Fermentation performance and nutritional assessment of physically processed lentil and green pea flour

Submerged fermentation of lentil protein isolate and its impact on protein functionality, nutrition, and volatile profiles

Fermentation of pulses as a clean processing technique has been reported to have a favorable impact on the functional and nutritional quality of the starting materials. Compared to commonly fermented pulses such as peas and chickpeas, limited information is available on the effect of fermentation on lentils, especially when using a high protein isolate (>80% protein) as compared to seeds or flours. Therefore, in the present work, lentil protein isolate was used as a feedstock for submerged fermentation with Aspergillus niger, Aspergillus oryzae, or Lactobacillus plantarum. After 48 h, the samples showed increased protein content with enhanced solubility and oil-holding capacity. Controlled fermentation, as opposed to spontaneous fermentation, maintained the high foaming capacity; however, all fermented samples had lower foam and emulsion stabilizing properties and reduced water-holding capacity compared to the control. The fermented proteins were also less digestible, possibly due to an increase in phenolics and saponins. New volatile compounds were identified in fermented samples that show promise for improved sensory attributes. Significant differences were observed in specific quality attributes depending on the microbial strain used. Further research is required to better understand the fermentative metabolism of microbial communities when provided high-protein lentil ingredients as growth substrates. PRACTICAL APPLICATION: Fermented lentil protein isolate has promising flavor profiles that may improve its sensory properties for food application.

Changes in Chemical Composition of Lentils, Including Gamma-Aminobutyric Acid and Volatile Compound Formation during Submerged and Solid-State Fermentation with Pediococcus acidilactici

The aim of this study was to evaluate and compare the characteristics of non-treated and fermented [via submerged (SMF) and solid-state (SSF) fermentation using Pediococcus acidilactici] lentils (Lens culinaris) grown either in pure stands (L) or relay intercropped with winter rye (LR). It was observed that the lentils were suitable substrate for lacto-fermentation. Most of the free amino acid concentrations increased in lentils after both fermentations. The highest concentration of γ-aminobutyric acid was found in SSF LR samples. However, fermentation led to higher biogenic amines (BA) content in lentils. The most abundant fatty acid in lentils was C18:2. SSF lentils showed more complex volatile compound (VC) profiles (with between nine and seventeen new VCs formed), whereas, in SMF samples, between two and five newly VCs were formed. When comparing lentil grown types, L contained significantly higher concentrations of Na, K, Ca, P, Mn, and Se, while LR contained significantly higher concentrations of Fe and Ni. To sum up, fermentation with lactic acid bacteria (LAB) contributed to the improved biological value of lentils; still, the quantity of BA needs to be considered. Further investigations into the P. acidilactici metabolism of certain compounds (such as phenolic and antinutritional compounds) in lentils during fermentation ought to be carried out.

Autochthonous Fermentation as a Means to Improve the Bioaccessibility and Antioxidant Activity of Proteins and Phenolic Compounds of Yellow Pea Flour

This study focused on evaluating the potential of the natural fermentation of pea flour to improve the release of antioxidant compounds. Preliminary fermentations of 36.4% w/w flour dispersions were performed in tubes under different conditions (24 and 48 h, 30 and 37 °C). Finally, fermented flours (FFs) were obtained in a bioreactor under two conditions: 1: 36.4% w/w, 24 h, 30 °C (FF1); 2: 14.3% w/w, 24 h, 37 °C (FF2). The pH values decreased to 4.4-4.7, with a predominance of lactic acid bacteria. As in the fermentations in tubes, an increment in the proteolysis degree (TNBS method) (greater for FF2), polypeptide aggregation and a decrease in their solubility, an increase in <2 kDa peptides, and an increase in the Oxygen Radical Absorption Capacity (ORAC) potency of PBS-soluble fractions after fermentation were demonstrated. Also, fermentation increased the proteolysis degree after simulated gastrointestinal digestion (SGID, COST-INFOGEST) with respect to the non-fermented flour digests, with some differences in the molecular composition of the different digests. ORAC and Hydroxyl Radical Averting Capacity (HORAC) potencies increased in all cases. The digest of FF2 (FF2D) presented the greater ORAC value, with higher activities for >4 kDa, as well as for some fractions in the ranges 2-0.3 kDa and <0.10 kDa. Fermentation also increased the 60%-ethanol-extracted phenolic compounds, mainly flavonoids, and the ORAC activity. After SGID, the flavan-3-ols disappeared, but some phenolic acids increased with respect to the flour. Fermentation in condition 2 was considered the most appropriate to obtain a functional antioxidant ingredient.

