Characterization and Behavior of Salmonella javiana During Manufacture of Mozzarella-type Cheese 1

Comparing the behavior of multidrug-resistant and pansusceptible Salmonella during the production and aging of a Gouda cheese manufactured from raw milk

Outbreaks of salmonellosis have been linked to the consumption of cheese, and emerging multidrug-resistant (MDR) strains of Salmonella may be more virulent and more tolerant than less resistant strains to stresses encountered in food production, which may enhance the survival of these resistant strains in cheese. This study was conducted to compare the behavior of MDR and pansusceptible Salmonella strains during the manufacture and aging of Gouda cheese and compare pathogen recovery via several rapid and traditional methods. Cheeses were manufactured from raw milk inoculated with a six-strain cocktail of either MDR or susceptible Salmonella Newport and Salmonella Typhimurium at initial levels of <20 CFU/ml. Samples of milk, whey, curd, and finished cheese were analyzed using eight enrichment and detection protocols. Overall, changes in pathogen levels observed throughout manufacture and aging did not differ significantly between MDR and susceptible Salmonella strains. Salmonella counts increased significantly during manufacture to a mean of 734 CFU/g on day 1 followed by a significant decrease over 60 days of aging to <1 CFU/g. Although levels fell and stayed below the direct plating detection limit of $ 5 CFU/g after 54 days on average, viable cells remained detectable after enrichment for an average of 210 ± 40 days. The International Organization for Standardization methods with and without PCR detection provided the most accurate results, and the remaining methods, notably those with selective primary incubation, produced results that disagreed significantly with the true result. Overall, our findings suggest that MDR Salmonella strains may not pose a greater threat to cheese safety than do non-MDR Salmonella strains.

Methods for thermal inactivation of pathogens in mozzarella: a comparison between stretching and pasteurization

This study aimed to evaluate the efficiency of stretching in the reduction of pathogens when compared to milk pasteurization, the official method to ensure safe cheese production. Whole buffalo milk was contaminated with Mycobacterium fortuitum, Listeria monocytogenes, Salmonella typhimurium, and Staphylococcus aureus. Part of the milk was used in mozzarella production and the other part was submitted to holder pasteurization. Pathogens were quantified before and after thermal processing (mozzarella stretching and milk pasteurization). Pasteurization and stretching led to the following reductions in log cycles, respectively: 4.0 and 6.3 for Mycobacterium sp.; 6.0 and 8.4 for Listeria sp.; >6.8 and 4.5 for Staphylococcus sp.; and >8.2 and 7.5 for Salmonella sp.

Potential growth and control of Salmonella in Hispanic type soft cheese

This study evaluated the growth and control of Salmonella serotypes in a soft Hispanic type cheese (Queso Fresco). Cheese was made in the laboratory using a commercial procedure and after inoculation it was stored under vacuum at temperatures ranging from 6 to 30 degrees C. The minimum temperature that allowed growth of Salmonella was 8 degrees C. Accumulated data from the growth studies were used for the development of models relating the square root of 1/LT (LT = lag time) and specific growth rate to temperature. The effect of selected antimicrobials (potassium sorbate, sodium benzoate and sodium lactate) on the growth and survival of Salmonella in milk and in cheese at various storage temperatures was also examined. Addition of sodium benzoate (0.3%) to cheese (pH 6.6) or addition of potassium sorbate (0.3%) to cheese (pH 6.0) made from milk, which was acidified to pH 5.9 with propionic acid, had a significant impact on delaying or preventing growth of the pathogen.

Salmonellae, salmonellosis, and dairy foods: a review

Salmonellae continue to be a major concern for the dairy industry because these bacteria have caused recent outbreaks of illness and have been isolated from various dairy products in the market place. Salmonellae are generally not heat resistant and normally grow at 35 to 37 degrees C, but they can grow at much lower temperatures, provided that the incubation time is suitably extended. To minimize problems, foods should be held at or below 2 to 5 degrees C at all times. Both conventional and rapid methods are available to isolate salmonellae from dairy foods and to identify the bacteria. Salmonellae behave differently in different kinds of cheese: they survived in ripening Cheddar cheese for up to 7 mo at 13 degrees C and for 10 mo at 7 degrees C; in coldpack cheese food for several weeks, depending on the pH and preservative used; and in Domiati cheese 13 to 36 d, depending on the manufacturing process used. When Mozzarella cheese was made, temperatures of stretching and molding (60 degrees C) killed all salmonellae present, but, in cottage cheese, survival of the pathogen depended on the cooking temperature of curd. Spray drying of skim milk killed substantial numbers of salmonellae, but some survivors remained. Butter readily supported growth of salmonellae at room temperature, and neither freezing nor refrigeration for brief periods eliminated salmonellae from butter. Use of appropriate hygienic procedures, e.g., Hazard Analysis Critical Control Point system, during processing should reduce the likelihood of salmonellosis outbreaks associated with dairy foods.

Acid adaptation promotes survival of Salmonella spp. in cheese

Salmonella typhimurium was adapted to acid by exposure to hydrochloric acid at pH 5.8 for one to two doublings. Acid-adapted cells had increased resistance to inactivation by organic acids commonly present in cheese, including lactic, propionic, and acetic acids. Recovery of cells during the treatment with organic acids was increased 1,000-fold by inclusion of 0.1% sodium pyruvate in the recovery medium. Acid-adapted S. typhimurium cells survived better than nonadapted cells during a milk fermentation by a lactic acid culture. Acid-adapted cells also showed enhanced survival over a period of two months in cheddar, Swiss, and mozzarella cheeses kept at 5 degrees C. Acid adaptation was found in Salmonella spp., including Salmonella enteritidis, Salmonella choleraesuis subsp. choleraesuis serotype heidelberg, and Salmonella choleraesuis subsp. choleraesuis serotype javiana, associated with food poisoning. These observations support the theory that acid adaptation is an important survival mechanism enabling Salmonella spp. to persist in fermented dairy products and possibly other acidic food products.