Practical approach to develop a multi-group screening method for detection of mycotoxins, pesticides and veterinary drugs in food

Critical Evaluation of Two Qualitative Analytical Approaches for Multiclass Determination of Veterinary Drugs in Bovine Muscle Using UHPLC-Q-Orbitrap: The Wind of Change in Brazilian Monitoring

Food safety is recognized as a main requirement for consumers, food industries, and official laboratories. Here, we present the optimization and screening qualitative validation of two multianalyte methods in bovine muscle tissues by ultra-high-performance liquid chromatography coupled to high-resolution mass spectrometry with an Orbitrap-type analyzer, operated with a heated ionization source in positive and negative mode. This aims for not only the simultaneous detection of veterinary drugs regulated in Brazil but also the prospection of antimicrobials not yet monitored. Two different sample preparation procedures were applied: method A-generic solid-liquid extraction with 0.1% formic acid (v/v) in an aqueous solution of EDTA 0.1% (w/v)-acetonitrile-methanol (1:1:1, v/v/v), followed by an additional ultrasound-assisted extraction and method B-QuEChERS. In both procedures, selectivity showed satisfactory conformity. From a detection capability (CCβ) equivalent to ½ the maximum residue limit, >34% of the analyte resulted in a false positive rate of <5%, preponderant by the QuEChERS method, which exhibited a higher yield of the sample. The results showed the potential application of both procedures in the routine analysis of foods by official laboratories, enabling the expansion of this methodological portfolio as well as its analytical scopes, thus optimizing the control of residues of veterinary drugs in the country.

Target analysis and retrospective screening of contaminants in ready-to-eat cooked ham samples through UHPLC-Q-Orbitrap HRMS

The use of veterinary drugs (VDs) is widely administered to animals for both therapeutic and prophylactic purposes. However, their improper use may involve their occurrence in the final products intended for human consumption. In this scientific work, a method for the investigation of target (n = 30) VDs residues and retrospective suspect screening followed by confirmation using analytical standards of others 38 contaminants in ready-to-eat cooked ham by ultra-high performance liquid chromatography coupled with high-resolution mass spectrometry (UHPLC-Q-Orbitrap HRMS) was developed. The extraction was performed based on the QuEChERS approach and validated in accordance with the European Regulation 2021/808. The application of the in-house validated method to ready-to-eat cooked ham showed the occurrence of fourteen VDs residues. Despite the important incidence, the concentration levels found were below the maximum residue limits set for VDs in porcine muscle, except for colchicine. Constant monitoring of animals derived food is strongly recommended to ensure the food safety of consumers.