Protein composition and nutritional aspects of pea protein fractions obtained by a modified isoelectric precipitation method using fermentation

Pea albumins are promising for their nutritional, biological, and techno-functional properties. However, this fraction is usually discarded in the industry due to its low protein content compared to globulin fraction and the presence of some anti-nutritional compounds. In the present study, we used an alternative method of pea protein extraction based on alkaline solubilization/isoelectric precipitation in which the reduction of pH was achieved by lactic acid fermentation using specific starters instead of mineral acids. Hence, the main objective of this study was to examine the protein profile and the content of anti-nutritional and nutritional active compounds in pea albumin-rich fractions obtained by the isoelectric extraction method without (control) or with fermentation with different lactic acid bacteria (Streptococcus thermophilus, Lactiplantibacillus plantarum, and their co-culture). Different pea cultivars (Cartouche, Ascension, and Assas) were used here for their differences in protein profile. The results revealed a higher total nitrogen content in albumin-rich fraction for fermented samples and, in particular, for co-culture. The majority of total nitrogen was determined as non-protein (~50%), suggesting the degradation of proteins by LAB to small peptides and amino acids, which were solubilized in the soluble fraction (albumin) as confirmed by size exclusion chromatography (SEC-HPLC) analysis. Moreover, the higher antioxidant activity of fermented albumin samples was attributed to the production of small peptides during extraction. Lactic acid fermentation also resulted in a significant reduction of trypsin inhibitor activity, α-galactoside, and phytic acid content of this fraction compared to control.

Formulation of Gluten-Free Cookies Utilizing Chickpea, Carob, and Hazelnut Flours through Mixture Design

Legume flours, which offer high nutritional quality, present viable options for gluten-free bakery products. However, they may have an objectionable flavor and taste for some consumers. In this study, it was aimed to improve the gluten-free cookie formulation by incorporating carob and hazelnut flours to pre-cooked chickpea flour and to investigate the techno-functional properties of the formulated cookies. The flours used in the formulations were assessed for their chemical and physical properties. This study employed a mixture design (simplex-centroid) to obtain the proportions of the flours to be used in the cookie formulations. The rheological characteristics of the doughs and the technological attributes of the baked cookies were determined. The addition of the hazelnut and carob flours had the overall effect of reducing the rheological characteristics of the cookie doughs. Furthermore, the textural attribute of the hardness of the baked cookies decreased as the ratio of hazelnut flour in the formulations was raised. The analysed results and sensory evaluation pointed to a formulation consisting of 30% pre-cooked chickpea/30% carob/30% hazelnut flours, which exhibited improved taste and overall acceptability scores. A total of 16.82 g/100 g of rapidly digestible starch, 5.36 g/100 g of slowly digestible starch, and 8.30 g/100 g of resistant starch exist in this particular cookie. As a result, combinations of chickpea, hazelnut, and carob flours hold promise as good alternatives for gluten-free cookie ingredients and warrant further exploration in the development of similar products.

Techno-Functional and In Vitro Digestibility Properties of Gluten-Free Cookies Made from Raw, Pre-Cooked, and Germinated Chickpea Flours

Chickpea flour, which is produced in various forms, has high protein and fiber content; therefore, it can be a good ingredient for gluten-free cookies. The objective of this study was to investigate and compare the properties of cookies formulated using raw (RCF), cooked (CCF), and germinated (GCF) chickpea flours. The techno-functional properties of these flours were determined, and scanning electron microscope images and mid-infrared spectra were obtained. The rheological properties of cookie doughs were measured along with their mid-infrared spectra. Baked cookies were analyzed for their technological properties as well as their in vitro digestion properties. Sensory analysis was also performed for all the cookies. The most significant difference among the flours was observed in their water retention capacity, and CCF had 119.7% higher water retention capacity compared to RCF. The dough made with CCF had quite different rheological properties from the others. The cookies baked with GCF had the highest baking loss and spread ratio. The CCF-containing cookies had the hardest structure. The cookies made from RCF had a higher resistant starch content followed by the cookies with GCF. All the cookies had similar scores in all aspects tested in the sensory analysis. The use of three different forms of chickpea flour in cookie formulations resulted in products with very different properties; however, their overall acceptability levels were close.

