Factors Limiting Shelf Life of a Tomato-Oil Homogenate (Salmorejo) Pasteurised via Conventional and Radiofrequency Continuous Heating and Packed in Polyethylene Bottles

Influence of Pasteurisation (Conventional vs. Radiofrequency) and Chill Storage on Retention of Ascorbic Acid, Tocopherol and Carotenoids in Salmorejo

Salmorejo, a Mediterranean tomato-oil puree, is considered a dietary source of antioxidant vitamins C and E and carotenoids lycopene and β-carotene, the latter endowed with provitamin A activity. However, these antioxidants can be degraded in oxidation reactions catalysed or not by enzymes during pasteurisation and storage treatments used to stabilise the salmorejo before consumption. Due to its better penetration, the use of dielectric heating by radiofrequency (RF) may improve results of pasteurisation in this product. The objective was to assess the effects of pasteurisation temperature (70-100 °C, at 5 °C intervals) and storage time (0-5 months, at one-month intervals) on levels of ascorbic acid, α-tocopherol and carotenoids and antioxidant capacity (AC) in salmorejo pasteurised (over 10 s) by conventional (CH) or RF continuous heating. Two successive experiments were conducted to select an adequate pasteurisation temperature for use in the shelf-life study. Pasteurisation upon tested conditions allows a good retention of salmorejo antioxidants. Either CH or RF pasteurisers can be used with similar results. Vitamin C (L-ascorbic + dehydroascorbic acids) was more abundant (15-19 mg 100 g-1) than carotenoids (0.9-2.6 mg 100 g-1) (all-trans + cis lycopene and β-carotene) and α-tocopherol (0.8-1.2 mg 100 g-1) in the pasteurised product. Using excessively low temperatures (70 °C) resulted in partial losses of the three antioxidants, possibly due to oxidase residual activities. Intensifying thermal treatment improved this issue with minor losses of the thermolabile vitamin C and increased carotenoid content. Using a suitable temperature (80 °C) did not prevent most vitamin C from being degraded by the first month, while α-tocopherol, and, to a lesser extent, carotenoids, showed good retention levels during shelf life under refrigeration. Vitamins C and E and carotenoids, either by degradation, regeneration or releasing, likely contribute to the AC in salmorejo. Phenolic antioxidant response, radical-scavenging activities and redox potential values confirmed this finding. The pasteurised-chilled salmorejo shows good antioxidant properties with potential health implications, a positive nutritional aspect for consumers of this tomato-oil homogenate. The losses of antioxidants and AC due to pasteurization would be of little relevance compared to the losses accumulated during shelf life.