showed a good performance, but statistical key data suggest that local calibrations should be established. The wide variation of InsP₆ED between feeds indicates that the ruminal availability of P bound in InsP₆ should be evaluated individually for feeds. This requires further in situ studies with high amounts of samples for InsP₆ analysis. Near-infrared spectroscopy has the potential to simplify the analytical step of InsP₆ in the future, but the calibrations need to be expanded.

Establishment of a rapeseed meal fermentation model for iturin A production by Bacillus amyloliquefaciens CX-20

Iturin A is an important broad-spectrum antifungal cyclic lipopeptide used as an ideal potential biological control agent. However, its application is limited mainly due to the producer strains' low productivity and the high production costs. Here, a potentially industrial strain Bacillus amyloliquefaciens CX-20 was proved to use low-cost rapeseed meal (RSM) as the sole source of all nutrients except the carbon source for the high productivity of iturin A. A fermentation model was first established to analyse the specific roles of different RSM components on iturin A production. Proteins and minerals in RSM were confirmed to play positive role, whereas fibre had negative effect. And the maximal concentration of iturin A was predicted to be more than 1.64 g l-1 by the established evaluation model. Moreover, submerged fermentation of B. amyloliquefaciens CX-20 demonstrated a strong ability to hydrolyse RSM and release water-soluble nutrients. This fermentation broth, a mixture of Bacillus, iturin A and RSM hydrolysate, could simultaneously combat clubroot disease and promote the growth of Brassica napus. In conclusion, this study provides a promising strategy to achieve full utilization of RSM for the production of a combination of value-added biological control agent and biofertilizer.