Evaluation of corn steep liquor as fermentation media for recombinant Lactococcus lactis producing antifreeze proteins

BACKGROUND

Corn processing byproducts corn steep liquor (CSL), and thin stillage were evaluated as growth media for recombinant Lactococcus lactis modified to produce antifreeze proteins (AFPs) that could have important food and non-food applications. The AFP III sequence from ocean pout was cloned into a shuttle vector to make an expression vector that facilitated the production of recombinant AFP III in Lactococcus lactis. Light CSL from yellow dent corn and thin stillage from the industrial corn bioethanol process were optimized as fermentation media with a combination of the following additives and trace elements: disodium-β-glycerophosphate (DG), tryptone (T), ascorbic acid (AA), iron (Fe), zinc (Zn), and magnesium (Mg). The growth of wild-type and recombinant Lactococcus lactis strains were compared over a 72 h period in 96-well plates and 250 mL shake flasks.

RESULTS

The corn coproducts media consisting of 50% (v/v) light steep in water supplemented with DG-5 g L^-1 , T-5 g L^-1 , AA-0.5 g L^-1 , and Zn-4 ppm resulted in best growth and was considered as the best-optimized media. The addition of additives and trace elements better supported the growth of both wild-type and recombinant Lactococcus lactis strains compared to control media without any additives. Respective fermentation supernatants were frozen to -20 °C, and the time to supercool and freeze was compared. A distinct supercooling effect was observed for the supernatants from recombinant strains thus, extending the time and temperature of supercooling and freezing. The maximum time of supercooling extended was 17.55 ± 4.45 min for thin stillage followed by M17 media (17.25 ± 4.45 min), Kent Corporation CSL (10.80 ± 2.12 min), and yellow dent CSL (6.9 ± 0.85 min) when fermented with recombinant Lactococcus lactis strains.

CONCLUSION

The supplemented corn coproduct-based media enhanced the growth of both wild-type and recombinant Lactococcus lactis strains. These optimized media can replace or supplement more expensive media (e.g. M17), potentially reducing cost. The fermentation supernatants exhibited longer times to supercool, and freeze compared to control supernatants, indicating potential use as antifreeze compounds in frozen food and non-food applications. © 2023 The Authors. Journal of The Science of Food and Agriculture published by John Wiley & Sons Ltd on behalf of Society of Chemical Industry.

Biotransformation of gluten-free composite flour mediated by probiotics via solid-state fermentation process conducted under different moisture contents

Staple foods produced from composite flour are considered feasible to alleviate protein-energy malnutrition (PEM). However, one of the major limitations of composite flour is poor protein digestibility. The biotransformation process mediated by probiotics via solid-state fermentation (SSF) holds a promising potential to address the poor protein digestibility in composite flour. Yet, there is no report established in this regard to the best of our knowledge. Therefore, 4 strains of Lactiplantibacillus plantarum and Pediococcus pentosaceus UP2 isolated from Malaysian foods that were previously reported to produce versatile extracellular hydrolytic enzymes were employed to biotransform gluten-free composite flour derived from rice, sorghum, and soybean. The SSF process was performed under 30-60% (v/w) moisture content for 7 days, where samples were withdrawn at 24 h intervals for various analyses such as pH, total titratable acidity (TTA), extracellular protease activity, soluble protein concentration, crude protein content, and in vitro protein digestibility. The pH of the biotransformed composite flour showed a significant reduction from the initial range of pH 5.98-6.67 to the final pH of 4.36-3.65, corresponding to the increase in the percentage of TTA in the range of 0.28-0.47% to 1.07-1.65% from days 0 to 4 and remained stable till day 7 of the SSF process. The probiotics strains exhibited high extracellular proteolytic activity (0.63-1.35 U/mg to 4.21-5.13 U/mg) from days 0 to 7. In addition, the treated composite flour soluble protein increased significantly (p ≤ 0.05) (0.58-0.60 mg/mL to 0.72-0.79 mg/mL) from days 0 to 7, crude protein content (12.00-12.18% to 13.04-14.39%) and protein digestibility (70.05-70.72% to 78.46-79.95%) from days 0 to 4 of SSF. The results of biotransformation of 50% (v/w) moisture content were mostly comparable to 60% (v/w) moisture content, implying 50% (v/w) moisture content was the most suitable moisture content for the effective biotransformation of gluten-free composite flour mediated by probiotics via SSF since flour quality is better at lower moisture content. As for the overall performance, L. plantarum RS5 was ranked the best strain, attributed to the general improvement in the physicochemical properties of composite flour.

Underlying evidence for the health benefits of fermented foods in humans

Fermented foods (FFs) have been a part of our diets for millennia and comprise highly diverse products obtained from plants and animals all over the world. Historically, fermentation has been used to preserve food and render certain raw materials edible. As our food systems evolve towards more sustainability, the health benefits of FFs have been increasingly touted. Fermentation generates new/transformed bioactive compounds that may occur in association with probiotic bacteria. The result can be specific, advantageous functional properties. Yet, when considering the body of human studies on the topic, whether observational or experimental, it is rare to come across findings supporting the above assertion. Certainly, results are lacking to confirm the widespread idea that FFs have general health benefits. There are some exceptions, such as in the case of lactose degradation via fermentation in individuals who are lactose intolerant; the impact of select fermented dairy products on insulin sensitivity; or the benefits of alcohol consumption. However, in other situations, the results fail to categorically indicate whether FFs have neutral, beneficial, or detrimental effects on human health. This review tackles this apparent incongruity by showing why it is complex to test the health effects of FFs and what can be done to improve knowledge in this field.

A review of thermosensitive antinutritional factors in plant-based foods

Legumes and cereals account for the vast proportion of people's daily intake of plant-based foods. Meanwhile, a large number of antinutritional factors in legumes and cereals hinder the body absorption of nutrients and reduce the nutritional value of food. In this paper, the antinutritional effects, determination, and passivation methods of thermosensitive antinutritional factors such as trypsin inhibitors, urease, lipoxygenase, and lectin were reviewed to provide theoretical help to reduce antinutritional factors in food and improve the utilization rate of plant-based food nutrition. Since trypsin inhibitors and lectin have been more extensively studied and reviewed previously, the review mainly focused on urease and lipoxygenase. This review summarized the information of thermosensitive antinutritional factors, trypsin inhibitors, urease, lipoxygenase, and lectin, in cereals and legumes. The antinutritional effects, and physical and chemical properties of trypsin inhibitors, urease, lipoxygenase, and lectin were introduced. At the same time, the research methods for the detection and inactivation of these four antinutritional factors were also summarized in the order of research conducted time. The rapid determination and inactivation of antinutrients will be the focus of attention for the food industry in the future to improve the nutritional value of food. Exploring what structural changes could passivation technologies bring to antinutritional factors will provide a theoretical basis for further understanding the mechanisms of antinutritional factor inactivation. PRACTICAL APPLICATIONS: Antinutritional factors in plant-based foods hinder the absorption of nutrients and reduce the nutritional value of the food. Among them, thermosensitive antinutritional factors, such as trypsin inhibitors, urease, lipoxygenase, and lectins, have a high proportion among the antinutritional factors. In this paper, we investigate thermosensitive antinutritional factors from three perspectives: the antinutritional effect of thermosensitive antinutritional factors, determination, and passivation methods. The current passivation methods for thermosensitive antinutritional factors revolve around biological, physical, and chemical aspects, and their elimination mechanisms still need further research, especially at the protein structure level. Reducing the level of antinutritional factors in the future food industry while controlling the loss of other nutrients in food is a goal that needs to be balanced. This paper reviews the antinutritional effects of thermosensitive antinutritional factors and passivation methods, expecting to provide new research ideas to improve the nutrient utilization of food.

Effect of Lactic Fermentation and Cooking on Nutrient and Mineral Digestibility of Peas

Peas are prospectively beneficial legumes in the human diet, and especially in a vegan and vegetarian diet, due to their high content of proteins and starch. Their frequent lack of appeal in human nutrition can be caused by their bloating effect and the content of some antinutritional compounds inhibiting the absorption of important nutrients. This study brings a comprehensive comparison of the nutrient content of pea flour after cooking and lactic fermentation before and after digestion in vitro. As a control sample, raw pea flour was used (sample 1). Raw pea flour was cooked for 10 min (sample 2) and 120 min (sample 3) at 100°C or it was fermented by Lactobacillus plantarum (sample 4) and cooked for 10 min at 100°C (sample 5). The samples were analyzed for protein and amino acids content, maltose, glucose, raffinose, total polyphenols, phytic acid, phytase, and mineral composition (P, Mg, Mn, Fe, Cu, Zn) before and after in vitro digestion. The results showed a significant (p &lt; 0.05) increase in the protein digestibility of samples 3, 4 and 5. In the fermented samples were observed a higher concentration of Cys, Met, and Gln when compared to non-fermented samples. The fermentation of pea flour resulted in a significant (p &lt; 0.05) decrease in glucose, maltose, and raffinose content. Cooking of pea flour for 10 and 120 min, but not fermenting, significantly (p &lt; 0.05) decreased the polyphenols content. Cooking and fermentation together did not affect phytic acid concentration and phytase activity. Mg, Mn, Fe, Cu and, Zn concentration in pea flour was significantly (p &lt; 0.05) decreased by cooking. On the other hand, fermentation significantly (p&lt;0.05) improved the bioaccessibility of Mn and Fe. These findings suggest that lactic fermentation of pea flour is a promising culinary preparation that can improve the digestibility of peas.